1997 FORD ASPIRE warning light

138 [ER10100(ALL)01/96]
WARNING
Installation of an English thread lug bolt
into a metric hub will not properly secure
the wheel to the hub. Damaged lug bolts
may result in wheel separation and
possible injury.
*
[ER10200(ALL)03/96]
6. Lower the vehicle by turning the jack handle
counterclockwise.
[ER10500(ALL)01/96]
7. Remove the jack and fully tighten the wheel
lug bolts in the order shown in the
illustration under Step 1.
[ER10700(ALL)01/96]
8. Put the tire, jack, retaining tool and wrench
away.
[ER10750(ALL)01/96]
9. Secure the conventional tire where the spare
was stored with the bolt provided.
*
[ER10850(ALL)03/96]
10. Unblock the wheels.
%
*
[ER12255(ALL)02/96]
Jump-Starting Your Vehicle
[ER12260(ALL)01/96]
Your vehicle's battery may become discharged
(ªdieº) if you leave the lights or any electrical
equipment on after you turn the engine off. If
this happens, you may be able to jump-start
from a booster battery to start your vehicle.
*
[ER12265(ALL)02/96]
WARNING
The gases around the battery can explode
if exposed to flames, sparks, or lit
cigarettes. An explosion could result in
injury or vehicle damage.
*
[ER12270(ALL)02/96]
WARNING
To protect yourself when charging a
battery, always shield your face and eyes.
Make sure that you can breathe fresh air.
File:10icerf.ex
Update:Tue Mar 4 08:55:59 1997

175 %
*
[MC43775(ALL)01/96]
WARNING
If you do not use the proper fuel cap, the
pressure in the fuel tank can damage the
fuel system or cause it to work improperly
in a collision.
*
[MC43780(ALL)01/96]
NOTE: If you replace your fuel cap with an
aftermarket fuel filler cap, the customer
warranty may be void for any damage
to the fuel tank and/or fuel system.
*
[MC43785(ALL)08/96]
WARNING
The fuel system may be under pressure. If
the fuel cap is venting vapor or if you
hear a hissing sound, wait until it stops
before completely removing the cap.
*
[MC43795(ALL)08/96]
A venting fuel tank is not an abnormal
condition. It may be caused by:
*
[MC43800(ALL)08/96]
q
too volatile a fuel for the weather conditions.
Service stations sometimes sell winter grade
fuel in the summer.
*
[MC43805(ALL)08/96]
q
extended periods of idling with the engine
RPM increased above the normal idle range.
*
[MC43810(ALL)08/96]
q
parking the vehicle in full sunlight for
extended periods on extremely hot days.
*
[MC43815(ALL)01/96]
WARNING
Do not overfill the fuel tank. The pressure
in an overfilled tank may cause leakage
and lead to fuel spray and fire.
*
[MC43820(ALL)01/96]
Before you fill your vehicle with fuel, extinguish
all lit cigarettes, other smoking materials, and
any open flames.
File:11icmcf.ex
Update:Tue Mar 4 08:57:16 1997

182
*
[MC48300(ALL)01/96]
WARNING
Do not park, idle, or drive your vehicle in
dry grass or other dry ground cover. The
emission system heats up the engine
compartment and exhaust system, which
can start a fire.
*
[MC48400(ALL)01/96]
Watch for fluid leaks, strange odors, smoke, loss
of oil pressure, the charge warning light, the
check engine light, or the temperature warning
light. These sometimes indicate that the emission
system is not working properly.
*
[MC48500(ALL)01/96]
Do not make any unauthorized changes to your
vehicle or engine. Changes that cause more
unburned fuel to reach the exhaust system can
increase the temperature of the engine or
exhaust system.
*
[MC48550(ALL)01/96]
In general, maintenance, replacement, or service
of the emissions control devices or systems in
your new Ford Motor Company vehicle or
engine may be performed at your expense by
any automotive repair establishment or
individual using automotive parts equivalent to
those which your vehicle or engine was
originally equipped.
*
[MC48575(ALL)01/96]
If other than Ford or Motorcraft or Ford
authorized remanufactured parts are used for
maintenance, replacement, or for the service of
components affecting emissions control, the
owner should be assured that such parts are
warranted by their manufacturer to be
equivalent to genuine Ford Motor Company
parts in performance and durability. Please
consult your warranty information booklet for
complete warranty information.
File:11icmcf.ex
Update:Tue Mar 4 08:57:16 1997

183
*
[MC48600(ALL)01/96]
By law, anyone who manufactures, repairs,
services, sells, leases, trades vehicles, or
supervises a fleet of vehicles is not permitted to
intentionally remove an emission control device
or prevent it from working. In some of the
United States and in Canada, vehicle owners
may be liable if their emission control device is
removed or is prevented from working.
*
[MC48700(ALL)08/95]
Never use a metal exhaust collector when you
service your vehicle. If the metal collector
contacts any of your vehicle's plastic trim or
bumper parts they could melt or deform.
*
[MC48800(ALL)01/96]
Do not drive your vehicle if it does not operate
properly. See your dealer if the engine runs on
for more than five seconds after you shut it off
or if it misfires, surges, stalls, or backfires.
%*
[MC48900(ALL)01/96]
Information about your vehicle's emission
control system is on the Vehicle Emission
Control Information decal located on or near the
engine. This decal identifies engine displacement
and gives some tune-up specifications.
%*
[MC48910(ALL)03/96]
How to Prepare Your Vehicle for
Inspection/Maintenance (I/M) Testing
[MC48920(ALL)02/97]
In some localities it may become a legal
requirement to pass an
Inspection/Maintenance (I/M) test of the
On-Board Diagnostic (OBD) II system. If your
ªCheck Engineº light is on, reference the ªCheck
Engineº light description under the Warning
Lights and Gauges section. Your vehicle may not
pass an I/M test with the Check Engine light on.
If the vehicle's powertrain system or its battery
has just been serviced, the OBD II system is
reset to a not ready for for I/M testing
condition. To prepare for I/M testing, additional
mixed city and highway driving to complete the
check of the OBD II system is necessary.
File:11icmcf.ex
Update:Tue Mar 4 08:57:16 1997

185 %
*
[MC61100(ALL)01/96]
The alignment of your headlamps should be
checked if:
*
[MC61200(ALL)01/96]
q
oncoming motorists frequently signal you to
turn off your vehicle's high beams when you
do not have the high beams on
*
[MC61300(ALL)01/96]
q
the headlamps do not seem to give you
enough light to see clearly at night
*
[MC61400(ALL)01/96]
q
the headlamp beams are pointed substantially
away from a position slightly down and to
the right
%*
[MC61500(ALL)01/96]
Headlamp Bulb
*
[MC61600(ALL)03/96]
The headlamps on your vehicle use replaceable
bulbs. When the lamp burns out, simply replace
the bulb, rather than the whole lamp.
*
[MC61700(ALL)01/97]
WARNING
Handle a halogen headlamp bulb carefully
and keep out of children's reach. Grasp
the bulb only by its plastic base and do
not touch the glass. The oil from your
hand could cause the bulb to break the
next time the headlamps are operated.
*
[MC61800(ALL)01/97]
Do not remove the burned-out bulb unless you
can immediately replace it with a new one. If a
bulb is removed for an extended period of time,
contaminants may enter the headlamp housing
and affect its performance.
File:11icmcf.ex
Update:Tue Mar 4 08:57:16 1997

Index 243
Index
A
ABS warning light (see Anti-lock
brake system)............. 15
Accessory position on the ignition..... 44
Additives, engine oil.......... 149
Air bag supplemental restraint system . 69, 78
and child safety seats........77±78
description............. 69,71
driver air bag........... 69,71
indicator light............. 14
operation............... 71
passenger air bag............ 71
service and information labels.... 71,75
tone generator............. 74
Air cleaner filter, specifications...... 199
Antenna, radio (see Electronic
sound system)......... 19,27,42
Antifreeze (see Engine coolant)...... 155
Anti-lock brake system (ABS)
description.............. 105
see also Brake............ 105
warning light.............. 15
warninig light............. 9
Appeals (see Dispute settlement board) . . 214
Assistance (see Customer assistance) . . . 211
Audio system (see Electronic
sound system)............. 19
Autolamp system (see Headlamps)..... 46
Automatic transaxle
fluid, adding............. 161
fluid, checking............ 161
Automatic transmission
driving an automatic overdrive.... 112
fluid, adding............. 161
File:icixf.ex
Update:Tue Mar 4 08:59:36 1997

244 Index
B
Backing up.............112, 116
Basic vehicle warranty........... 3
Battery................. 162
acid, treating emergencies . . . 139, 164±165
charging system warning light...... 11
disconnecting............. 142
how to service............ 162
jumping a disabled battery....... 138
maintenance-free........... 162
proper disposal, recycling....... 164
replacement, specifications....... 199
servicing............... 162
voltage gauge.............. 11
when storing your vehicle....... 197
Brake fluid............... 152
brake warning light........... 9
checking and adding......... 152
description.............. 152
Brakelamp............... 191
bulb replacement........... 191
high-mount brakelamp........ 191
Brakes................. 105
adjustment.............. 105
anti-lock............... 105
anti-lock brake system (ABS)
warning light............. 15
applying the brakes.......... 105
brake warning light........... 9
fluid, checking and adding....... 152
fluid, refill capacities......... 152
front disc............... 105
if brakes do not grip well....... 105
master cylinder............ 152
new brake linings............ 5
noise................. 105
parking............... 108
power braking............ 105
servicing............... 152
when storing your vehicle....... 198
File:icixf.ex
Update:Tue Mar 4 08:59:36 1997

Index 245
Break-in period.............. 5
Brights (high beams)........... 12
Bulbs, replacing............. 184
halogen............... 185
headlamps.............. 185
high-mount brakelamp........ 191
C
Canada, customer assistance....... 218
Canada, warranty information....... 3
Canadian Motor Vehicle Arbitration Plan
(CAMVAP).............. 219
Carbon monoxide in exhaust....... 102
Car seats for children
(see Child safety seats)......... 77
Cassette tape player (see Electronic sound
system)................ 21
Catalytic converter........... 181
Chains, tires.............. 173
Changing a tire............. 130
Charging system warning light....... 11
Child safety restraints
child safety belts............ 90
child safety seats............ 77
Child safety seats............. 77
and air bags............77±78
attaching with tether straps....... 87
automatic locking mode (retractor) . . 67, 77
in front seat............77±78
in rear outboard seat.......... 77
in rear seat............... 77
tether anchorage hardware....... 87
Chime
key in ignition............. 16
safety belt............... 9
Circuit breakers, see also fuses...... 122
Cleaning your vehicle.......... 192
chrome and aluminum parts...... 193
engine compartment......... 194
exterior............... 192
File:icixf.ex
Update:Tue Mar 4 08:59:36 1997