1996 VOLVO 850 tire type

1996 Volvo 850
mountainous areas.

NOTE: Refer to section "Automatic transmission" for additional trailer h\
auling tips.
WARNING!
l Bumper-attached trailer hitches must not be used on Volvos, nor should s\
afety chains be attached to
the bumper.
l Trailer hitches attaching to the vehicle rear axle must not be used.
l Never connect a trailer's hydraulic brake system directly to the vehicle\
brake system, nor a trailer's
lighting system directly to the vehicle lighting system. Consult your ne\
arest authorized Volvo retailer
for correct installation.
pg. 4:18 Winter driving
Cold weather precautions

l If you wish to check your car before the approach of cold weather, the f\
ollowing advice is worth
noting:
l Make sure that the engine coolant contains at least 50 percent antifreez\
e: that is, 3.7 qts. (3.5 liters)
Volvo Genuine Coolant/Antifreeze. This gives protection against freezing\
down to -31°F (-35°C). See
section "Coolant". The use of "recycled" antifreeze is not approved by V\
olvo. Different types of
antifreeze may not be mixed.
l Try to keep the fuel tank well filled - this prevents the formation of c\
ondensation in the tank. In
addition in extremely cold weather conditions it is worthwhile to add fu\
el line de-icer before refueling.
l The viscosity of the engine oil is important. Oil with low viscosity (t\
hinner oil) improves cold-
weather starting as well as decreasing fuel consumption while the engine\
is warming up. For winter use,
5W-30 oil, particularly the synthetic type, is recommended. Be sure to u\
se good quality oil but do not
use this cold-weather oil for hard driving or in warm weather. See secti\
on "Engine oil" for more
information.
l The load placed on the battery is greater during the winter since the he\
ater, windshield wipers,
lighting etc. are used more often. Moreover, the capacity of the battery\
decreases as the temperature
drops. In very cold weather, a poorly charged battery can freeze and be \
damaged. It is therefore
advisable to check the state of charge more frequently and spray an anti\
-rust oil on the battery posts.
l Volvo recommends the use of snow tires on all four wheels for winter dri\
ving - see section "Wheels
and tires".
l To prevent the washer reservoir from freezing, add washer solvents conta\
ining antifreeze (see page
file:///K|/ownersdocs/1996/1996_850/96850_412.htm (8 of 10)12/30/2006 \
9:59:35 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
Wheels and tires
pg. 5:1 Wheels and tires
Wheels and tires

The handling and riding comfort of the vehicle is dependent on the infla\
tion pressure and the type of
tires fitted. Read the following pages carefully.

5:2 General information, Wear indicator, Tire economy, Flat spots
5:3Snow chains, Winter tires
5:4Inflation pressure
pg. 5:2 Wheels and tires
General information

Your vehicle is equipped with tires according to the tire information la\
bel located on the rear facing side
of the right front door.

The following is an example of a tire designation code:
195 = tire width in mm.
60 = tire profile. This is the relationship (in percent) between the s\
ection height and the width of the tire.
R = radial tires.
15 = diameter in inches on all four wheels.

The tires have good road holding characteristics and offer good handling\
on dry and wet surfaces. It
should be noted however that the tires have been developed to give these\
features on snow/ice-free
surfaces. Certain models are equipped with "all-season" tires, which pro\
vide a somewhat higher degree
of winter roadholding on slippery surfaces than tires without the "all-s\
eason" rating. However, for
optimum road holding on icy or snow covered roads - we recommend suitabl\
e winter tires on all four
wheels. When replacing tires, be sure that the new tires are the same si\
ze designation, type (radial) and
preferably from the same manufacturer, on all four wheels. Otherwise the\
re is a risk of altering the car's
road-holding and handling characteristics.
file:///K|/ownersdocs/1996/1996_850/96850_501.htm (1 of 5)12/30/2006 9\
:59:37 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

NOTE: When storing wheel/tire assemblies (e.g. winter tires and wheels)\
, either stand the assemblies
upright or suspend them off the ground. Laying wheel/tire assemblies on \
their sides for prolonged
periods can cause wheel and/or tire damage.

Wear indicator

The tires have a so-called "wear indicator" in the form of a number of n\
arrow strips running across or
parallel to the tread. When approx. 1/16" (1.6 mm) is left on the trea\
d, these strips show up and indicate
that the tire should be replaced.
Tires with less than 1/16" (1.6 mm) tread have a very poor grip in rai\
n or snow.
When replacing worn tires, it is recommended that the tire be identical \
in type (radial) and size as the
one being replaced. Using a tire of the same make (manufacturer) will \
prevent alteration of the driving
characteristics of the vehicle.

To improve tire economy:

l Maintain correct tire pressure.
l Drive smoothly: avoid fast starts, hard braking and tire screeching.
l Tire wear increases with speed.
l Do not change wheel location unless necessary.
l Correct front wheel alignment is very important.
l Unbalanced wheels impair tire economy and driving comfort.
l If the wheels are rotated, they should be kept on the same side of the c\
ar so that they revolve in the
same direction as prior to rotation.
l Hitting curbs or potholes can damage the tires and/or wheels permanently\
.

Flat spots

All tires become warm during use. After cooling, when the vehicle is par\
ked, the tires have a tendency to
distort slightly, forming flat spots. These flat spots can cause vibrati\
ons similar to the vibrations caused
by imbalanced wheels. They do, however, disappear when the tire warms up\
. The degree to which the
flat spots form depends on the type of cord used in the tire. Remember t\
hat, in cold weather, it takes
longer for the tire to warm up and consequently longer for the flat spot\
to disappear.
file:///K|/ownersdocs/1996/1996_850/96850_501.htm (2 of 5)12/30/2006 9\
:59:37 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
pg. 5:3 Wheels and tires
Snow chains

Snow tire chains can be used on your Volvo with the following restrictio\
ns:
l Snow chains should be installed on your front wheels only.
l Snow chains may be mounted on tire dimension 185/65R15 and 195/60R15. Ti\
re dimension
205/55R15 and 205/50R16 require a special type of snow chain. Consult yo\
ur Volvo retailer. Snow
chains may not be used on 205/55R16
If accessory, aftermarket or "custom" tires and wheels are installed and\
are of a size different than the
original tires and wheels, chains in some cases CANNOT be used. Snow cha\
ins cannot be used on those
turbo models fitted with all-season tires 205/55 R16 or 205/45 R17. Mode\
ls equipped with 205/55 R15
or 205/50 R16 need specially designed snow chains. Sufficient clearances\
between chains and brakes,
suspension and body components must be maintained.
l Some strap-on type chains will interfere with brake components and there\
fore CANNOT be used.
CAUTION:
l Check local regulations regarding the use of snow chains before installi\
ng.
l Always follow the chains manufacturer's installation instructions carefu\
lly. Install chains as tightly
as possible and re-tighten periodically.
l Never exceed the chain manufacture's specified maximum speed limit. (Un\
der no circumstances
should that limit be higher than 30 mph (45 km/h).
l Avoid bumps, holes or sharp turns when driving with snow chains.
l The handling of the vehicle can be adversely affected when driving with \
chains. Avoid fast or sharp
turns as well as locked wheel braking.

Snow tires, studded tires *

Tires for winter use:
Owners who live in or regularly commute through areas with sustained per\
iods of snow or icy driving
conditions are strongly advised to fit suitable winter tires to help ret\
ain the highest degree of traction.
It is important to install winter tires on all four wheels to help retai\
n traction during cornering, braking
and accelerating. Failure to do so could reduce traction to an unsafe le\
vel or adversely affect handling.
Do not mix tires of different design as this could also negatively affec\
t overall tire road grip. Volvo
recommends 185/65 R15 winter tires on 15" wheels on all 850 models inclu\
ding models equipped with
file:///K|/ownersdocs/1996/1996_850/96850_501.htm (3 of 5)12/30/2006 9\
:59:37 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
pg. 6:5 Replacing bulbs
Replacing bulbs

Make sure when installing bulbs, that the guide pin on the socket fits i\
nto its corresponding recess.
When installing Halogen bulbs, do not touch the glass with your fingers \
because grease, oil or any other
impurities can be carbonized onto the bulb and damage the reflector. Use\
bulbs of correct type and
voltage. Failure to do so could cause the bulb failure warning light to \
activate.

NOTE: Turn the ignition and the light switch off before replacing any bu\
lbs.



Parking light/direction indicator

1. Loosen the spring which retains the lamp housing.
2. Withdraw the entire lamp housing; separate the bulb holder from the l\
amp unit.
3. Leave the connector with its wires in the bulb holder.
4. Remove the bulb from the holder by pressing in and turning counter-cl\
ockwise.
5. Insert a new bulb and reinstall the unit in the reverse order. pg. 6:6 Replacing bulbs
file:///K|/ownersdocs/1996/1996_850/96850_605.htm (1 of 13)12/30/2006 \
9:59:43 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
Turbo: Champion RC7GYC (or equivalent)
Spark plug gap 0.028" (0.7 mm)
Tightening torque 18.4 ft. lbs. +/- 3.7 ft. lbs. (25 Nm +/- 5 Nm)

Front suspension

Spring strut suspension with integrated shock absorbers and control arm \
linked to the support frame.
Power-assisted rack and pinion steering. Safety type steering column.
The alignment specifications apply to an unladen car but include fuel, c\
oolant, and spare wheel.

Toe-in measured on the wheel rims: 2.4 mm +/- 0.7 mm
Toe-in measured on tire sides: 2.9 +/- 0.9 mm

Rear Suspension

Delta-link individual rear-wheel suspension with longitudinal support ar\
ms, double link arms and track
rods.

Toe-in measured on the tire sides: 4° +/- 10°

All specifications are subject to change without notice. pg. 9:5 Specifications (cont.)
Power transmission

Manual transmission: M 56 H
Single-disc dry plate clutch. All-synchromesh on all gears including rev\
erse; integrated final drive.
Operation via a floor mounted gear lever.

Final drive ratio 4.00:1
Reduction ratios
file:///K|/ownersdocs/1996/1996_850/96850_901.htm (5 of 7)12/30/2006 9\
:59:55 AMClassic Cars & Cycles www.ClassicCycles.org