1996 VOLVO 850 light

1996 Volvo 850
Occupant safety
pg. 3:1 Occupant safety
Occupant safety

3:2 Seat belts
3:4Volvo SRS
3:8Side Impact Protection System - (SIPS) air bag
3:9Child safety
3:13Occupant safety
3:13Reporting Safety Defects

Despite our strongest recommendations, and your best intentions, not wea\
ring a seat belt is like
believing "It'll never happen to me!". Volvo urges you and all adult occ\
upants of your car to wear seat
belts and ensure that children are properly restrained, using an infant,\
car or booster seat determined by
age, weight and height.
Fact: In every state and province, some type of child-restraint legislat\
ion has been passed. Additionally,
most states and provinces have already made it mandatory for occupants o\
f a car to use seat belts.
So, urging you to "buckle up" is not just our recommendation - legislati\
on in your state or province may
mandate seat belt usage. The few seconds it takes to buckle up may one d\
ay allow you to say, "It's a
good thing I was wearing my seat belt".

pg. 3:2 Seat belts
Seat belts

Always fasten the seat belts before you drive or ride.
Two lights above the rear view mirror will be illuminated for 4-8 second\
s after the starting (ignition) key
is turned to the driving position. A chime will sound at the same time i\
f the driver has not fastened his
file:///K|/ownersdocs/1996/1996_850/96850_301.htm (1 of 4)12/30/2006 9\
:59:27 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

A self-diagnostic system incorporated in the sensor monitors the SRS. Th\
is system does not, however,
monitor the SIPS airbags. If a fault is detected, the "SRS" warning ligh\
t will illuminate. The light is
included in the warning/indicator light cluster in the instrument panel.\
Normally, the SRS warning lamp
should light up when the ignition is switched on and should go out after\
10 seconds or when the engine
is started. Check that this light is functioning properly every time the\
car is started.

The following items are monitored by all the self-diagnostic system:
l Sensor unit
l Cable harness
l Gas generator ignitors
WARNING!
Never drive an SRS equipped car with your hands on the steering wheel pa\
d/airbag housing.
No objects, accessory equipment or stickers may be placed on, attached t\
o or installed near the SRS
cover in the center of the steering wheel, the SRS cover above the glove\
compartment or the area
affected by the airbag deployment.
If the SRS warning light stays on after the engine has started or if it \
comes on while you are driving,
drive the car to the nearest authorized Volvo retailer for inspection as\
soon as possible.

file:///K|/ownersdocs/1996/1996_850/96850_304.htm (3 of 10)12/30/2006 \
9:59:29 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
the SRS system warning light when starting and driving the car. Normally\
, this light will come on when
the ignition is switched on and should go out after approximately 10 sec\
onds or when the engine is
started. If this light should stay on or come on while you are driving, \
drive the car to an authorized
Volvo retailer for inspection as soon as possible.

Seat belts - the heart of the Volvo safety system

The heart of the Volvo safety system is the three-point seat belt! In or\
der for the SRS system to provide
the protection intended, seat belts must be worn at all times by everyon\
e in the car. The SRS system is a
supplement to the seat belts.
WARNING! If your car has been subjected to flood conditions (e.g. soake\
d carpeting/standing water
on the floor of the vehicle) or if your car has become flood-damaged in\
any way, do not attempt to
start the vehicle or put the key in the ignition before disconnecting th\
e battery (see below). This may
cause airbag deployment which could result in personal injury. Have the \
car towed to an authorized
Volvo retailer for repairs.
Automatic transmission only:
Before attempting to tow the car, use the following procedure to overrid\
e the shiftlock system to move
the gear selector to the neutral position.
l Disconnect the battery
l Wait at least one minute
l Insert the key in the ignition and turn it to position 1
l Press firmly on the shiftlock override button (located near the base of\
the gear selector).
l While holding the override button down, move the gear selector from the \
park position.
pg. 3:8 Volvo Side Impact Protection System (SIPS) airbag
file:///K|/ownersdocs/1996/1996_850/96850_304.htm (8 of 10)12/30/2006 \
9:59:29 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
Volvo allows the use of the following "oxygenated fuels"; however, the o\
ctane ratings listed on this page
must still be met.

Alcohol -- Ethanol

Fuels containing up to 10% ethanol by volume may be used.
Ethanol may also be referred to as Ethyl alcohol, or "Gasohol".
Ethers -- MTBE
Fuels containing up to 15% MTBE may be used.

Refueling

The fuel tank filler cap is located behind the door on the left rear fen\
der. Open cap slowly during hot
weather conditions.
When filling, position the cap in the special bracket on the door.

NOTE: Turn the ignition off or to position I when refueling. If the igni\
tion is on, an incorrect reading
could occur in the fuel gauge (low fuel will be indicated).

After filling the tank, install the cap and turn until a "click" is hear\
d.
The fuel tank is designed to hold approximately 19.3 US gals (73 liters\
) with sufficient volume left over
to accommodate possible expansion of the fuel in hot weather. The "usabl\
e" tank capacity will be
somewhat less than the specified maximum. When the fuel level is low, su\
ch factors as ambient
temperature, the fuel's "vapor pressure" characteristics, and terrain ca\
n affect the fuel pumps' ability to
supply the engine with an adequate supply of fuel. Therefore, it is advi\
sable to refuel as soon as possible
when the needle nears the red zone, or when the fuel warning light comes\
on.
CAUTION: Do not refuel with the engine running. After refueling, close t\
he fuel filler cap by turning
it clockwise until it clicks into place.

NOTE: if the filler cap is not closed tightly or if the engine is runnin\
g when the car is refueled, the
Malfunction Indicator Lamp may indicate a fault. Use only Volvo original\
or approved fuel filler caps.

file:///K|/ownersdocs/1996/1996_850/96850_401.htm (4 of 8)12/30/2006 9\
:59:32 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
CAUTION: Take care not to spill gasoline during refueling. Gasolines con\
taining alcohol can cause
damage to painted surfaces, which may not be covered under the New Vehic\
le Limited Warranty.
Do not use gasoline containing methanol (methyl alcohol, wood alcohol)\
. This practice can result in
vehicle performance deterioration and can damage critical parts in the f\
uel system. Such damage may
not be covered under the New Vehicle Limited Warranty.
pg. 4:4 Driving economy
Economical driving does not necessarily mean driving slowly

Better driving economy may be obtained by thinking ahead, avoiding rapid\
starts and stops and
adjusting the speed of your vehicle to immediate traffic conditions. Obs\
erve the following rules:
l Bring the engine to normal operating temperature as soon as possible by \
driving with a light foot on
the accelerator pedal for the first minutes of operation. A cold engine \
uses more fuel and is subject to
increased wear.
l Whenever possible, avoid using the car for driving short distances. This\
does not allow the engine to
reach normal operating temperature.
l Drive carefully and avoid rapid acceleration and hard braking.
l Do not exceed speed limit.
l Avoid carrying unnecessary items (extra load) in the car.
l Check tire pressure regularly (check when tires are cold).
l Remove snow tires when threat of snow or ice has ended.
l Note that roof racks, ski racks, etc., increase air resistance and there\
by fuel consumption.
l Avoid using automatic transmission kick-down feature unless necessary.
l Avoid using the air conditioning when it is not required. When engaged, \
the air conditioner's
compressor places places an additional load on the engine.
l If your car is equipped with the optional Trip Computer, utilizing the f\
uel consumption modes can
help you "learn" how to drive more economically.

Other factors which decrease gas mileage are:
l Low tire pressure
l Worn or dirty spark plugs
l Incorrect spark plug gap
l Dirty air cleaner
l Dirty engine oil and clogged oil filter
l Dragging brakes
l Incorrect front end alignment
file:///K|/ownersdocs/1996/1996_850/96850_401.htm (5 of 8)12/30/2006 9\
:59:32 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
Your car is equipped with a KEYLOCK system. When the engine is switched \
off, the gear selector must
be in the ( P )ark position before the starting key can be removed fro\
m the ignition switch.

5. Select desired gear. The gear engages after a slight delay (automati\
c transmission) which is especially
noticeable when selecting R.
CAUTION: (Automatic transmission only) The engine should be idling; ne\
ver accelerate until after
you feel the gear engage! Too rapid acceleration immediately after selec\
ting a gear will cause harsh
engagement and premature transmission wear.

NOTE: Selecting P or N (automatic transmission) when idling at a stand\
still for prolonged periods of
time will help prevent overheating of transmission oil.
WARNING! Always place the gear selector (automatic transmission) in Pa\
rk and apply the parking
brake before leaving the vehicle. Never leave the car unattended with th\
e engine running.
Always open the garage doors fully before starting the engine inside a g\
arage to ensure adequate
ventilation. The exhaust gases contain carbon monoxide, which is invisib\
le and odorless but very
poisonous.
TURBO CAUTION:
Never race the engine immediately after starting. Oil flow may not reach\
some lubricating points fast
enough to prevent engine damage.
Do not race the engine just prior to switching off!

Hydraulic valve lifters

This engine features hydraulic valve lifters which means that valve clea\
rance is adjusted automatically.
It is possible that the valve lifters will produce a ticking sound for t\
he first few seconds after the engine
is started, while the oil pressure is increasing.
If the car has not been used for a long period of time, this ticking sou\
nd may last for up to 15 minutes.
This is entirely normal.
Do not exceed 300 rpm until the ticking sound disappears.



file:///K|/ownersdocs/1996/1996_850/96850_401.htm (7 of 8)12/30/2006 9\
:59:32 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
governed by accelerator pedal position and vehicle speed.

3 (Intermediate position)

Automatically shifts up and down between 1st, 2nd, and 3rd gears when in\
driving modes E or S. There
is no upshift from 3rd gear. Position 3 can be used for driving in hilly\
terrain, for towing trailers or for
increased engine braking power.

L (low position)

No upshift can occur when L is engaged. Select position L for driving in\
first and second gears. Use this
position to select low gear with no upshift, e.g. when ascending and des\
cending steep grades. The
transmission will noticeably shift down from second to first if road spe\
ed drops to below 40 km/h (25
mph) when driving in E mode and below 10 km/h (6 mph in S mode.

Kick-down

Automatic shift to a lower gear (kick-down) is achieved by depressing \
the accelerator pedal fully and
briskly. An upshift will be achieved when approaching the top speed for \
a particular gear or by releasing
the accelerator pedal slightly. Kick-down can be used for maximum accele\
ration or when passing at
highway speeds.

"Lock-up"

The transmission has a "lock-up" function which reduces engine speed and\
saves fuel. "Lock-up" can
sometimes be felt as an additional gear change. pg. 4:8 Automatic transmission
file:///K|/ownersdocs/1996/1996_850/96850_406.htm (4 of 10)12/30/2006 \
9:59:34 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Shift gate positions

The gear selector can be moved freely between N and D. Selections of oth\
er positions are obtained by
depressing the selector knob prior to moving the selector.
Slightly depressing the selector knob allows selection of positions R, N\
, D, 3 and L. Fully depressing the
selector knob allows selection of positions P. This is also necessary wh\
en initially bringing the selector
out of position P. Fully depressing the selector knob thus permits shift\
ing freely between all positions.


Mode selector
file:///K|/ownersdocs/1996/1996_850/96850_406.htm (5 of 10)12/30/2006 \
9:59:34 AMClassic Cars & Cycles www.ClassicCycles.org