1997 FORD RANGER clutch

182
[GF17140(R)05/96]
NOTE: Do not drive the vehicle with the left and right
manual locking hubs set to different positions.
*
[GF17150(R)05/96]
To shift from 4H to 2H:
*
[GF17160(R)05/96]
Move the transfer case shift lever forward to the 2H position.
This can be done at any speed. However, the front driveline
will remain engaged to the front wheels until the manual
locking hubs are disengaged. To disengage the manual locking
hubs, stop the vehicle and rotate both hub lock selector knobs
counterclockwise to the FREE position.
*
[GF17170(R)05/96]
Operating in 2H with the hubs in the LOCK position increases
fuel consumption, noise, vibration, and wear. For prolonged 2H
operation on dry pavement, set the manual locking hubs to the
FREE position.
*
[GF17180(R)05/96]
To shift between 4H and 4L:
[GF17190(R)05/96]
Stop the vehicle and place the automatic transmission into N
(Neutral) or depress the clutch on vehicles with a manual
transmission. Pull the transfer case shift lever to the left and
shift the transfer case to the desired 4H or 4L position. This
shift should be with one continuous motion without pausing in
the N position. Pausing in the neutral position can result in gear
clash and difficult shifting. If while shifting between 4H and 4L,
the transfer case gets stuck in the N position or is difficult to
shift into either 4H or 4L, it may be necessary to let the vehicle
roll slightly and/or turn off the engine (particularly on vehicles
equipped with automatic transmissions).
[GF17200(R)05/96]
To shift between N (Neutral) and either 4H or 4L
[GF17210(R)05/96]
To shift into N (Neutral), stop the vehicle and engage the
parking brake. Place the automatic transmission into N (Neutral)
or depress the clutch on manual transmission vehicles. From
either the 4H or 4L position, pull the transfer case shift lever to
the left and move the transfer case shift lever to the N (Neutral)
position. The N (Neutral) position should only be used for
vehicle towing.
File:09ungfr.ex
Update:Thu Mar 20 08:55:24 1997

Maintenance and Care
263
[MC17400(R)05/96]
Clutch Fluid (If equipped)
*
[MC17405(R)01/96]
During normal operation the fluid level in the clutch reservoir
will slowly rise. If for any reason the fluid level drops, maintain
the fluid level at the step in the reservoir body.
%*
[MC17410(R)05/96]
If it becomes necessary to remove the reservoir cap, thoroughly
clean the reservoir cap before removing it to prevent dirt or
water from entering the reservoir. Remove the internal
diaphragm and then add only a DOT 3 brake fluid such as Ford
High Performance DOT 3 Brake Fluid (Ford Part Number
C6AZ-19542-AB) Ford specification ESA-M6C25-A.
*
[MC17415(R)05/96]
The clutch on your vehicle is automatically self-adjusting and
should not require any routine service.
[MC17420(R)01/96]
10-1/2 pica art:0020376-E
Clutch fluid reservoir
%*
[MC17500(R)02/96]
Windshield Washer Fluid
*
[MC17510(R)01/96]
Check the level of the windshield washer fluid every time you
stop for fuel. The reservoir for washer fluid is located on the
passenger's side of the engine compartment. Visual inspection
can determine if the washer fluid is adequate. Do not operate
the washer when the reservoir is empty.
File:11unmcr.ex
Update:Thu Mar 20 08:58:43 1997

347
Index
Climate control system.................. 64
Clock........................ 34,55
Clutch
fluid........................ 263
fluid reservoir.................261, 263
operation while driving............... 170
recommended shift speeds.............. 173
shifting the gears.................. 171
specifications.................... 313
Cold engine starting.................. 148
Combination lap and shoulder belts.........110, 112
Controls
mirrors........................ 86
power seat..................... 109
Convenience kit in cargo area.............. 229
Coolant (see Engine coolant)
checking and adding................ 265
preparing for storage................ 309
specifications.................... 313
temperature gauge.................. 22
warnings...................... 265
Cooling fan...................... 250
Crankcase emission filter................ 311
Customer Assistance Centre, Ford of Canada....... 324
D
Daytime running light system.............. 63
Defects, reporting................... 315
Defrost, windshield................. 67,70
Dipstick
automatic transmission fluid...........271, 273
engine oil..................... 258
power steering fluid................. 268
Disabled vehicle (see Towing).............. 242
File:unixr.ex
Update:Thu Mar 20 09:01:44 1997

355
Index
Lubricant specifications................. 313
Lug nuts
standard...................... 233
tightening sequence................. 230
M
Maintenance schedule and record (see separate
Maintenance Schedule and Record booklet)..... 3
Maintenance (see Servicing)............... 249
Manual transmission
clutch....................... 170
fluid, checking and adding.............. 274
lubricant specifications................ 313
shifting gears.................... 171
shift speeds..................... 173
Master cylinder, brakes................. 261
Mileage, calculating fuel economy............ 294
Mirrors
dual electric remote control.............. 86
side view mirrors (power)............... 86
Motorcraft parts.................... 311
N
National Highway Traffic Safety Administration..... 315
New vehicle break-in.................. 5
O
Octane rating..................... 290
Odometer
description...................... 25
trip odometer..................... 25
Oil filter.....................260, 311
Oil (see Engine oil).................. 257
Oil viscosity...................... 257
On-board diagnostic (OBD II) system.......... 297
Overdrive.....................167, 169
Overseas offices.................... 325
File:unixr.ex
Update:Thu Mar 20 09:01:44 1997