1997 CHEVROLET EXPRESS radiator cap

Downloaded from www.Manualslib.com manuals search engine Windshield Washer Fluid
What to Use
When you need windshield washer fluid, be sure to read
the manufacturer’s instructions before use. If you will be
operating your vehicle in an area where the temperature
may fall below freezing, use
a fluid that has sufficient
protection against freezing.
Adding Washer Fluid
Open the cap labeled WASHER FLUID. Add washer
fluid
until the tank is full.
NOTICE:
e
e
e
e
When using concentrated washer fluid,
follow the manufacturer’s instructions for
adding water.
Don’t mix water with ready-to-use washer
fluid. Water can cause the solution to freeze
and damage your washer fluid tank and
other parts of the washer system.
Also,
water doesn’t clean as well as washer fluid.
Fill your washer fluid tank only
three-quarters full when it’s very cold. This
allows
for expansion if freezing occurs,
which could damage the tank if it is
completely full.
Don’t use radiator antifreeze in your
windshield washer.
It can damage your
washer system and paint.

Downloaded from www.Manualslib.com manuals search engine Normal Replacement Parts
Engine VIN
Oil Filter
Air Cleaner Filter*
PCV Valve
Spark Plugs
Fuel Filter
Radiator Cap
*Replace with AC Ai
“VORTEC”4300
w
PF52
A9 17C
CV789C
41-932 GF48
1
RC36
“VORTEC”5000
r Filter, Part No. A917C and fi
Air Conditioning Refrigerant Capacity
M
PF1218
A917C
cv774c
4 1-932 GF48
1
RC36
or severe dua
NOTICE:
R-134A refrigerant is not compatible with R-12
refrigerant in an air conditioning system. R-12 in
an R-134A system
will cause compressor failure,
refrigerant oil sludge, or poor air conditioning
system performance. “VORTEC”5700
R
PF1218
A9 17C
cv774c
4 1-932
GF48
1
RC36
“VORTEC”7400
J
PF1218
A917C
cv774c
41-932 GF48
1
RC36
;ty conditions, use, AC Air Filter, Part No. 1236C.
TYPE QTY Front Only QTY Front and Rear
Refrigerant 3.00 Ibs. (1.36 kg) 4.875 Ibs. (2.2 1 kg)
R- 134A
Air Conditioning Refrigerants
Not all air conditioning refrigerants are the same.
If the air conditioning system in your vehicle needs
refrigerant,
be sure the proper refrigerant is used.
Tf you’re not sure, ask your GM dealer.

Downloaded from www.Manualslib.com manuals search engine I Short ’IYipKity Maintenance Schedule =- Gasoline Engines I
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
IJ’yo~1 do not use your vehicle under any of these
conditions, the.fluid
and.filter do not require changing.
0 Inspect Positive Crankcase Ventilation
(Pcv) valve.
An Emission Control Service.
I I I 1
DATE
SERVICED BY ACTUAL MILEAGE
150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system
(or every
60 months since last service,
whichever occurs first). See “Engine
Coolant” in the Index for
what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test cooling
system and pressure cap.
An Emission Control Service.
DATE SERVICED BY ACTUAL MILEAGE

Downloaded from www.Manualslib.com manuals search engine Long TripMighway Maintenance Schedule -- Gasoline Engines 1
100,000 Miles (166 000 km) (Continued)
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of these
conditions, thefluid andfilter do not require changing.
0 Inspect Positive Crankcase Ventilation
(Pcv) valve. An Emission Control Service.
150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system
(or every
60 months since last service,
whichever occurs first). See “Engine
Coolant”
in the Index for what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test the
cooling system and pressure cap.
Arz Emission Control Service.
DATE SERVICED BY ACTUAL MILEAGE
7-44

Downloaded from www.Manualslib.com manuals search engine Paint Spotting. Chemical ........................ 6-56
Park Automatic Transmission
....................... 2-24
Shifting Out of
............................... 2-27
AtNight
.................................... 2-15
Brake
...................................... 2-23
Brake Mechanism Check
....................... 7-48
Lots
....................................... 2-15
OverThingsThatBurn
........................ 2-27
With a Trailer
................................ 4-37
Passenger Position
.............................. 1-25
Passenger Temperature Control
..................... 3-5
Passing
....................................... 4-12
Periodic Maintenance Inspections
.................. 7-49
Power
Antenna Mast Care
............................ 3-28
DoorLocks
................................... 2-5
Option Fuses
................................ 6-60
Remote Control Mirror
........................ 2-43
Seat
......................................... 1-3
Steering ..................................... 4-9
Steering Fluid
................................ 6-26
Windows
................................... 2-29
Power Seat
Pregnancy. Use of Safety Belts
.................... 1-24
Problems on the Road
............................ 5-1
Publications. Service and Owner ................... 8-1 1
Shifting Into ................................. 2-24
Parking Radiator
..................................... 5-19
Radiator Pressure Cap
............................ 6-25
Radio Reception
................................ 3-26
Radios
......................... 3.9.3.11.3.13. 3.18
Rain. Driving In
................................ 4-16
Reading Lamps
................................ 2-41
Rear Axle
....................................... 6-22
Door Security Locks
........................... 2-5
Outside Seat Position
.......................... 1-32
Seatpassengers
.............................. 1-32
Towing
..................................... 5-11
Rearview Mirror
................................ 2-43
Reclining Front Seatbacks
......................... 1-3
Recommended Fluids and Lubricants
............... 7-51
Recovery Tank. Coolant
.......................... 5-16
Refrigerants. Air Conditioning
.................... 6-67
Remote Compact Disc Player
..................... 3-22
Replacement Bulbs
...................................... 6-68
Parts
....................................... 6-67
Wheel
...................................... 6-47
Replacing Safety Belts
........................... 1-52
Reporting Safety Defects
......................... 8-10
Restraints
Checking
................................... 1-52
Child
....................................... 1-40
Head
........................................ 1-5
System Check
................................ 7-46
Reverse. Automatic Transmission
.................. 2-21
Replacing Parts After
a Crash
................... 1-52
9-7