1996 VOLVO 850 transmission

1996 Volvo 850
mountainous areas.

NOTE: Refer to section "Automatic transmission" for additional trailer h\
auling tips.
WARNING!
l Bumper-attached trailer hitches must not be used on Volvos, nor should s\
afety chains be attached to
the bumper.
l Trailer hitches attaching to the vehicle rear axle must not be used.
l Never connect a trailer's hydraulic brake system directly to the vehicle\
brake system, nor a trailer's
lighting system directly to the vehicle lighting system. Consult your ne\
arest authorized Volvo retailer
for correct installation.
pg. 4:18 Winter driving
Cold weather precautions

l If you wish to check your car before the approach of cold weather, the f\
ollowing advice is worth
noting:
l Make sure that the engine coolant contains at least 50 percent antifreez\
e: that is, 3.7 qts. (3.5 liters)
Volvo Genuine Coolant/Antifreeze. This gives protection against freezing\
down to -31°F (-35°C). See
section "Coolant". The use of "recycled" antifreeze is not approved by V\
olvo. Different types of
antifreeze may not be mixed.
l Try to keep the fuel tank well filled - this prevents the formation of c\
ondensation in the tank. In
addition in extremely cold weather conditions it is worthwhile to add fu\
el line de-icer before refueling.
l The viscosity of the engine oil is important. Oil with low viscosity (t\
hinner oil) improves cold-
weather starting as well as decreasing fuel consumption while the engine\
is warming up. For winter use,
5W-30 oil, particularly the synthetic type, is recommended. Be sure to u\
se good quality oil but do not
use this cold-weather oil for hard driving or in warm weather. See secti\
on "Engine oil" for more
information.
l The load placed on the battery is greater during the winter since the he\
ater, windshield wipers,
lighting etc. are used more often. Moreover, the capacity of the battery\
decreases as the temperature
drops. In very cold weather, a poorly charged battery can freeze and be \
damaged. It is therefore
advisable to check the state of charge more frequently and spray an anti\
-rust oil on the battery posts.
l Volvo recommends the use of snow tires on all four wheels for winter dri\
ving - see section "Wheels
and tires".
l To prevent the washer reservoir from freezing, add washer solvents conta\
ining antifreeze (see page
file:///K|/ownersdocs/1996/1996_850/96850_412.htm (8 of 10)12/30/2006 \
9:59:35 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
8:15 for the location of the washer fluid reservoir). This is important sin\
ce the dirt is often splashed on
the windshield during winter driving, thus requiring frequent use of the\
washers and wipers. The Volvo
Washer Solvent should be diluted as follows:
Down to 14°F (-10°C): 1 part anti-freeze and 4 parts water
Down to 5°F (-15°C): 1 part anti-freeze and 3 parts water
Down to 0°F (-18°C): 1 part anti-freeze and 2 parts water
Down to -18°F (-28°): 1 part anti-freeze and 1 part water
l When driving in temperatures below 15 F (-10 C), we recommend the use \
of Volvo's radiator guard to
help the engine reach normal operating temperature as quickly as possibl\
e. This guard should not be
used when towing a trailer.
l Use Volvo Teflon Lock Spray in the locks.

NOTE: Avoid the use of de-icing spray as they can cause damage to the lo\
cks.

Winter/Wet mode

Enhanced Vehicle Traction

This mode may be selected for starting/moving off on slippery roads. In \
this mode:
* In position D, the gearbox starts in 3rd gear and changes up to 4th ge\
ar.
* In position 3, 2nd gear is locked and there is no change up to 3rd gea\
r.
In position L, first gear is locked.
* These positions always offer the kick-down feature.
pg. 4:19 Long distance trips, City driving
Before a long distance trip

It is always worthwhile to have your car checked at a Volvo retailer bef\
ore driving long distances. Your
retailer will also be able to supply you with bulbs, fuses, spark plugs \
and wiper blades for your use in the
event that problems occur.
If you prefer to check the car yourself, please note the following:
l Check that the engine runs smoothly and that fuel consumption is normal.\

l Check engine oil, coolant levels, and for possible fuel leakage.
l Check transmission oil level.
file:///K|/ownersdocs/1996/1996_850/96850_412.htm (9 of 10)12/30/2006 \
9:59:35 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
WARNING!
l The jack attachment must engage the bar in the jack attachment (A). Th\
e car's weight must not rest
on the jack's attachment (B).
l Be sure the jack is on a firm, level, non-slippery surface.
l Never allow any part of your body to be extended under a car supported b\
y a jack.
l Use the jack intended for the car when replacing a wheel. For any other \
job, use stands to support
the end of the car being worked on.
l Apply the parking brake, select position P (automatic transmission) or\
Reverse gear (manual
transmission).
l Block the wheels standing on the ground. Use rigid wooden blocks or larg\
e stones.
l The jack should be kept well-greased.

Installing the wheel

Clean the contact surfaces on the wheel and hub. Lift the wheel and plac\
e it on the hub. Make sure that
you align the wheel with the guide stud on the wheel hub prior to instal\
lation. Install the wheel bolts
cross-wise (see illustration) and tighten by turning lightly clockwise\
. Lower the vehicle to the ground
and alternately tighten the bolts to 81 ft. lbs. (110 NM). Install the\
wheel cap (where applicable).
CAUTION: Correct tightening torque on wheel bolts must be observed. The \
wheel bolts should never
be greased or lubricated. The extended, chromed wheel bolts must not be \
used with steel rims, as they
make is impossible to fit the hub caps.


Correct tightening order for wheel bolts
pg. 6:4 Spare tire
file:///K|/ownersdocs/1996/1996_850/96850_601.htm (4 of 5)12/30/2006 9\
:59:39 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Shiftlock release (automatic transmission only)

The gear selector is locked in the (P)ark position. To manually releas\
e the shiftlock:
l Turn the starting (ignition) key to position I
l Press firmly on the "SHIFTLOCK OVERRIDE" button located to the right of \
the base of the gear
selector
l While holding the override button down, press the button on the front of\
the gear selector
l Move the selector from the ( P )ark position.


Fuel tank cover does not open

Faulty motor in fuel tank cover
(Sedans):
Open the cover panel on the right tail light unit and pull on the hook. \

The fuel tank cover can then be opened.
(Wagons):
file:///K|/ownersdocs/1996/1996_850/96850_613.htm (7 of 8)12/30/2006 9\
:59:46 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
Volvo service
pg. 8:1 Volvo Service
Service - an investment!

An investment which will pay dividends in the form of improved reliabili\
ty, durability, and resale value.

8:2 Label Information
8:3Maintenance service, Warranty
8:4Maintenance schedule
8:6Servicing
8:9Lubrication
8:10Engine oil
8:12Power steering fluid, Brake/clutch system fluid reservoir
8:13Automatic transmission fluid
8:14Drive belt, Air pump system
8:15Windshield washer nozzle, Washer fluid reservoir
8:16Coolant
8:17Engine compartment
pg. 8:2 Label information
1 Vehicle Emission Control Information
Your Volvo is designed to meet all applicable emission standards, as evi\
denced by the certification label
on the underside of the hood. For further information regarding these re\
gulations, please consult your
Volvo retailer.
2 Vacuum hose routing
(underside of hood)
3 Loads and Tire Pressures
(on inside of fuel tank cover)
4 Model plate
Vehicle Identification Number (VIN). Codes for color and upholstery et\
c. This plate is located on panel
file:///K|/ownersdocs/1996/1996_850/96850_801.htm (1 of 6)12/30/2006 9\
:59:50 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
EMISSION SYSTEM
MAINTENANCE



Engine oil and filter
1 R
3 R R 3 R R 3 R R 3 R R 3 R R 3 R
Engine drive belt accessory belt) R
Air cleaner filter R R
Spark plugs R R
Automatic transmission fluid

I
I I I I I
Timing belt - B 5254 S, B 5234 T
4


1) See section "Engine oil" for detailed information.

NOTE: The oil should be changed at these intervals or after 750 hours of\
driving or after 12 months
which ever occurs first. See "Service Reminder indicator",
page 1:5.

2) For services beyond 60,000 miles (96,000 km), consult your "Mainte\
nance records booklet".
3) These intervals may apply, depending on actual driving conditions (\
see page 8:11 for details)
4) For proper functioning of the vehicle and its emission control syste\
m, Volvo recommends that the
timing belt be replaced every 70,000 (112,000 km).
pg. 8:5 Servicing (cont.)
Maintenance schedule

A = Adjust (Correct if necessary) I = Inspect (Correct or Replace if \
necessary)
R = Replace L = Lubricate
file:///K|/ownersdocs/1996/1996_850/96850_801.htm (4 of 6)12/30/2006 9\
:59:50 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
pg. 8:13 Automatic transmission fluid

Check the oil level as follows:

Park the car on a level surface with the engine idling . Slowly move the\
gear selector lever through all
the shift positions and then to position P. Wait 3 minutes before checki\
ng the oil level.
As the illustration shows, the dipstick has a COLD and a HOT side. The o\
il level should between the
MIN and MAX marks. Wipe the dipstick with a clean cloth.
WARNING! The oil may be very
hot.

Do not use rags that could leave lint on the dipstick. The transmission \
is topped up via the dipstick tube.
The space between the MIN and MAX marks on the dipstick corresponds to 0\
.5 US qt. (0.5 liter). Do
not fill the transmission with too much oil, since this can result in oi\
l being ejected from the
transmission. Too little oil, on the other hand, can negatively affect t\
ransmission operation, particularly
in very cold weather.

A Cold transmission: oil temperature 105° F (40° C). This is a n\
ormal temperature for the transmission
after idling for about 10 minutes. At oil temperatures below 105° F (\
40° C), the level may be below the
MIN mark.
B Warm transmission: oil temperature 169° F (80° C). This temper\
ature after driving for about 30
minutes. At oil temperatures above 190° F (90° C), the level may\
be above the MAX mark.

Fluid type: ATF Dexron IIE/III and Mercon.
file:///K|/ownersdocs/1996/1996_850/96850_813.htm (1 of 7)12/30/2006 9\
:59:53 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
CAUTION: The cooling system must always be kept filled to correct level.\
If it is not kept filled, there
can be high local temperatures in the engine which could result in damag\
e. Different types of anti-
freeze/coolant may not be mixed.
pg. 8:17 Engine compartment
Engine compartment 850
(engine B 5254 S / B 5252 S)


1 Expansion tank, coolant
2 Engine designation plate
3 Oil filler cap, engine
4 Clutch/brake system fluid reservoir
5 Fuse box
6 Washer fluid reservoir
7 Power steering fluid reservoir
8 Dipstick - engine oil
9 Dipstick - automatic transmission
10 Air cleaner
11 Battery
12 Data plate
WARNING! The cooling fan may start or continue to operate (for up to 6 \
minutes) after the engine has
been switched off.
pg. 8:18 Engine compartment (cont.)
Engine compartment 850 Turbo
(engine B 5234 T)
1 Expansion tank, coolant
2 Engine designation plate
3 Oil filler cap, engine
4 Clutch/brake system fluid reservoir
5 Fuse box
6 Washer fluid reservoir
7 Power steering fluid reservoir
8 Dipstick - engine oil
file:///K|/ownersdocs/1996/1996_850/96850_813.htm (6 of 7)12/30/2006 9\
:59:53 AMClassic Cars & Cycles www.ClassicCycles.org