1997 CHEVROLET CAVALIER radiator

Downloaded from www.Manualslib.com manuals search engine Windshield Washer Fluid
What to Use
When you need windshield washer fluid, be sure to read
the manufacturer’s instructions before use. If you will be
operating your vehicle in an area where the temperature
may fall below freezing, use a fluid that has sufficient
protection against freezing.
Adding Washer Fluid
Open the cap labeled
WASHER FLUID ONLY.
mgrr Add washer fluid until the
tank is full.
NOTICE:
.~ -~
a
a
a
a
When using concentrated washer fluid,
follow the manufacturer’s instructions for
adding water.
Don’t mix water with ready-to-use washer
fluid. Water can cause the solution
to freeze
and damage your washer fluid tank and
other parts of the washer system. Also,
water doesn’t clean
as well as washer fluid.
Fill your washer fluid tank only
three-quarters full when it’s very cold. This
allows for expansion if freezing occurs,
which could damage the tank
if it is
completely full.
Don’t
use radiator antifreeze in your
windshield washer.
It can damage your
washer system and paint.
6-30

Downloaded from www.Manualslib.com manuals search engine 0 Section 7 Maintenance Schedule
This section covers the maintenance required for your Chevrolet. Your vehicle needs these services to retain its safety,
dependability and emission control performance.
7-2
7-2
7-3
7-4
7-4
7-4 7-4
1
7-4 1
7-4 1
7-42
7-43
Introduction Your Vehicle and the Environment
How This Section
is Organized
Part A: Scheduled Maintenance Services
Using Your Maintenance Schedule
Selecting the Right Schedule
Part B: Owner Checks and Services
At Each Fuel Fill
At Least Once
a Month
At Least Twice
a Year
At Least Once a Year
7-46
7-46
7-46
7-46
7-46
7-47
7-47
7-48
7-50 Part C: Periodic Maintenance Inspections
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
Exhaust System Inspection
Radiator and Heater Hose Inspection
Throttle Linkage Inspection
Brake System Inspection
CaliperKnuckle Maintenance Inspection
Part
D: Recommended Fluids and Lubricants
Part E: Maintenance Record

Downloaded from www.Manualslib.com manuals search engine I I
Short Trip/City Maintenance Schedule
100,000 Miles (1 66 000 km) (Continued)
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
If you do not use your vehicle under any of these
conditions, the
fluid andfilter do not require changing.
Manual transaxle fluid doesn’t
require change. delivery service.
DATE
ACTUAL MILEAGE SERVICED BY:
150,000 Miles (240 000 km)
Drain, flush and refill cooling system
(or every
60 months since last service,
whichever occurs first). See “Engine
Coolant’’ in the Index for what
to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test cooling
system and pressure cap.
An Emission Control Service.
DATE
SERVICED BY: ACTUAL MILEAGE
- -.

Downloaded from www.Manualslib.com manuals search engine bung Trip/Highway Maintenance Schedule I
100,000 Miles (166 000 km) (Continued)
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of these
conditions, the
fluid andfilter do not require changing.
Manual transaxle fluid doesn’t
require change.
I I I 1
DATE SERVICED BY: ACTUAL MILEAGE
150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system
(or every
60 months since last service,
whichever occurs first). See “Engine
Coolant” in the Index for what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test the
cooling system and pressure cap.
An Emission Control Service.
I I I 1
DATE
SERVICED BY ACTUAL MILEAGE

Downloaded from www.Manualslib.com manuals search engine Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall).
You should let your GM dealer’s
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a
GM service manual. See “Service and Owner
Publications” in the Index.
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs
of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc. Clean and then inspect the drive axle boot seals for damage, tears or leakage. Replace
seals if necessary.
I
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system.
Look for broken, damaged,
missing
or out-of-position parts as well as open seams,
holes, loose connections or other conditions which could
cause a heat build-up in the floor pan or could let
exhaust fumes into the vehicle. See “Engine Exhaust’’
in the Index.
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed.
Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding,
and for damage or missing parts. Replace parts as
needed. Replace any cables that have high effort or
excessive wear.
Do not lubricate accelerator and cruise
control cables.

Downloaded from www.Manualslib.com manuals search engine FrontTowing .................................. 5-10
Fuel .......................................... 6-3
Filling Your Tank
.............................. 6-6
Gage ....................................... 2-78
In Foreign Countries
........................... 6-5
Fuses and Circuit Breakers ....................... 6-59
Gages Engine Coolant Temperature
.................... 2-72
Fuel
....................................... 2-78
Speedometer
....................... 2-64.2-65. 2.66
Tachometer
............................. 2.65. 2.67
GAWR
....................................... 4-34
Gear Positions. Automatic Transaxle
................ 2- 19
Gear Positions. Manual Transaxle
.................. 2-23
Gross Axle Weight Rating
........................ 4-34
Gross Vehicle Weight Rating
...................... 4-34
Guide en Frangais
11 .. .................................
GVWR ....................................... 4-34
Halogen Bulbs
................................ 6-35
Hazard Warning Flashers
.......................... 5-2
Head Restraints
................................. 1-5
Headlamps .................................... 2-42
Bulb Replacement
............................ 6-36
High/Low Beamchanger
...................... 2-35
OnReminder
................................ 2-42
Wiring
..................................... 6-59
Hearing Impaired. Customer Assistance
.............. 8-4
High-Beam Headlamps
.......................... 2-35
Highway Hypnosis
.............................. 4-24
Hill and Mountain Roads
......................... 4-24
Heating
........................................ 3-5 Hitches.
Trailer 4-39
Hood Checking Things Under
......................... 6-8
Release ...................................... 6-8
Hydraulic Clutch ............................... 6-24
Fluid
....................................... 6-24
..
.................................
Prop ........................................ 6-9
Horn ......................................... 2-32
System Check
................................ 7-42
Hydroplaning
.................................. 4-20
Ignition Positions
.............................. 2-12
Ignition Transaxle Lock Check
.................... 7-44
Inflation, Tire
.................................. 6-41
Inside Daymight Rearview Mirror
................. 2-46
Inspections Brakesystem
................................ 7-47
Caliper/Knuckle
.............................. 7-47
Exhaust Systems
............................. 7-46
Front-Wheel-Drive Axle Boot
.................. 7-46
Front-Wheel-Drive Axle Seal
................... 7-46
Radiator and Heater Hose
...................... 7-46
Steering
.................................... 7-46
Suspension
.................................. 7-46
Throttle Linkage
.............................. 7-46
InstrumentPanel
............................... 2-62
Brightness Control
............................ 2-44
Cleaning
.................................... 6-51
Cluster
................................ 2-64, 2-65
FuseBlock
.................................. 6-60
Interior Lamps ................................. 2-44
Bulb Replacement ............................ 6-39
Illuminated Entry
............................... 2-44
Installing the Boot
.............................. 2-52
9-5