1996 VOLVO 850 open gas tank

1996 Volvo 850
Volvo allows the use of the following "oxygenated fuels"; however, the o\
ctane ratings listed on this page
must still be met.

Alcohol -- Ethanol

Fuels containing up to 10% ethanol by volume may be used.
Ethanol may also be referred to as Ethyl alcohol, or "Gasohol".
Ethers -- MTBE
Fuels containing up to 15% MTBE may be used.

Refueling

The fuel tank filler cap is located behind the door on the left rear fen\
der. Open cap slowly during hot
weather conditions.
When filling, position the cap in the special bracket on the door.

NOTE: Turn the ignition off or to position I when refueling. If the igni\
tion is on, an incorrect reading
could occur in the fuel gauge (low fuel will be indicated).

After filling the tank, install the cap and turn until a "click" is hear\
d.
The fuel tank is designed to hold approximately 19.3 US gals (73 liters\
) with sufficient volume left over
to accommodate possible expansion of the fuel in hot weather. The "usabl\
e" tank capacity will be
somewhat less than the specified maximum. When the fuel level is low, su\
ch factors as ambient
temperature, the fuel's "vapor pressure" characteristics, and terrain ca\
n affect the fuel pumps' ability to
supply the engine with an adequate supply of fuel. Therefore, it is advi\
sable to refuel as soon as possible
when the needle nears the red zone, or when the fuel warning light comes\
on.
CAUTION: Do not refuel with the engine running. After refueling, close t\
he fuel filler cap by turning
it clockwise until it clicks into place.

NOTE: if the filler cap is not closed tightly or if the engine is runnin\
g when the car is refueled, the
Malfunction Indicator Lamp may indicate a fault. Use only Volvo original\
or approved fuel filler caps.

file:///K|/ownersdocs/1996/1996_850/96850_401.htm (4 of 8)12/30/2006 9\
:59:32 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
WARNING! Do not remove the coolant expansion tank
cap.

See "Coolant" to check and top-up the coolant level if necessary.
CAUTION: Drive slowly and carefully if going through standing water (i.\
e. flooded roadways, etc.).
Damage to engine could result if excess water is ingested through the ai\
r intake system.
Never drive the vehicle in water deeper than 1 foot (300 mm).
See the flood warning on page 3:7.
WARNING! Do not drive with trunk lid or tailgate open!
Poisonous exhaust gases may enter via the trunk lid or tailgate.
If the trunk lid/tailgate must be kept open for any reason, proceed as f\
ollows:
l Close the windows.
l Set the ventilation system control to air to floor, windshield and side \
windows and blower control to
its highest setting.
Electrical system

When replacing the battery or when carrying out work involving the elect\
rical system, the following
should be observed:
l A battery connection to the wrong terminal will damage the diodes. Befor\
e connections are made,
check the polarity of the battery with a voltmeter.
l If booster batteries are used for starting, they must be properly connec\
ted to minimize the risk of the
diode being damaged. For correct connection, see "Jump starting" section\
.
l Never disconnect the battery circuit (for example, to replace the batte\
ry) while the engine is running,
as this will immediately ruin the generator. Always make sure that all t\
he battery connections are
properly tightened.
l If any electrical-welding work is performed on the vehicle, the ground l\
ead and all the connecting
cables of the generator must be disconnected and the welder cables place\
d as near the welding point as
possible.
l The radio must be turned off before the battery is disconnected.
l The anti-theft code must be re-entered before the radio will function pr\
operly.
l The electrical system in your car is designed to accommodate Volvo acces\
sories. It also has an
accessory connector beneath the dashboard on the driver's side.
pg. 4:11 Points to remember
file:///K|/ownersdocs/1996/1996_850/96850_406.htm (8 of 10)12/30/2006 \
9:59:34 AMClassic Cars & Cycles www.ClassicCycles.org