1997 FORD RANGER transmission fluid

164
*
[GF08742(R)05/96]
Speed limiter
[GF08744(R)05/96]
All models are equipped with a Powertrain Control Module
(PCM) which limits the maximum engine speed and thus road
speed in top gear. Vehicle operation is normal since the
controlled maximum speed is above posted highway speeds in
North America.
*
[GF08746(R)05/96]
Power Braking
*
[GF08748(R)05/96]
Increasing the engine speed above idle without vehicle
movement (such as holding the brake) in a forward or reverse
gear causes transmission stall.
*
[GF08749(R)05/96]
NOTE: Continued operation in the stall condition can result
in transmission overheat, malfunction or fluid
expulsion.
*
[GF08752(R)05/96]
Automatic Overdrive Transmission
%*
[GF08755(R)05/96]
Putting Your Vehicle in Gear
[GF08800(R)01/96]
Your vehicle's gearshift is on the steering column. The
transmission control switch is located on the end of the gearshift
lever. You can put the gearshift in any of the several positions.
[GF08915(R)01/96]
10-1/2 pica
art:0021373-A
The positions of the column-mounted gearshift
File:09ungfr.ex
Update:Thu Mar 20 08:55:24 1997

Driving
185
*
[GF20000(R)01/96]
Sand
*
[GF20100(R)01/96]
When driving over sand, try to keep all four wheels of the
vehicle on the most solid area of the trail. Do not reduce the
tire pressures but shift to a lower gear and drive steadily
through the terrain. Apply accelerator slowly and avoid
spinning the wheels.
*
[GF20200(R)01/96]
Mud and Water
*
[GF20300(R)01/96]
When driving through water, determine the depth; avoid water
higher than the bottom of the hubs (if possible) and proceed
slowly. If the ignition system gets wet, the vehicle may stall.
*
[GF20400(R)01/96]
Once through water, always try the brakes. Wet brakes do not
stop the vehicle as effectively as dry brakes. Drying can be
improved by moving your vehicle slowly, while applying light
pressure on the brake pedal.
*
[GF20500(R)01/96]
After driving through mud, clean off residue stuck to rotating
driveshafts and tires. Excess mud stuck on tires and rotating
driveshafts causes an imbalance which could damage drive
components.
*
[GF20525(R)03/96]
NOTE: If the transmission and transfer case is submerged in
water, their fluids should be checked and changed, if
necessary.
File:09ungfr.ex
Update:Thu Mar 20 08:55:24 1997

Maintenance and Care
271
%*
[MC22980(R)01/96]
Driveline Universal Joint and Slip Yoke
*
[MC22982(R)03/96]
The universal joints that come standard with your vehicle do
not require lubrication. If your original equipment universal
joints are replaced with universal joints equipped with grease
fittings, lubrication will be necessary at the intervals shown in
theMaintenance Schedulebooklet.
*
[MC22986(R)05/96]
Your vehicle may be equipped with a constant velocity or
double cardan joint at the transfer case end of the driveshaft.
The front driveshaft double cardan joint may be fitted with a
flush type grease fitting that requires an adapter to permit
proper lubrication. Lubricate the drive joint according to the
intervals shown in theMaintenance Schedulebooklet.
[MC22990(R)01/96]
7-1/2 pica art:0021194-A
Double cardan joint
%*
[MC23000(R)01/96]
Automatic Transmission Fluid
[MC23010(R)05/96]
Under normal driving conditions your automatic transmission
does not use up transmission fluid. However, it is recommended
that you check the transmission fluid at least twice a year.
Vehicles under severe driving conditions must have the fluid
changed every 50,000 miles. If the transmission is not working
properly, for example, the transmission may slip or shift slowly,
or if you notice some sign of fluid leakage, the fluid level
should be checked.
File:11unmcr.ex
Update:Thu Mar 20 08:58:43 1997

Maintenance and Care
273
%*
[MC23050(R)01/96]
Adding Automatic Transmission Fluid
*
[MC23053(R)01/96]
The fluid type is stamped on the dipstick.Before adding any
fluid, be sure that the correct type will be used.
*
[MC23055(R)01/96]
Add fluid in 1/2 pint (.25L) increments through the filler tube
to bring the level to the correct area on the dipstick. If an
overfill occurs, excess fluid should be removed by a qualified
technician.
%*
[MC23057(R)05/96]
NOTE: Always dispose of used automotive fluids in a
responsible manner. Follow your community's
standards for disposing of these types of fluids. Call
your local recycling center to find out about recycling
automotive fluids.
[MC23060(R)01/96]
7-1/2 pica art:0021193-A
Automatic transmission dipstick
File:11unmcr.ex
Update:Thu Mar 20 08:58:43 1997

274
%*
[MC23100(R)01/96]
Manual Transmission and Transfer Case
Fluid
[MC23110(R)04/96]
Checking the Manual Transmission Fluid
*
[MC23112(R)01/96]
Clean the filler plug on the side of the case. Remove the filler
plug. The fluid level should be up to the bottom of the filler
plug hole.
*
[MC23114(R)01/96]
If additional fluid is required:
[MC23116(R)04/96]1.
Add enough fluid through the filler plug hole to bring the
level up to the bottom of the hole. Use only fluid certified to
meet Ford Motor Company lubricant specification as listed
underRefill Capacities, Motorcraft Parts, and Lubricant
Specifications, later in this chapter.
*
[MC23118(R)01/96]2.
Replace the filler plug in its original position, making sure it
is fully seated.
%*
[MC23300(R)01/96]
Battery
*
[MC23310(R)01/96]
Your vehicle may have a Motorcraft maintenance-free battery.
The Motorcraft maintenance-free battery does not require
additional water during its life of service. The vents are part of
the cover and cannot be removed. For longer, trouble-free
operation, keep the top of the battery clean and dry. Also, make
certain the battery cables are tightly fastened to the battery
terminals.
*
[MC23312(R)01/96]
If you see any corrosion on the battery cables or terminals,
remove the cables from the terminal and clean them both with a
wire brush. You can neutralize the acid with a solution of
baking soda and water. Reinstall the cables when you are done
cleaning them, and apply a small quantity of grease to the top
of each battery terminal to help prevent corrosion.
File:11unmcr.ex
Update:Thu Mar 20 08:58:43 1997

344
Audio system (see Electronic sound system)........ 27
Autolamp system (see Headlamps)............ 63
Automatic transmission
fluid, adding.................... 273
fluid, checking................... 272
fluid, specification.................. 313
Axle
lubricant specifications................ 313
traction lok..................... 170
B
Basic vehicle warranty.................. 3
Battery
acid, treating emergencies............238, 275
battery saver..................... 97
charging system warning light............. 15
disconnecting.................... 241
how to service................... 274
jumping a disabled battery.............. 237
maintenance-free.................. 274
proper disposal, recycling.............. 275
replacement, specifications.............. 311
servicing...................... 274
voltage gauge.................. 15,19
when storing your vehicle.............. 309
Brake fluid
brake warning light.................. 10
checking and adding................ 261
description..................... 261
specifications.................... 313
Brakes
adjustment..................... 155
anti-lock...................... 155
applying the brakes................. 159
brake warning light.................. 10
fluid, checking and adding.............. 261
fluid, refill capacities................ 261
fluid, specifications................. 313
File:unixr.ex
Update:Thu Mar 20 09:01:44 1997

347
Index
Climate control system.................. 64
Clock........................ 34,55
Clutch
fluid........................ 263
fluid reservoir.................261, 263
operation while driving............... 170
recommended shift speeds.............. 173
shifting the gears.................. 171
specifications.................... 313
Cold engine starting.................. 148
Combination lap and shoulder belts.........110, 112
Controls
mirrors........................ 86
power seat..................... 109
Convenience kit in cargo area.............. 229
Coolant (see Engine coolant)
checking and adding................ 265
preparing for storage................ 309
specifications.................... 313
temperature gauge.................. 22
warnings...................... 265
Cooling fan...................... 250
Crankcase emission filter................ 311
Customer Assistance Centre, Ford of Canada....... 324
D
Daytime running light system.............. 63
Defects, reporting................... 315
Defrost, windshield................. 67,70
Dipstick
automatic transmission fluid...........271, 273
engine oil..................... 258
power steering fluid................. 268
Disabled vehicle (see Towing).............. 242
File:unixr.ex
Update:Thu Mar 20 09:01:44 1997

355
Index
Lubricant specifications................. 313
Lug nuts
standard...................... 233
tightening sequence................. 230
M
Maintenance schedule and record (see separate
Maintenance Schedule and Record booklet)..... 3
Maintenance (see Servicing)............... 249
Manual transmission
clutch....................... 170
fluid, checking and adding.............. 274
lubricant specifications................ 313
shifting gears.................... 171
shift speeds..................... 173
Master cylinder, brakes................. 261
Mileage, calculating fuel economy............ 294
Mirrors
dual electric remote control.............. 86
side view mirrors (power)............... 86
Motorcraft parts.................... 311
N
National Highway Traffic Safety Administration..... 315
New vehicle break-in.................. 5
O
Octane rating..................... 290
Odometer
description...................... 25
trip odometer..................... 25
Oil filter.....................260, 311
Oil (see Engine oil).................. 257
Oil viscosity...................... 257
On-board diagnostic (OBD II) system.......... 297
Overdrive.....................167, 169
Overseas offices.................... 325
File:unixr.ex
Update:Thu Mar 20 09:01:44 1997