1997 FORD F SERIES MOTORHOME AND COMMERCIAL CHASSIS brake

113
%*
[MC18300( ALL)01/96]
Power Steering Fluid
*
[MC18350( ALL)01/96]
Check the level of the power steering fluid at
least twice a year (i.e., every Spring and Fall).
*
[MC18400( ALL)01/96]
To check the level of your power steering fluid:
*
[MC18450( ALL)01/96]
1. Start the engine and let it run until the
power steering fluid reaches normal
operating temperature. The power steering
fluid will be at the right temperature when
the engine coolant temperature gauge in the
instrument cluster is near the center of the
NORMAL operating temperature range.
*
[MC18500( ALL)01/96]
2. While the engine idles, turn the steering
wheel back and forth several times. Make
sure that the cap assembly is installed at this
time.
[MC18600( M)01/96]
3. Then turn the engine off and do not press
the brake pedal.
%*
[MC18650( ALL)01/96]
4. Check the fluid level on the dipstick (which
is highlighted in yellow in your vehicle). The
fluid level should be between the arrows in
the FULL HOT range, which is marked on
the side of the dipstick, opposite the side
marked FULL COLD. Do not add fluid if the
level is within the FULL HOT range.
File:11ltmcm.ex
Update:Fri Dec 13 11:24:54 1996

117 [MC21650( ALL)01/96]
q
Accumulating 5,000 miles (8,000 km) or more
per month.
[MC21700( ALL)01/96]
q
Continuous operation and/or extensive idling
(a delivery service as an example).
*
[MC21750( ALL)01/96]
q
Operating in severe dust conditions.
[MC21800( ALL)01/96]
NOTE: Use of a transmission fluid other than
specified could result in transmission
malfunction and/or failure. Refer to
ªAdding automatic transmission fluidº,
ªRefill capacitiesº and ªlubricant
specificationsº for further information.
%*
[MC21850( ALL)01/96]
Checking the Automatic Transmission
Fluid
[MC21875( ALL)01/96]
Transmission fluid should be checked at least
twice a year.
*
[MC21900( ALL)01/96]
It is preferable to check the transmission fluid
level at normal operating temperature
150ÊF-170ÊF (66ÊC-77ÊC),after approximately 20
miles (30 km) of driving. However, if necessary,
you can check the fluid level without having to
drive 20 miles (30 km) to obtain a normal
operating temperature if outside temperatures
are above50ÊF (10ÊC).
*
[MC21950( ALL)01/96]
NOTE: If the vehicle has been operated for an
extended period at high speeds or in
city traffic during hot weather, or
pulling a trailer, the vehicle should be
turned off for about 30 minutes to
allow the fluid to cool before checking.
*
[MC22000( ALL)01/96]
With the vehicle on a level surface, start the
engine and move the transmission shift selector
through all of the gear ranges allowing sufficient
time for each position to engage. Securely latch
the transmission shift selector in the P (Park)
position, fully set the parking brake and leave
the engine running.
File:11ltmcm.ex
Update:Fri Dec 13 11:24:54 1996

127 [MC27600( M)01/96]
RWARNING
Use only wheel assemblies approved and
released by Ford Motor Company for your
vehicle model.
[MC27650( M)01/96]
A wheel or tire of the wrong size or type may
adversely affect such things as load carrying
capacity, wheel and bearing life, brake cooling,
speedometer/odometer calibration, stopping
ability, headlight aim, bumper height, vehicle
ground clearance, and tire or tire chain clearance
to the body and chassis. Replacement with used
wheels is not advised: they may have been
treated harshly or have high mileage, and they
could fail without warning.
[MC27700( M)01/96]
The use of wheels with load carrying limits
higher than the limits of the wheels originally
installed on your vehicle does not in itself
increase the GAWR or GVWR of the vehicle.
[MC27750( M)01/96]
RWARNING
Use only wheel assemblies approved and
released by Ford Motor Company for your
vehicle model.
[MC27800( M)01/96]
RWARNING
Alterations to the vehicle suspension or
steering by raising the chassis (i.e., use of
aftermarket ªlift kitsº) may adversely
affect vehicle handling and braking
performance.
File:11ltmcm.ex
Update:Fri Dec 13 11:24:54 1996

134
*
[MC37100( ALL)01/96]
4. Use these equations to calculate your fuel
economy.
*
[MC37200( ALL)01/96]
q
English: MPG = (total miles)/(gallons used).
*
[MC37300( ALL)01/96]
q
Metric: L/100K = (liters used) x 100/(total
kilometers)
%*
[MC37700( ALL)01/96]
Improving Fuel Economy
*
[MC37800( ALL)01/96]
Fuel economy is affected by a number of
variables which can reduce efficiency. You can
improve fuel economy by understanding these
variables and minimizing their effect.
*
[MC37900( ALL)01/96]
The following decrease fuel economy:
*
[MC38000( ALL)01/96]
q
Lack of regular, scheduled maintenance
*
[MC38100( ALL)01/96]
q
Driving with your foot on the brake
*
[MC38200( ALL)01/96]
q
Sudden stops
*
[MC38300( ALL)01/96]
q
Excessive speed
*
[MC38400( ALL)01/96]
q
Extended engine idling
*
[MC38500( ALL)01/96]
q
Heavy loads
*
[MC38600( ALL)01/96]
q
Underinflated tires
*
[MC38700( ALL)01/96]
q
Extended use of the A/C, defroster, rear
window defroster and other accessories
[MC38800( M)01/96]
q
Use your air conditioning system wisely.
File:11ltmcm.ex
Update:Fri Dec 13 11:24:54 1996

153 %
*
[CS02810( ALL)01/96]
Engine
*
[CS02820( ALL)01/96]
q
Start engine every 15 days. Run at fast idle
until it reaches normal operating temperature.
*
[CS02830( ALL)01/96]
q
With your foot on the brake, shift through all
the gears while the engine is running.
%*
[CS02840( ALL)01/96]
Fuel system
%*
[CS02850( ALL)01/96]
q
Fill fuel tank with high-quality unleaded fuel
until the first automatic shutoff of the fuel
pump nozzle.
*
[CS02860( ALL)01/96]
NOTE: During extended periods of vehicle
storage (60 days or more), fuel may
deteriorate due to oxidation. This can
damage rubber and other polymers in
the fuel system and may also clog
small orifices.
*
[CS02870( ALL)01/96]
Ford Gas Stabilizer should be added whenever
actual or expected storage periods exceed 60
days. Follow the instructions on the label. The
vehicle should then be operated at idle speed to
circulate the additive throughout the fuel system.
*
[CS02890( ALL)01/96]
A volatile corrosion inhibitor added to the fuel
system will protect the fuel system's inner
surfaces from corrosion. Follow the instructions
packaged with the product.
%*
[CS02900( ALL)01/96]
Cooling system
*
[CS02910( ALL)01/96]
q
Protect against freezing temperatures.
File:12ltcsm.ex
Update:Fri Dec 13 11:25:18 1996

154 %
*
[CS02920( ALL)01/96]
Battery
*
[CS02930( ALL)01/96]
q
Check and recharge as necessary.
*
[CS02940( ALL)01/96]
q
Keep connections clean and covered with a
light coat of grease.
%*
[CS02950( ALL)01/96]
Brakes
*
[CS02960( ALL)01/96]
q
Make sure brakes and parking brake are fully
released.
%*
[CS02970( ALL)01/96]
Tires
*
[CS02980(B FM)01/96]
q
Maintain recommended air pressures.
*
[CS02990( ALL)01/96]
Miscellaneous
*
[CS03000( ALL)01/96]
q
Make sure all linkages, cables, levers and
clevis pins under vehicle are covered with
grease to prevent rust.
*
[CS03010( ALL)01/96]
q
Move vehicles at least 25 feet (10 m) every 15
days to lubricate working parts to prevent
corrosion.
File:12ltcsm.ex
Update:Fri Dec 13 11:25:18 1996

Severe Duty Schedule 175
*
[BK52401( ALL)01/95]
15,000 MILES (25,000 Kilometers)
*
[BK52501( ALL)11/95]
q
Change engine oil and replace oil filter.
*
[BK52550( ALL)06/95]
q
Inspect engine cooling system, hoses, and clamps;
and check coolant strength every 15,000 miles
(25,000 km) or 12 months.
*
[BK52601( ALL)08/95]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK52801( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK53001( ALL)08/95]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK53030( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK53035( FM)02/95]
q
Inspect parking brake fluid (F-Super Duty).
*
[BK53050( ALL)04/93]
four pica chart:0060627-A
*
[BK53101( ALL)01/95]
18,000 MILES (30,000 Kilometers)
*
[BK53201( ALL)11/95]
q
Change engine oil and replace oil filter.
*
[BK53501( ALL)09/95]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK53601( ALL)06/95]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK53610( ALL)09/95]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
File:18ltbkm.ex
Update:Thu Dec 12 13:32:30 1996

178 Severe Duty Schedule
*
[BK56300( ALL)06/95]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK56350( ALL)09/95]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK56400( ALL)08/95]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK56700( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK56900( ALL)08/95]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK57000( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK57100( ALL)08/95]
q
Inspect parking brake system for damage and
operation.
[BK57225( M)08/95]
q
Inspect parking brake fluid (F-Super Duty
only).
*
[BK57520( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK57550( ALL)04/93]
four pica chart:0060627-A
File:18ltbkm.ex
Update:Thu Dec 12 13:32:30 1996