1996 VOLVO 850 cooling

1996 Volvo 850


Washer fluid reservoir

The washer fluid reservoir is located in the engine compartment and hold\
s approx. 3.2 US qts. (3.0
liters).
During cold weather, the reservoir should be filled with windshield wash\
er solvent containing anti-
freeze. pg. 8:16 Coolant
Check coolant level

The cooling system must be filled with coolant and not leak to operate a\
t maximum efficiency. Check
the coolant level regularly. The level should be between the "MAX" and "\
MIN" marks on the expansion
tank. The check should be made with particular thoroughness when the eng\
ine is new or when the
cooling system has been drained.
Do not remove the filler cap other than for topping up with coolant. Fre\
quent removal may prevent
coolant circulation between the engine and the expansion tank during eng\
ine warm up and cooling.

Changing coolant

file:///K|/ownersdocs/1996/1996_850/96850_813.htm (4 of 7)12/30/2006 9\
:59:53 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Normally, the coolant does not need to be changed. If the system must be\
drained, use the following
procedure:
1 Remove the expansion tank cap.
2 Move the temperature adjustment control to max. heat. Open the drain c\
ocks at the rear left of the
engine block and at the bottom right corner of the radiator.
3 Disconnect the lower right radiator hose.
Filling:
4 Close the drain cocks and reconnect the hose.
5 Fill the expansion tank to the MAX mark or slightly above.
6 Run the engine until hot. Check the cooling system connections for tig\
htness. Recheck the coolant
level.

Capacity: Approx. 7.6 US qts. (7.2 liters)
Turbo - 7.4 US qts. (7.0 liters)

Coolant: Volvo Genuine Coolant/Antifreeze only

NOTE: Do not top up with water only. Water by itself reduces the rust-pr\
otective and anti-freeze
qualities of the coolant and has a lower boiling point. It can also caus\
e damage to the cooling system if it
should freeze.
WARNING: If the engine is warm and you are going to top up coolant, unsc\
rew the cap slowly in
order to allow any excess pressure to escape.
file:///K|/ownersdocs/1996/1996_850/96850_813.htm (5 of 7)12/30/2006 9\
:59:53 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
CAUTION: The cooling system must always be kept filled to correct level.\
If it is not kept filled, there
can be high local temperatures in the engine which could result in damag\
e. Different types of anti-
freeze/coolant may not be mixed.
pg. 8:17 Engine compartment
Engine compartment 850
(engine B 5254 S / B 5252 S)


1 Expansion tank, coolant
2 Engine designation plate
3 Oil filler cap, engine
4 Clutch/brake system fluid reservoir
5 Fuse box
6 Washer fluid reservoir
7 Power steering fluid reservoir
8 Dipstick - engine oil
9 Dipstick - automatic transmission
10 Air cleaner
11 Battery
12 Data plate
WARNING! The cooling fan may start or continue to operate (for up to 6 \
minutes) after the engine has
been switched off.
pg. 8:18 Engine compartment (cont.)
Engine compartment 850 Turbo
(engine B 5234 T)
1 Expansion tank, coolant
2 Engine designation plate
3 Oil filler cap, engine
4 Clutch/brake system fluid reservoir
5 Fuse box
6 Washer fluid reservoir
7 Power steering fluid reservoir
8 Dipstick - engine oil
file:///K|/ownersdocs/1996/1996_850/96850_813.htm (6 of 7)12/30/2006 9\
:59:53 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
9 Dipstick - automatic transmission
10 Air cleaner
11 Battery
12 Data plate
WARNING! The cooling fan may start or continue to operate (for up to 6 \
minutes) after the engine has
been switched off.




Contents | Top of Page
file:///K|/ownersdocs/1996/1996_850/96850_813.htm (7 of 7)12/30/2006 9\
:59:53 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
Specifications
pg. 9:1 Specifications
Specifications

This chapter contains facts and figures pertaining to the technical spec\
ifications of your car.

9:2 Oil/Fluids specifications
9:3Engine specifications
9:4Cooling/fuel distributor ignition systems
9:4Front/rear suspensions
9:5Transmission, Capacities, Vehicle
loading
9:6
Electrical system/bulbs
9:7Dimensions and weights
9:8Service manuals, Road assistance
pg. 9:2 Oil/Fluids Specifications
Oil quality

Meeting API specification SG, SG/CD, SH or Energy Conserving (EC) II \
For best fuel economy and engine protection, consult with your authorize\
d Volvo retailer for
recommended oils. Oil with a different quality rating may not provide ad\
equate engine protection.
Synthetic oils complying with oil quality requirements are recommended. \
Volvo recommends the use of
fuel economy improving oils. Look for the API label.
Synthetic oils complying with oil quality requirements are recommended f\
or: Driving in areas of
sustained temperature extremes (hot or cold), when towing a trailer ov\
er long distances or for prolonged
driving in mountainous areas.
Extra oil additives must not be used unless advised by an authorized Vol\
vo retailer.

Viscosity (stable ambient temperatures):
file:///K|/ownersdocs/1996/1996_850/96850_901.htm (1 of 7)12/30/2006 9\
:59:55 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
for 30 seconds:

237 hp at 5600 rpm (177 Kw at 94 rps)
Torque:
221 ft. lbs. at 2000-5600 rpm (300 Nm at 33-94 rps)

The output power on cars with a manual transmission is:
247 hp at 5400 rpm (184 Kw at 90 rps)
Torque:
258 ft. lbs. at 2400-5000 rpm (350 Nm at 40-83 rps)

All specifications are subject to change without notice. pg. 9:4 Specifications
Cooling system

Type: Positive pressure, closed system
Thermostat begins to open at 186°F (90°C)
Turbo 180° F (87° C)
Coolant: Volvo original coolant/anti-freeze
Capacity: 7.6 US qts. (7.2 liters)
Turbo - 7.4 US qts. (7.0 liters)

Fuel system

The engine is equipped with a multiport fuel injection system

Distributor ignition system

Firing order 1-2-4-5-3
Distributor ignition setting Not adjustable
Spark plugs Bosch FR 6 DC (or equivalent)
file:///K|/ownersdocs/1996/1996_850/96850_901.htm (4 of 7)12/30/2006 9\
:59:55 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
1st gear 3.07:1
2nd gear 1.77:1
3rd gear 1.19:1
4th gear 0.87:1
5th gear 0.70:1
Reverse 2.99:1

Automatic transmission: AW 50-42 LE
4-speed automatic electronically controlled gearbox comprising a hydraul\
ic torque converter with a lock-
up function; planetary gear, integrated final drive.
Operation via a floor mounted gear selector lever. Drive shafts with sym\
metrical joint location.

Final drive ratio 2.74:1 (Turbo: 2.54:1)
Reduction ratios
1st gear 3.61:1
2nd gear 2.06:1
3rd gear 1.37:1
4th gear 0.98:1
Reverse 3.95:1

Capacities

Fuel tank 19.3 US gals (73 liters)
Cooling System 7.4 US qts. (7.0 liters)
Engine oil (incl. filter) 5.6 US qts. (5.3 liters)*
Automatic transmission 2 US gals (7.6 liters)
Manual transmission 2.2 US qts. (2.1 liters)
Power steering fluid 0.8 US qts. (0.8 liter)
Washer fluid reservoir 3.2 US qts. (3.0 liters)
Brake/clutch system 0.6 US qts (0.6 liters)

* Certain models: 6.1 US qts. (5.8 liters)
Turbo: Add 0.95 US qt. (0.9 liters) if the oil cooler has been drained\
.

Vehicle Loading

file:///K|/ownersdocs/1996/1996_850/96850_901.htm (6 of 7)12/30/2006 9\
:59:55 AMClassic Cars & Cycles www.ClassicCycles.org