1997 FORD EXPLORER ABS

Maxi fuses
10 - Not used
11 20 HEGO system
Relay number Circuits connected
1 Wiper run relay
2 Horn relay
3 Wiper HI/LO relay
4 WOT A/C relay
5 PCM power relay
6 Fuel pump relay
Diode number Circuits connected
1 ABS diode
2 PCM diode
Relays
Relays are located in the power
distribution box.
Relays receive signals from
components or systems and
transfer these signals to activate or
deactivate other components or
systems.
Ford recommends that relays be
replaced by a qualified service
technician.
6
5
3
2
14 21
uno_relays
Roadside emergencies
155

Relay number Circuits protected
1 Wiper run relay
2 Horn relay
3 Wiper HI/LO relay
4 WOT A/C relay
5 PCM power relay
6 Fuel pump relay
Diode number Circuits protected
1 ABS diode
2 PCM diode
CHANGING TIRES
Tire change procedure
1. Park on a level surface.
2. Activate the hazard flashers.
²Before beginning the tire change
procedure, ensure that the
Automatic Ride Control service
switch is turned off.
0P RND21
UNLEADED
FUEL ONLY
RPM x 100012345
6H
C
F
E
RSM
SET
ACC
COAST OFF ON
SRS
- +H
H
L L020
1030405060
70
80
90
110
120000000oooo
km/h10020406080100
120
140
160
180
uno_tire_change_procedure
Roadside emergencies
156

The fuel system may be
under pressure. If the fuel
cap is venting vapor or if you
hear a hissing sound, wait until it
stops before completely
removing the cap.
Automotive fuels can
cause serious injury or
death if misused or mishandled.
Observe the following guidelines
when handling automotive fuel:
²Extinguish all smoking materials
and any open flames before
fueling your vehicle.
²Always turn off the vehicle
before fueling.
²Automotive fuels can be harmful
or fatal if swallowed. If fuel is
swallowed, call a physician
immediately, even if no
symptoms are immediately
apparent. The toxic affects of
fuel may not be visible for
hours.
²Fuels can also be harmful if
absorbed through the skin. If
fuel is splashed on the skin,
promptly remove contaminated
clothing and wash skin
thoroughly with soap and water.
²If fuel is splashed in the eyes,
remove contact lenses, flush
with water for 15 minutes and
seek medical attention.
²Be particularly careful if you are
taking ªAntabuseº or other
Maintenance and care
203

Replacing the headlamps
1. With the flat side of the bulb's
base facing upward, insert the
glass end of the bulb into the
socket. Turn the bulb left or right
to line up the grooves in the
plastic base with the tabs in the
socket. Push the bulb into the
socket until the plastic base
contacts the rear of the socket.
2. Slip the retaining ring over the
plastic base until it hits the rear of
the socket. Lock the ring by
rotating it clockwise until you feel
it stop.
3. Press the electrical connector
into the rear of the plastic base
until it snaps, locking it into
position.
4. Turn the headlamps on and
ensure they work properly.
Foglamps (if equipped)
1. Disconnect the electrical
connector from the back of the
foglamp by turning it
counterclockwise.
2. Remove the bulb by lifting the
retaining clip and pulling the bulb
from the assembly.
3. Replace the bulb and insert the
bulb assembly back into the
foglamp.
LIFT
uno_foglamps
Maintenance and care
211

Engine oil
changing oil and oil filter .......175
specifications ..........................173
Entry system
illumination ...............................66
Exhaust fumes ..........................112
Flashing the lights ......................45
Floor mats ..............................62,63
Foglamps .....................................27
Ford Extended Service Plan ....129
Four way head restraints ...........78
Four-Wheel Drive vehicles
control trac ........................38,128
driving off road .......................130
Fuel ............................................202
calculating fuel economy .......206
improving fuel economy ........146
octane rating ...........................204
quality ......................................205
safety information relating to
automotive fuels .....................202
Fuel gauge ...................................15
Fuel pump shut-off switch .......147
Fuses ..........................................148
Gauges, Mechanical
engine coolant temperature
gauge .........................................13
engine oil pressure gauge ........13
Hazard flashers ....................44,147
Head restraints ...........................78
Hitch ..........................................144
Hood ..........................................169
Identification Number, Vehicle
(VIN) ..........................................230
Ignition
positions of the ignition ...........39
Jack ..............................................63
Jump-starting your vehicle 160,162
attaching cables ......................161
disconnecting cables ..............162
Keyless entry system
autolock .....................................76keypad .......................................74
locking and unlocking doors ....74
programming entry code .........75
Lamps
instrument panel, dimming .....26
Liftgate ........................................57
Lights, warning and indicator
air bag ........................................11
anti-lock brakes (ABS) ............11
anti-theft .....................................9
brake ..........................................11
charging system ........................10
check engine ...............................9
door ajar ....................................10
four-wheel drive ..........................9
fuel reset ...................................10
high beam .................................11
overdrive off ................................8
safety belt .......................11,87,88
Luggage rack .............................146
Manual transmission
driving .......................121,125,127
fluid, checking and adding ....187
Message center ..16,17,18,19,20,52
air ride switch off .....................21
change oil soon .........................21
check air ride system ...............20
check charging system .............22
check engine temperature .......22
check exterior lamps ................22
door ajar ....................................24
low fuel level .............................24
low oil level ...............................24
low washer fluid .......................24
warning messages .....................20
Moon roof ....................................54
Motorcraft parts ........................222
Odometer .....................................14
Overdrive ................................45,46
Overhead console
storage compartment ...............52
Parking brake ..............................28
Index
234

Power door locks ........................54
Power steering
fluid, checking and adding ....184
Rear window
wiper .....................................37,38
Refill capacities for fluids ........223
Relays ..........................149,150,153
Remote entry system .................69
locking/unlocking doors ......69,70
panic alarm ...............................70
replacement/additional
transmitters ...............................73
replacing the batteries .............72
Reporting safety defects ..........232
Restraints, safety (see Safety
restraints)
head ...........................................78
Safety restraints
adjusting the safety belts ....86,87
energy absorbing sew
pattern ..................................88,89
for children ...............................95
proper use ..................83,84,85,86
Safety seats for children
attaching with tether straps ..101
automatic locking mode
(retractor) ............................97,98
Seats ............................................79
adjusting the seat, power ........80
bench (60-40 split) ..................79
Servicing your vehicle ..............165
precautions when servicing ...165
servicing when you tow .........145
Snowplowing .................................4
Special notice ................................3
ambulance conversions ..............3
utility-type vehicles ....................3
Specification chart, lubricants .225
Speed control ..............................40
indicator light ........................8,43
Speedometer ...............................14
Starting your vehicle ................110preparing to start your
vehicle .....................................112
starting a warm engine ..........115
Steering wheel
tilting .........................................44
Storage compartments
overhead storage
compartment .............................52
Tachometer
mechanical cluster ...................15
Tires
changing ..................................156
checking the pressure ............197
inspection and maintenance ..195
replacing ..................................199
rotating ....................................198
snow tires and chains ............201
spare tire .................................156
tire grades ...............................195
treadwear ................................196
Traction-lok rear axle ...............119
Trailer towing ............................138
safety chains ...........................143
tips ....................................139,144
trailer brakes ...........................143
trailer lamps ............................143
Transfer case (see Differential
fluid) ..........................................188
Transmission
fluid, checking and adding
(automatic) .............................186
Trip odometer .............................14
Turn signal
indicator lights ............................9
Two step lock ..............................54
Vehicle dimensions ...................228
Vehicle headlamp aiming
device (VHAD) .........................214
Vehicle Identification Number
(VIN) ..........................................230
Ventilating your vehicle ...........111
Index
235