1997 CHEVROLET ASTRO checking oil

Downloaded from www.Manualslib.com manuals search engine Section 6 Service and Appearance Care
Here you will find information about the care of your vehicle. This section begins with service and fuel information,
and
then it shows how to check important fluid and lubricant levels. There is also technical information about your
vehicle, and
a part devoted to its appearance care.
6- 2
6-3
6-4
6-5
6-7
6-1 1
6- 15
6- 19
6-20
6-23
6-25
6-25
6-29
6-30
6-30
6-3
1
6-32
6-36
6-36
6-36 Service
Fuel Fuels
in Foreign Countries
Filling Your Tank
Checking Things Under the Hood
Engine Oil
Engine Cover
Air Cleaner
Automatic Transmission Fluid
All-Wheel Drive Rear Axle
Engine Coolant
Radiator Pressure Cap
Thermostat Power Steering Fluid
Windshield Washer Fluid
Brakes Battery
Bulb Replacement Halogen Bulbs 6-42
6-43
6-50
6-5
1
6-54
6-55
6-55
6-57
6-5
8
6-5 8
6-5
8
6-59
6-60
6-60
6-60
6-66
6-66
6-67
6-68 Windshield Wiper Blade Replacement
Tires Appearance Care
Cleaning
the Inside of Your Vehicle
Cleaning Glass Surfaces
Cleaning the Outside
of the Windshield,
Backglass and Wiper Blades
Cleaning the Outside
of Your Vehicle
Cleaning Tires Finish Damage Underbody Maintenance
Chemical Paint Spotting
Appearance Care Materials Chart
Vehicle Identification Number
(VIN)
Service Parts Identification Label
Electrical System Replacement Bulbs
Capacities and Specifications
Air Conditioning Refrigerants
Normal Maintenance Replacement Parts
6-1

Downloaded from www.Manualslib.com manuals search engine When you put the cap back on, turn it to the right
(clockwise) until
you hear a clicking sound. Make sure
you fully install the cap. The diagnostic system can
determine if the fuel cap has been left off or improperly
installed. This would allow fuel to evaporate into the
atmosphere. See “Malfunction Indicator Lamp” in
the Index.
NOTICE:
If you need a new cap, be sure to get the right
type. Your dealer can get one for you.
If you get
the wrong type,
it may not fit properly. This may
cause your malfunction indicator lamp to light
and your fuel tank and emissions system may be
damaged. See “Malfunction Indicator Lamp” in
the Index.
Checking Things Under the Hoc4
m-
Things that burn can get on hot engine parts and
start a fire. These include liquids like gasoline,
oil, coolant, brake fluid, windshield washer and
other fluids, and plastic or rubber. You
or others
could be burned. Be careful not to drop or spill
things that will burn onto a hot engine.
6-7

Downloaded from www.Manualslib.com manuals search engine Automatic Transmission Fluid
When to Check and Change
A good time to check your automatic transmission fluid
level is when
the engine oil is changed.
Change both the fluid and filter every
15,000 miles
(25 000 km) if the vehicle is mainly driven under one or
more
of these conditions:
0 In heavy city traffic where the outside temperature
In hilly or mountainous terrain.
0 When doing frequent trailer towing.
regularly reaches
90 OF (32 ” C) or
higher.
Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these
conditions, change the fluid and filter every
30,000 miles
(50 000 km).
See “Scheduled Maintenance Services” in the Index.
How to Check
Because this operation can be a little difficult, you may
choose to have this done at your
GM dealership
Service Department.
If you do it yourself, be sure to follow all the instructions
here, or you could get
a false reading on the dipstick.
NOTICE:
Too much or too little fluid can damage your
transmission.
Too much can mean that some of
the fluid could come out and fall on hot engine
parts or exhaust system parts, starting a fire. Be
sure to get an accurate reading if you check your
~ transmission fluid.
Wait at least 30 minutes before checking the
transmission fluid level if you have been driving:
0 When outside temperatures are above 90°F (32°C).
0 At high speed for quite a while.
0 In heavy traffic -- especially in hot weather.
0 While pulling a trailer.
To get the right reading, the fluid should be at normal
operating temperature, which
is 180°F to 200°F
(82°C to 93°C).
6-20

Downloaded from www.Manualslib.com manuals search engine Engineoil .................................... 6-11
Adding ..................................... 6-12
Additives
................................... 6- 14
Checking
................................... 6-11
Pressure Gage ................................ 2-68
Used
....................................... 6-14
Whentochange
.............................. 6-14
Exhaust, Engine
....... 2-27,2-28,2-30,4-27,4-34, 4-35
Express-Down Window
.......................... 2-29
Fabric Cleaning
............................... 6-52
FillingYourTank
6-5
Fi 1 ter
.
................................
Air Cleaner Replacement ....................... 6-68
Engine Oil Replacement
....................... 6-68
Finish Care
.................................... 6-56
Finish Damage
................................. 6-58
FirstGear ..................................... 2-22
Flashers, Hazard Warning
......................... 5-2
Flat Tire. Changing
............................. 5-23
Fluid Capacities
........................... 6.66. 6.67
Foreign Countries. Fuel
........................... 6-4
Fluids and Lubricants ............................ 7-49
French Language Manual
11
Front
Axle
....................................... 6-24
Towing
................................. 5-9. 5.10
Turn Signal Lamp Bulb Replacement ............. 6-40
.. ...........................
Storage Area ................................. 2-42
Fuel .......................................... 6-3
Filling Your Tank
.............................. 6-5
Gage
....................................... 2-69
In Foreign Countries ........................... 6-4
Regulator
................................... 2-18
Fuses and Circuit Breakers
....................... 6-61
Gages Engine Coolant Temperature
.................... 2-64
Fuel ....................................... 2-69
Engine Oil Pressure
........................... 2-67
Garage Door Opener
............................ 2-45
GAWR
....................................... 4-28
Gear Positions. Automatic Transmission
............. 2-19
GloveBox
.................................... 2-42
Gross Axle Weight Rating
........................ 4-28
Gross Vehicle Weight Rating
...................... 4-28
Guide en Franpis 11
GVWR ....................................... 4-28
.. .................................
Halogen Bulbs ................................ 6-36
Hatch Release
.................................. 2-12
Hazard Warning Flashers
.......................... 5-2
Head Restraints
................................. 1-5
Headlamps .................................... 2-38
Bulb Replacement
............................ 6-37
High/Low Beam Changer ...................... 2-32
Wiring
..................................... 6-61
OnReminder ................................ 2-38
9-4