1997 FORD EXPLORER warning

Watch for fluid leaks, strange
odors, smoke, loss of oil pressure,
the charging system warning light,
the ªService Engine Soonº light or
the temperature warning light.
These events could indicate that
the emission control system is not
working properly.
If you smell exhaust fumes
of any kind inside your
vehicle, have the dealer inspect
and fix your vehicle immediately.
Do not drive if you smell exhaust
fumes. These fumes are harmful
and could kill you.
Do not make any unauthorized
changes to your vehicle or engine.
By law, vehicle owners and anyone
who manufactures, repairs,
services, sells, leases, trades
vehicles, or supervises a fleet of
vehicles are not permitted to
intentionally remove an emission
control device or prevent it from
working. Information about your
vehicle's emission system is on the
Vehicle Emission Control
Information Decal located on or
near the engine. This decal
identifies engine displacement and
gives some tune up specifications.
Please consult your ªWarranty
Guideº for complete emission
warranty information.
Readiness for
inspection/maintenance testing
In some localities, it may be a legal
requirement to pass an I/M test of
com_ready-test
Maintenance and care
208

the on-board diagnostic (OBD-II)
system. If your ªcheck
engine/service engine soonº light is
on, reference the applicable light
description in theWarning Lights
and Gaugessection of your
owners guide. Your vehicle may
not pass the I/M test with the
ªcheck engine/service engine soonº
light on.
If the vehicle's powertrain system
or its battery has just been
serviced, the OBD-II system is
reset to a ªnot ready for I/M testº
condition. To ready the OBD-II
system for I/M testing, a minimum
of 30 minutes of city and highway
driving is necessary as described
below:
²First, at least ten minutes of
driving on an expressway or
highway.
²Next, at least twenty minutes
driving in stop and go, city type
traffic with at least four idle
periods.
Allow the vehicle to sit for at least
8 hours without starting the
engine. Then, start the engine and
complete the above driving cycle.
The engine must warm up to it's
normal operating temperature.
Once started, do not turn off the
engine until the above driving
cycle is complete.
Maintenance and care
209

Air bag supplemental restraint
system
and child safety seats ..............90
description ................................89
disposal ......................................94
indicator light ...........................93
passenger air bag .....................91
Air cleaner filter .......................192
replacing ..................................193
Air conditioning
manual heating and air
conditioning
system ...................28,29,30,31,32
Air suspension ...........................119
All wheel drive (AWD) .............134
Anti-theft system ........................65
arming the system ....................66
disarming a triggered system ..68
disarming an untriggered
system .......................................68
warning light .............................67
Autolamp system (see
Headlamps) .................................49
Automatic dimming mirror ...47,48
Battery .......................................188
battery saver ...........................192
servicing ....................188,189,190
Brakes
adjustment ..............................117
anti-lock ...................................117
fluid, checking and adding ....177
parking ....................................118
Break-in period .............................2
Built-in child seat .......102,107,108
Bulbs,
replacing ........208,210,211,212,213
specifications ..........................213
Capacities for refilling fluids ....225
Cargo area shade ........................64
Childproof locks ..........................55
Cleaning your vehicle ...............215
built-in child seat ...................220engine compartment ..............216
fabric ........................................219
instrument panel ....................219
plastic parts ............................218
safety belts ..............................220
tail lamps .................................218
washing ....................................215
waxing .....................................215
wheels ......................................216
Climate control system ..............28
automatic temperature
control ...................32,33,34,35,36
defrosting .............................59,60
Clutch
fluid ..........................................177
Compass, electronic ....................50
calibration .................................51
set zone adjustment .................51
Console, description ..............58,61
Control trac 4WD system .........128
Controls ..................................58,59
Coolant (see Engine coolant)
proper solution .......................181
Daytime running light system ...26
Differential fluid ........................187
Driveline universal joint and
slip yoke .............................176,187
Driving under special
conditions ..................................130
high water ...............................131
slippery roads ..................132,133
towing a trailer .......................144
Emission control system ..........206
Engine .................................228,231
service points ............170,171,172
Engine block heater .................116
Engine coolant
checking and adding .......180,183
checking hoses .......................184
disposal ....................................182
refill capacities ........................182
Index
233

Engine oil
changing oil and oil filter .......175
specifications ..........................173
Entry system
illumination ...............................66
Exhaust fumes ..........................112
Flashing the lights ......................45
Floor mats ..............................62,63
Foglamps .....................................27
Ford Extended Service Plan ....129
Four way head restraints ...........78
Four-Wheel Drive vehicles
control trac ........................38,128
driving off road .......................130
Fuel ............................................202
calculating fuel economy .......206
improving fuel economy ........146
octane rating ...........................204
quality ......................................205
safety information relating to
automotive fuels .....................202
Fuel gauge ...................................15
Fuel pump shut-off switch .......147
Fuses ..........................................148
Gauges, Mechanical
engine coolant temperature
gauge .........................................13
engine oil pressure gauge ........13
Hazard flashers ....................44,147
Head restraints ...........................78
Hitch ..........................................144
Hood ..........................................169
Identification Number, Vehicle
(VIN) ..........................................230
Ignition
positions of the ignition ...........39
Jack ..............................................63
Jump-starting your vehicle 160,162
attaching cables ......................161
disconnecting cables ..............162
Keyless entry system
autolock .....................................76keypad .......................................74
locking and unlocking doors ....74
programming entry code .........75
Lamps
instrument panel, dimming .....26
Liftgate ........................................57
Lights, warning and indicator
air bag ........................................11
anti-lock brakes (ABS) ............11
anti-theft .....................................9
brake ..........................................11
charging system ........................10
check engine ...............................9
door ajar ....................................10
four-wheel drive ..........................9
fuel reset ...................................10
high beam .................................11
overdrive off ................................8
safety belt .......................11,87,88
Luggage rack .............................146
Manual transmission
driving .......................121,125,127
fluid, checking and adding ....187
Message center ..16,17,18,19,20,52
air ride switch off .....................21
change oil soon .........................21
check air ride system ...............20
check charging system .............22
check engine temperature .......22
check exterior lamps ................22
door ajar ....................................24
low fuel level .............................24
low oil level ...............................24
low washer fluid .......................24
warning messages .....................20
Moon roof ....................................54
Motorcraft parts ........................222
Odometer .....................................14
Overdrive ................................45,46
Overhead console
storage compartment ...............52
Parking brake ..............................28
Index
234

Voltmeter (see Battery voltage
gauge) ..........................................15
Warning chimes
headlamps on ............................11
key in ignition ...........................12
safety belt .................................12
Washer fluid
reservoir ..................................179
Windows
power windows, operating .......56Windshield washer fluid and
wipers ........................................193
checking and adding fluid .....178
checking and replacing wiper
blades ...............................193,194
liftgate reservoir .....................179
operation ...................................46
specifications ..........................178
Wrecker towing .........................163
236