1996 PONTIAC FIREBIRD fuel cap

Be careful not to spill gasoline. Clean gasoline from
painted surfaces as soon as possible! See “Cleaning the
Outside
of Your Pontiac” in the Index.
When
you plat the cap back on, turn it to the right until
you hear at least three clicks. Make sure you fully install
the cap. The diagnostic system can determine if the fuel
cap
has been left of or improperly installed. This would
allow fuel to evaporate into
the atmosphere. See
“Malfunction Indicator
Lamp” in the Index.
NOTICE:
If you need a new cap, be sure to get the right
type. Your dealer can get one for you, If you get
the
wrong type, it may not fit and your fuel tank
and emissions system might
be damaged.
.j
Checking Things Und-- the Hoop
An electric fan under the hood can start up and
injure you even when the engine is not running.
Keep hands, clothing and tools away
from any
underhood electric fan.
Things that burn can get on hot engine
parts and
start a fire. These include liquids like gasoline,
oil,
coolant, brake fluid, windshield washer and
other fluids, and plastic or rubber. You or others
could be burned. Be careful not to drop or spill
things
that will burn onto a hot engine.
6-6 .:
ProCarManuals.com

Before closing the hood, be sure all the filler caps are on.
Then just pull the hood down and
close it firmly.
Engine Oil
LOW
OIL
If the LOW OIL light
on the instrument
panel comes on, it
means you need to
check your engine oil
level right away.
5.7L LT1 (Code P) Oil Dipstick
The engine oil dipstick is the yellow
loop near the back
of the engine.
For more information, see
"Low 0il.Light" in the Index.
You
should check your engine oil level regularly; this is
an added reminder.
It's a good idea to check your engine oil every time you
get fuel. In order to get an accurate reading, the oil must
be
warm and'the vehicle must be on level ground.
ProCarManuals.com

Inflation -- Tire Pressure
The Tire-Loading Information label, located on the
driver’s door, shows the correct inflation pressures for
your tires when they’re cold. “Cold“ means your vehicle\

has been sitting for
at least three hours or driven no
more than 1 mile ( 1.6 km).
If you’ll be driving at speeds higher than 100 mph
(160 km/h) where it is legal, raise the cold inflation
pressure
of each tire to 35 psi (240 Pa). When you end
this very high-speed driving, reduce the cold inflation
pressures to those listed on the Tire-Loading
Information label.
NOTICE:
~ ~~ ~~ ~
Don’t let anyone tell you that underinflation or
overinflation
is all right. It’s not. If your tires
don’t have enough air (underinflation),
you can
get the following:
Too much flexing
e Too much heat
0 Tire overloading
NOTICE: (Continued)
~ ~~~~
NOTICE: (Continued)
0 Bad wear
0 Bad handling
Bad fuel economy.
If your tires have too much air (overinflation),
you can get the following:
0 Unusual wear
Bad handling
0 Rough ride
Needless damage fram road hazards.
When to Check
Check your tires once a-month or more.
Don’t forget your compact spare tire. It should be
at 61) psi (420 kPa).
How to Check
Use a good quality pocket-type gage to check tire
pressure. You can’t tell if your tires are properly inflated
simply by looking at them.
Radial tires may look properly
inflated even when they’re underidlated.
Be sure to put the valve caps back on the valve stem.
They help prevent
leaks by keeping out dirt and moisture.
ProCarManuals.com

Capacities and Specifications
Engine
Type VIN Engine Code
K ...................... V6
VTN Engine Code P ...................... V8
Fuel Delivery .................... Fuel Injection
Valve Arrangement
.................... In-Head
Piston Displacement
..........................
VINEngine Code K ............ 231 CID (3.8L)
VIN Engine Code
P ............ 350 CID (5.7L)
VIN Engine Code K .............. 1-6-5-4-3-2
VIN Engine Code P ......... 1-8-4-3-6-5-7-2
Wheel Nut Torque ............ 100 lb-ft (140 N-m)
Windshield Wiper Blade Replacement
Type ............ ................. hook
Length ........ ... 24 inches (610 mm)
Firing Order
Capacities (Approximate)
The following approximate capacities are given in
English and metric conversions.
Air Conditioning?
............. See the refrigerant
information label under the hood.
Automatic Transmission
Drain and Refill ............... 10 pints (4.7 L)*
Overhaul
VIN Engine Code
K ......... 17.6 pints (8.3 L)*
VIN Engine Code P ........ 21 ..6 pints (10.2 L)*
VIN Engine Code K V)
With Manual Transmission .... 12.5 quarts (11.8 L)
With' Automatic "ransmissjon . 12.3 qums (1 1.6 L)
VIN Engine Code P
With Manual Transmission ... 15.3 quarts (14.5 L)
With Automatic Transmission 15.1 quarts (14.3
L)
Cooling System
6-69
ProCarManuals.com

Capacities (Approximate) (Continued)
Crankcase
Oil and Filter Change
3800 (WN K) ............ 4.5 quarts (4.3 L)**
5.7 L (VIN P) ............ 5.0 quarts (4.7 L)**
Fuel Tank .................. 15.5 gallons (58.7 L)
Five-Speed ................. 6.8 pints (3.2 L)*
Six-Speed .................. 8.0 pints (3.8 L)*
Rear Axle Lubricant ............ 3.5 pints (1 .TL)
Manual Transmission
+Not all air conditioning refrigerants are the same.
If the air conditioning system in your vehicle needs
refrigerant, be sure the proper refrigerant is used.
If you’re not sure, ask your Pontiac dealer.
*Recheck fluid level after filling. See “Automatic
Transmission
Fluid” or “Manual Transmission Fluid”
in the Index.
**Recheck the oil level after filling. See “Engine Oil” in
the Index.
Vehicle Dimensions
Wheelbase
Front Tread
Rea’ Tread
Length
Firebird / Formula
Trans
Am
Width
Height
101.1 inches (2 566 mm)
60.7 inches (1 542 mm)
60.7 inches (1 540 mm)
195.6 inches (4 968 mm)
197.0 inches ( 5 005 mm)
74.5 inches (1 893 mm)
52.10 inches (1 323, nun)
ProCarManuals.com

Replacement Parts Air Conditioning Refrigerants
Air Cleaner Filter Not all air conditioning refrigerants are the same.
VIN Engine Code P .................. A1163C refrigerant, be sure the proper refrigerant is used.
VIN Engine Code P (with WS6 Option) A1097C
Battery
............................... .75-60
Engine
Oil Filter
..... .;+ VIN Engine Code K .................. A1163C If the air conditioning system in your vehicle needs I . . '. .~ ,..I . ,. ,
If you're not sure, ask your Pontiac dealer. ...
. VIN Engine Code K ..................... PF47
VIN Engine Code
P .................... PF25
Fuel Filter
............................. GF578
PCV Valve
VIN Engine Code
K ................. CV892C
VIN Engine Code P ................. CV895C
Radiator Cap
........................... RC24
Spark Plug
VIN Engine Code K ....... -41-921 (0.060" Gap)
VIN Engine Code P ....... e41-943 (0.050" Gap)
Specification
................... 180°F (82°C)
Thermostat Temperature
I 6r't
ProCarManuals.com

Maintenance Schedule
Short Trip/City Definition
Follow the Short TripKity Maintenance Schedule if any
one
of these conditions is true for your vehicle:
0 Most trips are less than 5 to 10 miles (8 to 16 km).
This is particularly important when outside
temperatures are below freezing.
0 Most trips include extensive idling (such as frequent
driving in stop-and-go traffic).
$0 Most trips are through dusty areas.
You frequently tow a trailer or use a carrier on top of
0 If the vehicle is used for delivery service, police, taxi
One ofthe reasons you should follow this schedule if you
operate your vehicle under any of these conditions is that
these conditions cause engine oil to break down
soonel:
your vehicle.
or other commercial application.
Short Trip/City Intervals
~~
Every 3,000 Miles .(5 000 km): Engine Oil and Filter
Every 6,000 Miles (10 000 km): Chassis Lubrication
Change
(or 3 months, whichever occurs first).
(or
6 months, whichever occurs first).
- I
Short Trip/City Intervals
At 6,000 Miles (10 000 km) -- .Then
Every 12,000 Miles (20 000 km): Tire Rotation.
Every 6,000 Miles (10 000 km) of Trailering:
Rear Axle Fluid Change (Vehicles Towing Trailers).
At the First 6,000 Miles (10 000 Ism): Rear Axle Fluid
Change (Limited-Slip Differential).
Every 15,000 Miles (25 000 km): Air Cleaner Filter
Inspection, if driving in dusty conditions. Automatic
Transmission Service (severe conditions only).
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement, Fuel Tank, Cap and
Lines Inspection.
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection.
Every 100,000 Miles (166 000 km): Cooling System
Service
(or every 60 months, whichever occurs fust).
Spark Plug Wire Inspection. Spark Plug Replacement.
Automatic Transmission Service (normal conditions).
These intervals only summarize maintenance services.
Be
sure to follow the complete maintenance schedule on
the following pages.
7-4
ProCarManuals.com

Maintenance Schedule
Lung Trip/Highway Definition Long Trip/Highway Intervals
Follow this maintenance schedule only if none of the
conditions from the Short Trip/City Maintenance
Schedule is true.
Driving a vehicle with a fully warmed engine under
highway conditions causes engine oil to break
down slower.
Every 7,500 Miles (12 500 km): Engine Oil and Filter
Change (or every
12 months, whichever occurs fist).
Chassis Lubrication (or every
12 months, whichever
occurs first).
At the First 7,500 Miles (12 500 km): Rear Axle Fluid
Change (Limited-Slip Differential).
At 7,500 Miles (12 500 km) -- Then Every
15,000 Miles (25
000 km): Tire Rotation.
Every 15,000 Miles (25 000 km): Automatic
Transmission Service (severe conditions
only).
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement. Fuel Tank, Cap and Lines Inspection.
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection.
Every 100,000 Miles (166 000 km): Cooling System
Service (or every
60 months, whichever occurs first).
Spark Plug Wire Inspection: Spark Plug Replacement.
Automatic Transmission Service (normal conditions).
These intervals only summarize maintenance services.
Be sure to follow the complete maintendnce schedule on
the following pages.
7-5
ProCarManuals.com