1997 FORD CONTOUR headlamp

Maintenance and Care
219
%*
[MC32300(ALL)03/96
]
How to Prepare Your Vehicle for
Inspection/Maintenance (I/M) Testing
*
[MC32400(ALL)05/96]
In some localities it may become a legal requirement to pass an
Inspection/Maintenance (I/M) test of the On-Board Diagnostic
(OBD) II system. If the vehicle's powertrain system or its battery
has just been serviced, the OBD II system is reset to a not ready
for I/M testing condition. To prepare for I/M testing, the law
specifies that additional mixed city and highway driving is
required to complete the check of the OBD II system.
*
[MC32500(ALL)05/96]
OBD II Drive Cycle
*
[MC32601(ALL)05/96]
The driving modes required to reach the ready condition consist
of a minimum of 30 minutes of city and highway driving as
described below:
*
[MC32701(ALL)05/96]
n
At least twenty minutes driving in stop and go, city type
traffic with at least four idle periods.
*
[MC32801(ALL)05/96]
n
At least ten minutes of driving on an expressway or
highway.
*
[MC32901(ALL)05/96]
Before completing the above driving modes, the engine must be
warmed up and at operating temperature. Once started, the
vehicle must not be turned off during these driving modes.
%*
[MC34300(ALL)03/96]
Lights and Bulb Replacement
*
[MC34400(ALL)01/96]
It is a good idea to check the operation of the following lights
frequently:
*
[MC34500(ALL)01/96]
n
headlamps
*
[MC34600(ALL)01/96]
n
tail lamps
*
[MC34700(ALL)01/96]
n
brakelamps
*
[MC34800(ALL)01/96]
n
high-mount brakelamp
*
[MC34900(ALL)01/96]
n
hazard flasher
File:11cdmco.ex
Update:Thu Sep 12 11:08:18 1996

220
*
[MC35000(ALL)01/96]
n
turn signals
*
[MC35100(ALL)01/96]
n
side markers
*
[MC35200(ALL)05/96]
n
license plate lamps
%*
[MC35300(ALL)01/96
]
The alignment of your headlamps should be checked if:
*
[MC35400(ALL)01/96]
n
oncoming motorists frequently signal you to turn off your
vehicle's high beams when you do not have the high beams
on
*
[MC35500(ALL)01/96]
n
the headlamps do not seem to give you enough light to see
clearly at night
[MC35600(ALL)04/96]
n
the headlamps are not aligned so that they point slightly
down and to the right.
%*
[MC35700(ALL)01/96
]
Headlamp Bulb
[MC35800(ALL)12/95]
The headlamps on your vehicle use replaceable bulbs, one for
high beam and one for low beam on each side. When the lamp
burns out, simply replace the bulb, rather than the whole lamp.
*
[MC35900(ALL)01/96]
RWARNING
Handle a halogen headlamp bulb carefully and keep out
of children's reach. Grasp the bulb only by its plastic
base and do not touch the glass. The oil from your hand
could cause the bulb to break the next time the
headlamps are operated.
*
[MC36000(ALL)01/96]
Do not remove the burned-out bulb unless you can immediately
replace it with a new one. If a bulb is removed for an extended
period of time, contaminants may enter the headlamp housing
and affect its performance.
File:11cdmco.ex
Update:Thu Sep 12 11:08:18 1996

Maintenance and Care
221
*
[MC36100(ALL)03/96]
Removing the headlamp bulb
*
[MC36200(ALL)01/96]1.
Make sure that the headlamp knob is in the OFF position.
*
[MC36300(ALL)01/96]2.
Lift the hood and find the bulb in the headlamp socket.
[MC36400(ALL)12/95]3.
Remove the bulb assembly by turning it clockwise and
pulling it out of the headlamp socket.
[MC36500(ALL)12/95]4.
Remove the L-shaped bulb by pressing the retaining clip at
the base of the electrical connector and sliding the bulb out.
*
[MC36600(ALL)03/96]
Installing the headlamp bulb
[MC36700(ALL)12/95]1.
Without touching the glass on the bulb, insert the new bulb.
You may want to protect the bulb by holding it with a piece
of cloth or paper towel. Make sure the retaining clip at the
base of the electrical connector locks.
[MC36800(ALL)12/95]2.
Insert the bulb assembly in the headlamp socket. Turn it
counterclockwise to lock it in place.
[MC36900(ALL)12/95]3.
Turn the headlamps on and make sure that they work
properly. If the headlamp was correctly aligned before you
changed the bulb, you should not need to align it again.
File:11cdmco.ex
Update:Thu Sep 12 11:08:18 1996

273
Index
Brakes (continued)
power braking................... 125
servicing...................... 188
stopping distances.................. 145
trailer....................... 143
when storing your vehicle.............. 234
Brake-shift interlock.................. 131
Break-in period..................... 5
Brights (high beams)................... 15
Bulbs, replacing.................... 219
halogen...................... 220
headlamps..................... 220
high-mount brakelamp................ 222
specifications.................... 223
C
Canada, customer assistance.............. 244
Canada, warranty information.............. 3
Canadian Motor Vehicle Arbitration Plan (CAMVAP) . . . 245
Capacities for refilling fluids.............. 230
Carbon monoxide in exhaust.............. 123
Car seats for children (see Child safety seats)...... 102
Cassette tape player (see Electronic sound system) . . . 38, 42
Catalytic converter................... 216
Chains, tires...................... 208
Changing a tire.................... 161
Charging system warning light.............. 14
Childproof locks..................... 71
Child safety restraints................. 100
child safety belts.................. 114
child safety seats.................. 102
Child safety seats................... 102
and air bags.................... 102
attaching with tether straps............. 113
automatic locking mode (retractor).........91,102
in front seat..................102, 104
File:cdixo.ex
Update:Thu Sep 12 11:12:35 1996

274
Child safety seats (continued)
in rear outboard seat................ 102
in rear seat..................... 102
tether anchorage hardware.............. 114
Chime
headlamps on.................... 16
key in ignition.................... 58
safety belt...................... 12
Circuit breakers, checking and replacing......... 160
Cleaning your vehicle................. 224
CD player and discs.................. 33
chrome and aluminum parts............. 225
engine compartment................. 227
exterior...................... 224
exterior lamps................... 226
fabric....................... 226
headlamps..................... 226
instrument panel................. 7,225
interior....................... 226
mirrors........................ 75
plastic parts.................... 225
polishing...................... 224
rear windows..................... 52
rustproofing.................... 225
safety belts..................... 225
tail lamps..................... 226
upholstery and interior trim............. 226
washing...................... 224
waxing....................... 224
wheels....................... 227
Climate control system.................. 47
Clock.......................... 55
Clutch........................ 136
fluid reservoir................... 188
operation while driving............... 136
shifting the gears.................. 136
specifications.................... 231
File:cdixo.ex
Update:Thu Sep 12 11:12:35 1996

280
Gearshift
automatic operation................. 130
column-mounted.................. 130
floor-mounted................... 136
locking the gearshift.................. 56
positions....................130, 136
shifting the gears................130, 136
shift-lock...................... 131
Gearshift:
shifting the gears................130, 136
GVWR (Gross Vehicle Weight Rating).......... 139
calculating..................... 140
definition...................... 139
driving with a heavy load.............. 139
location...................... 139
H
Hazard flashers................... 62,149
Headlamps
bulb specification.................. 223
checking alignment................. 220
cleaning...................... 226
daytime running lights................ 53
replacing bulbs.................219±220
turning on and off.................. 52
warning chime.................... 16
Head restraints..................... 83
High beams
indicator light.................... 15
operation....................... 60
High-mount brakelamp................ 222
description..................... 222
replacing the bulb.................. 222
Hitch......................... 143
File:cdixo.ex
Update:Thu Sep 12 11:12:35 1996

282
L
Lamps
bulb replacement specifications chart......... 223
checking...................... 219
daytime running light system............. 53
dome lamps..................... 54
fog lamps...................... 53
hazard flashers.................. 62,149
headlamps...................... 52
high-mount brakelamp............... 222
instrument panel, dimming.............. 54
interior lamps.................. 52,54
replacing bulbs................... 219
trailer....................... 144
Lap belts........................ 93
Lights, warning and indicator
airbag........................ 16
anti-lock brakes (ABS)................. 21
brake........................ 13
charging system................... 14
check engine..................... 18
engine oil pressure.................. 14
high beam...................... 15
low coolant...................... 22
Overdrive off indicator (automatic transaxle only).... ??
safety belt...................... 12
turn signal indicator.................. 19
Load limits...................... 139
GAWR....................... 139
GVWR....................... 139
trailer towing.................... 141
File:cdixo.ex
Update:Thu Sep 12 11:12:35 1996

290
W
Warm engine, starting................. 120
Warning chimes
headlamps on.................... 16
key in ignition.................... 58
safety belt...................... 12
Warning lights (see Lights)................ 9
Warranties....................... 3
basic......................... 3
Canada....................... 3
radio......................... 45
Warranty Information Booklet.............. 3
Washer fluid...................... 60
reservoir...................... 189
windshield..................... 189
Weight limits (GAWR, GVWR)............. 139
Wheel dollies (see Towing)............... 174
Wheels
anti-theft lugnuts.................. 168
cleaning...................... 227
covers....................... 164
inspection and maintenance............. 205
lug nuts...................... 163
Windows........................ 73
manual windows, operating.............. 73
power windows, operating............... 73
Windshield, washing................... 60
File:cdixo.ex
Update:Thu Sep 12 11:12:35 1996