1996 VOLVO 850 service interval

1996 Volvo 850
authorized Volvo retailer for an inspection of the system. See the SRS s\
ection for more information.


Service reminder indicator
This light will come on at 10,000 mile (16,000 km) intervals*, after 7\
50 hours of driving or after 12 months, whichever occurs
first. It is a reminder to the driver that the service interval has been\
exceeded. The light will stay on 2 minutes after the start until
reset by the servicing retailer.
* Turbo models intervals: 5,000 miles (8,000 km), 500 hours of driving\
or after 12 months, whichever occurs first.


Bulb failure warning light
The light will come on if any of the following bulbs are defective:
l one of the low beam headlights
l one of the tail lights
l one of the brake lights when the brake pedal is depressed.
Check the fuse and bulb. See sections titled "Replacing bulbs" and "Fuse\
s".
Should the warning light come on after a defective outside bulb has been\
replaced, the corresponding bulb on the other side of the
car should also be replaced.




Contents | Top of Page
file:///K|/ownersdocs/1996/1996_850/96850_101.htm (7 of 7)12/30/2006 9\
:58:55 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Some of the above mentioned items and others are checked at the standard\
Maintenance Service
intervals.

NOTE: ( D )rive or 5th gear (manual transmissions) should be used as\
often as possible to help improve
fuel economy. pg. 4:5 Starting the engine
Starting and stopping

1. Fasten the seat belt.
WARNING! Before starting, check that the seat and steering wheel are adj\
usted properly. Make sure
the brake pedal can be depressed completely. Move the seat closer if nec\
essary. Refer to section "front
seats".

2. Apply the parking brake, if not already set. The gear selector ( aut\
omatic transmission ) is locked in
the ( P )ark position ( SHIFT LOCK ).

3. Without touching the accelerator pedal , turn the ignition key to the\
starting position. Allow the starter
to operate for 5-10 seconds (turbo: 10 seconds). Release the key as so\
on as the engine starts. If the
engine fails to start, repeat step 3.
For cold starts at altitudes above 6000 ft (1800 m), depress the accel\
erator pedal halfway and turn the
key to the starting position. Release the accelerator pedal slowly when \
the engine starts.

4. To release the gear selector from the (P)ark position (automatic t\
ransmission), the ignition key must
be in position II and the brake pedal must be depressed.
See page 6:18 for instructions on manually
overriding the SHIFTLOCK system.

Do not race a cold engine immediately after starting. Oil flow may not r\
each some lubricating points fast
enough to prevent engine damage.

NOTE: (Automatic transmission only)
file:///K|/ownersdocs/1996/1996_850/96850_401.htm (6 of 8)12/30/2006 9\
:59:32 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
Maintenance services

Your Volvo has passed several major inspections before being delivered t\
o you, according to Volvo
specifications. The maintenance services outlined in this book should be\
performed as indicated. The
extended maintenance service intervals make it even more advisable to fo\
llow this program. Inspection
and service should also be performed any time a malfunction is observed \
or suspected. It is
recommended that receipts for vehicle emission services be retained in t\
he event that questions arise
concerning maintenance. See your "Maintenance Records Manual".

Applicable warranties - U.S.

In accordance with U.S. Federal Regulations, the following list of appli\
cable U.S. warranties is
provided. For Canadian specification vehicles, see your separate warrant\
y booklet.
l New Car Limited Warranty
l Parts and Accessories Limited Warranty
l Corrosion Protection Limited Warranty
l Seatbelt and Supplemental Restraint Systems Limited Warranty
l Emission Design and Defect Warranty
l Emission Performance Warranty

These are the Federal warranties; other warranties are provided as requi\
red by state law. Refer to your
separate Warranty booklet for detailed information concerning each of th\
e warranties.
pg. 8:4 Servicing
Maintenance schedule

A = Adjust (Correct if necessary) I = Inspect (Correct or Replace if \
necessary)
R = Replace L = Lubricate
Maintenance Operation thousand
miles (thousand km) 5
3
(8) 10
(16) 15 3
(25) 20
(32) 25 3
(40) 30
(48) 35 3
(56) 40
(64) 45 3
(72) 50
(80) 55 3
(88) 60
2
(96)
file:///K|/ownersdocs/1996/1996_850/96850_801.htm (3 of 6)12/30/2006 9\
:59:50 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
EMISSION SYSTEM
MAINTENANCE



Engine oil and filter
1 R
3 R R 3 R R 3 R R 3 R R 3 R R 3 R
Engine drive belt accessory belt) R
Air cleaner filter R R
Spark plugs R R
Automatic transmission fluid

I
I I I I I
Timing belt - B 5254 S, B 5234 T
4


1) See section "Engine oil" for detailed information.

NOTE: The oil should be changed at these intervals or after 750 hours of\
driving or after 12 months
which ever occurs first. See "Service Reminder indicator",
page 1:5.

2) For services beyond 60,000 miles (96,000 km), consult your "Mainte\
nance records booklet".
3) These intervals may apply, depending on actual driving conditions (\
see page 8:11 for details)
4) For proper functioning of the vehicle and its emission control syste\
m, Volvo recommends that the
timing belt be replaced every 70,000 (112,000 km).
pg. 8:5 Servicing (cont.)
Maintenance schedule

A = Adjust (Correct if necessary) I = Inspect (Correct or Replace if \
necessary)
R = Replace L = Lubricate
file:///K|/ownersdocs/1996/1996_850/96850_801.htm (4 of 6)12/30/2006 9\
:59:50 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
No. Lubrication point lubricant No. Lubrication point lubricant
1 Hood lock and latch Oil 6 Window winder (on
inside of door) Oil, grease, low
temperature grease
2 Door stop and hinges Oil 7 Front seat slide rail
and latch Oil
3 Sun roof wind
deflector Oil
Low temperature
grease
8
Door locks Volvo teflon lock
spray
4 Door lock catch plate Oil
5 Trunk/tailgate lid lock Low temperature
grease
To avoid rattles and unnecessary wear, the body should be lubricated at \
regular service intervals. This
should be done by an authorized Volvo retailer.
pg. 8:10 Engine oil
Checking the oil level

The oil level should be checked every time the car is refuelled. This is\
especially important during the
engine break-in period (up to the first service).
CAUTION : Not checking the oil level regularly can result in serious eng\
ine damage if the oil
becomes too low.
file:///K|/ownersdocs/1996/1996_850/96850_806.htm (6 of 11)12/30/2006 \
9:59:52 AMClassic Cars & Cycles www.ClassicCycles.org