1997 FORD RANGER maintenance

Maintenance and Care
297
%*
[MC42450(R)01/96]
Information about your vehicle's emission control system is on
the Vehicle Emission Control Information decal located on or
near the engine. This decal identifies engine displacement and
gives some tune-up specifications.
%*
[MC42460(R)03/96]
How to Prepare Your Vehicle for
Inspection/Maintenance (I/M) Testing
*
[MC42470(R)04/96]
In some localities it may become a legal requirement to pass an
Inspection/Maintenance (I/M) test of the On-Board Diagnostic
(OBD) II system. If your check engine light is on, reference the
check engine light description under theWarning Lights and
Gaugessection. Your vehicle may not pass an I/M test with the
check engine light on. If the vehicle's powertrain system or its
battery has just been serviced, the OBD II system is reset to a
not ready for I/M testing condition. To prepare for I/M testing,
additional city and highway driving is necessary to complete the
check of the OBD II system.
*
[MC43000(R)05/96]
The driving modes required to reach the ready condition consist
of a minimum of 30 minutes of city and highway driving as
described below:
[MC43100(R)03/96]
n
20 minutes of driving in stop and go city-type traffic with at
least four (4) idle periods.
*
[MC43200(R)03/96]
n
10 minutes of driving on an expressway or highway
[MC43300(R)03/96]
Before completing the above driving modes, the engine must be
warmed up and operating temperature. Once started, the vehicle
must not be turned off during the above driving modes. If the
vehicle owner is unable to meet the I/M requirements by using
these driving patterns, an authorized service center can perform
a detailed OBD II Drive Cycle as it would any other type of
repair work.
File:11unmcr.ex
Update:Thu Mar 20 08:58:43 1997

Maintenancean dCare
299
WARNING
Handl ea haloge nheadlam pbul bcarefull yan dkee pout
File:11unmcr.ex

Maintenance and Care
301
[MC47415(R)01/96]
Tail Lamp Bulb
[MC47420(R)01/96]
Removing the tail lamp bulb
[MC47425(R)01/96]1.
Remove the four (4) screws retaining rear lamp to vehicle.
[MC47430(R)01/96]2.
Remove rear lamp.
[MC47435(R)01/96]3.
Remove socket from lamp.
[MC47440(R)01/96]4.
Remove bulb from socket.
[MC47465(R)01/96]
Installing the tail lamp bulb
[MC47470(R)01/96]1.
Install tail lamp bulb in socket.
[MC47475(R)01/96]2.
Install socket to lamp.
[MC47480(R)01/96]3.
Install lamp to vehicle.
[MC47485(R)01/96]4.
Install four (4) lamp retaining screws.
File:11unmcr.ex
Update:Thu Mar 20 08:58:43 1997

Maintenance and Care
303
*
[MC47625(R)02/96]
Bulb Specifications
[MC48200(R)05/96]
thirty-two pica
chart:0020414-MFile:11unmcr.ex
Update:Thu Mar 20 08:58:43 1997

Maintenance and Care
305
%*
[MC50030(R)01/96]
Washing and Polishing Your Vehicle
*
[MC50032(R)01/96]
Wash the outside of your vehicle, including the underside, with
a mild detergent.
*
[MC50034(R)01/96]
DO NOT:
*
[MC50036(R)01/96]
n
Wash your vehicle with hot water
*
[MC50038(R)01/96]
n
Wash your vehicle while it sits in direct sunlight
*
[MC50040(R)01/96]
n
Wash your vehicle while the body is hot
*
[MC50042(R)01/96]
Polish your vehicle to remove harmful deposits and protect the
finish.
%*
[MC50060(R)01/96]
Cleaning Chrome and Aluminum Parts
*
[MC50065(R)01/96]
Wash chrome and aluminum parts with a mild detergent. Do
not use steel wool, abrasive cleaners, fuel or strong detergents.
%*
[MC50100(R)01/96]
Cleaning Plastic Parts
*
[MC50110(R)01/96]
Some of your vehicle's exterior trim parts are plastic. Clean with
a tar and road oil remover if necessary. Use a vinyl cleaner for
routine cleaning.
*
[MC50112(R)01/96]
Do not clean plastic parts with thinners, solvents or
petroleum-based cleaners.
%*
[MC50114(R)01/96]
If you have your vehicle rustproofed, remove oversprayed
rustproofing with a tar and road oil remover. If rustproofing is
not removed from plastic and rubber parts, it can cause
deterioration.
*
[MC50116(R)01/96]
Because your vehicle's side mouldings are painted in lacquer, do
not use thinners or solvents to clean them.
%*
[MC50200(R)03/96]
NOTE: Any cleaner or polish that increases the gloss (shine)
of the upper part of the instrument panel should be
avoided. The dull finish in this area is to help protect
the driver from undesirable windshield reflection.
File:11unmcr.ex
Update:Thu Mar 20 08:58:43 1997

Maintenance and Care
307
*
[MC51560(R)01/96]
Leather
*
[MC51562(R)01/96]
For routine cleaning, wipe the surface with a soft, damp cloth.
For more thorough cleaning, wipe the surface with a leather and
vinyl cleaner or a mild soap.
%*
[MC52000(R)02/96]
Cleaning the Safety Belts
*
[MC52020(R)02/96]
Clean the safety belts with any mild soap solution that is
recommended for cleaning upholstery or carpets. Do not bleach
or dye the belt webbing because this may weaken it.
%*
[MC52800(R)02/96]
Cleaning the Interior Lamps
*
[MC52820(R)02/96]
Your interior dome lamps and map lamps are plastic and
should be cleaned with a mild detergent diluted in water. Rinse
them with clear water.
%*
[MC56000(R)01/96]
Vehicle Storage
*
[MC56100(R)01/96]
Maintenance Tips
*
[MC56150(R)01/96]
If you plan on storing your vehicle for an extended period of
time (60 days or more), refer to the following maintenance
recommendations to ensure your vehicle stays in good operating
condition.
*
[MC56200(R)01/96]
General
*
[MC56300(R)01/96]
n
Store all vehicles in a dry, ventilated place.
*
[MC56400(R)01/96]
n
Protect from sunlight, if possible.
*
[MC56500(R)01/96]
n
If vehicles are stored outside, they require regular
maintenance to protect against rust and damage.
File:11unmcr.ex
Update:Thu Mar 20 08:58:43 1997

Maintenance and Care
309
*
[MC58100(R)01/96]
A volatile corrosion inhibitor added to the fuel system will
protect the fuel system's inner surfaces from corrosion. Follow
the instructions packaged with the product.
%*
[MC58200(R)01/96]
Cooling system
*
[MC58300(R)01/96]
n
Protect against freezing temperatures.
%*
[MC58400(R)01/96]
Battery
*
[MC58500(R)01/96]
n
Check and recharge as necessary.
*
[MC58600(R)01/96]
n
Keep connections clean and covered with a light coat of
grease.
%*
[MC58700(R)01/96]
Brakes
*
[MC58800(R)01/96]
n
Make sure brakes and parking brake are fully released.
%*
[MC58900(R)01/96]
Tires
*
[MC59000(R)01/96]
n
Maintain recommended air pressure.
*
[MC59100(R)01/96]
Miscellaneous
*
[MC59200(R)01/96]
n
Make sure all linkages, cables, levers and clevis pins under
vehicle are covered with grease to prevent rust.
*
[MC59300(R)01/96]
n
Move vehicles at least 25 feet (8 m) every 15 days to
lubricate working parts and prevent corrosion.
File:11unmcr.ex
Update:Thu Mar 20 08:58:43 1997

318
*
[HS00300(R)01/95]
If You Have a Service Problem
*
[HS00400(R)01/95]
Ford Motor Company has authorized Ford and Lincoln-Mercury
dealerships that can service your vehicle for you. This chapter
tells you how to get service or maintenance for your vehicle.
%*
[HS00525(R)02/95]
Service/Maintenance Concerns (U.S. or Canada)
*
[HS00600(R)04/95]
Ford recommends taking your vehicle to your selling dealer
who wants to ensure your continued satisfaction. You may,
however, take your vehicle to any authorized Ford or
Lincoln-Mercury dealer. In most cases, your dealer will be able
to resolve your concern.
*
[HS00700(R)04/95]
If you are not satisfied with the service you received from your
dealership's service department, talk to the service manager at
the dealership, or if you still are not satisfied, talk to the owner
or general manager of the dealership. In most cases, you will
have your concern resolved at this level.
*
[HS01000(R)04/95]
If you are away from home when your vehicle needs to be
serviced, or if you need more help than the dealer gave you,
contact the Ford Customer Assistance Center to find an
authorized dealership that may be able to help you.
*
[HS01010(R)04/95]
Please have the following information available when contacting
Ford Customer Assistance:
*
[HS01020(R)05/96]
n
your telephone number (both business and home)
*
[HS01030(R)05/96]
n
the name of the dealer and the city where the dealership is
located
*
[HS01040(R)05/96]
n
the year and make of your vehicle
*
[HS01050(R)05/96]
n
the date purchased
*
[HS01060(R)05/96]
n
the current mileage on your vehicle
%*
[HS01070(R)05/96]
n
your Vehicle Identification Number (VIN) listed on your
vehicle ownership license
File:14unhsr.ex
Update:Thu Mar 20 09:00:11 1997