1996 Oldsmobile Cutlass Supreme air filter

1. Air Cleaner
To check or replace the air filter, remove the four screws
and pull
off the cover. Pull
out the filter. Be sure to install the air filter and
install the cover tightly when you are finished.
Refer to the Maintenance Schedule to determine when to
replace the air filter.
See “Scheduled Maintenance Services” in the Index.
6-16

I
Operating the.engine wi4.h the air cleaner oi’fcan
cause you or .others to be burned. The
air cleaner
not only cleans the
air, it stops flame if the engine
backfires. Hit isn’t there, and the engine
backfires, you could
be burned. Don’t drive with
it off, and be careful working on the engine with
the
air cleaner off.
NOTICE:
If the air cleaner is off, a backfii can cause a
damaging engine fire. And, dirt can easily get
into
your engine, which will damage it. Always
have the
air cleaner in place when you’re driving.
-1 -. .. ..
Automatk Transaxle’ Fluid
When to Check and Change
A good time to check your automaticdransaxle fiui,d
level is when the engine
oil is changed.
Change both the fluid and. filter ,every
30,000 miles
(83 000 km) if the, vehicle is mainly ‘driven under one or
more of these conditions:
’
In heavy city traffic where the outside temperature
regularly reaches
90 OF (32 O C) or higher;.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in :taxi, polide or delivery service. ,.,
If you do not use your vehicle under any of these
conditions, the fluid and filter
.. do not require changing.
See “Scheduled Maintenance Services” in the Index.
I

Capacities and Specifications
Automatic Transaxle
Pan Removal and Replacement .... 7 quarts (6.7 L)
After Complete Overhaul ....... 10 quarts (9.5 L)
When draining transaxle convertel; more and/or less
converter fluid may be needed.
Cooling System Including Reservoir
3.1L (Code M) ............ 11.6 quarts (10.93 L)
3.4L (Code X) ............. 12.3 quarts (11.65 L)
Refrigerant (R- I34a),
Air Conditioning*
............. 2.0 pounds (0.91 kg)
Engine Specifications
Type .................................
Displacement ..........................
Compression Ratio .....................
Firingorder ..........................
Thermostat Temperature .................
Valve Arrangement .....................
Horsepower ...........................
Engine Crankcase -- Oil and Filter Change
3.1L L82 (Code M) ........... 4.5 quarts (4.2 L)
3.4L LQ1
(Code X) ........... 5.5 quarts (5.2 L)
Fuel Tank ................. 17.1 gallons (64.7 L)
*See “Air Conditioning Refrigerants” later in this section.
3.1L (Code M)
V6
191 CID (3.1L)
9.6: 1
1-2-3-4-5-6
195°F (91°C)
In-Head
160 @ 5200
3.4L (Code X)
V6
207
CID (3.4L)
9.25: 1
1-2-3-4-5-6
195°F (91 “C)
In-Head
215 @ 5200
6-69

Vehicle Dimensions Normal Maintenance Replacement Parts
Wheelbase ............. 107.5” (2730 inm)
Tread Width
Front
................. 59.5”(1512 mm)
Rear .................. 58.0” (1472 mm)
Overall Length Coupe
............... 193.9” (4926 mm)
Sedan ................ 193.7” (492 1 mm)
Overall Width ............ 7 1 .O” ( 1804 mm)
Overall Height
Coupe
................ 53.3” (1 353 mm)
Sedan.. ............... 54.8”(1391 mm)
Air Conditioning Refrigerants
Not all air conditioning refrigerants are the same.
If
the air conditioning system in your vehicle needs
refrigerant, be sure the proper refrigerant is used.
If you’re not sure, ask your Oldsmobile retailer.
Air Cleaner Filter
Battery
All Engines ......................... A1208C
3.1L (Code
M) ...................... 525 CCA
3.4L (Code
X) ...................... 690 CCA
Engine Oil Filter
3.1L (Code M) ........................ PF47
3.4L(CodeX)
......................... PF51
3.1L (Code
M) ..................... CV892C
3.4L (Code X)
.......... : ........... CV895C
All Engines
........................... RC27
3.1L (Code
M) ............... AC. Type 41-940
Gap:
0.060” (1.52 mm)
3.4L (Code X) ................ AC Type 41-919
Gap: 0.045” (1.14
mm)
Length ........................ 20” (510 mm)
Type
...................................p in
PCV Valve
Radiator Cap
Spark Plugs
Windshield Wiper Blade Replacement
6-70

.Maintenance Schedule
I Short Trip/City Definition I
Follow the Short TripKity Maintenance Schedule if any
one of these conditions is true for your vehicle:
Most trips are less than 5 to 10 miles (8 to 16 km).
This is particularly important when outside
temperatures are below freezing.
driving in stop-and-go traffic).
Most trips include extensive idling (such as frequent
0 Most trips are through dusty areas.
0 You frequently tow a trailer or use a carrier on top of
your vehicle.
If the vehicle is used for delivery .service, police, taxi
or other commercial application.
One of the reasons you should follow this schedule ifyou
operate your vehicle under any
of these conditions is that
these conditions cause engine oil to break down soonez
Short TriplCity Intervals
Every 3,000 Miles (5 000 km): Engine Oil and Filter
Change (or
3 months, whichever occurs first).
Every 6,000 Miles (10 000 km): Chassis Lubrication
(or
6 months, whichever occurs first).
At 6,000 Miles (10 000 km) -- Then Every
12,000 Miles
(20 000 km): Tire Rotation.
Every 15,000 Miles (25 000 km): Air Cleaner Filter
Inspection, if 'driving in dusty conditions.
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement. Fuel Tank, Cap and Lines Inspection.
Every '50,000 Miles (83 000 km): Automatic Transaxle
Service (severe conditions only).
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection.
At 60,000 Miles (100 000 km) -- Then Every
15,000 Miles
(25 000 km): Camshaft Timing Belt
Inspection (3.4L Code
X engine only);
Every 100,000 Miles (166 000 km): Cooling System
Service (or every
60 months, whichever occurs first).
Spark.Plug Wire Inspection. Spark Plug Replacement.
These intervals only summarize maintenance services.
Be sure to follow the complete rnainten.ance schedule on
the following pages.
7-4

Maintenance Schedule
1 Long Trip/Highway Definition
Follow this maintenance schedule only if none of the
conditions
from the Short TripKity Maintenance
Schedule is
true.
Driving a vehicle with a fully warmed engine under
highway conditions causes engine oil to break
down slowez
Every 7,500 Miles (12 500 km): Engine Oil and Filter
Change (or every 12 months, whichever occurs first).
Chassis Lubrication
(or every 12 months, whichever
occurs first).
At 7,500 Miles (12 500 km) -- Then ,Every
15,000 Miles (25 000 km): Tire Rotation.
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement. Fuel Tank, Cap and Lines Inspection.
Every 50,000 Miles (83 000 km): Automatic Transaxle
SerVice (severe conditions only).
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection.
At 60,000 Miles (100 000 km) -- Then Every
15,000
Miles (25 000 km): Camshaft Timing Belt
Inspection
(3.4L Code X engine only).
Every 100,000 Miles (166 000 km): Cooling System
Service (or every
60 months, whichever occurs first).
Spark Plug Wire Inspection. Spark Plug Replacement.
These intervals only summarize maintenance services.
Be sure to
follow the complete maintenance schedule on
the following pages.
7-5

I
I I Short Trip/City Maintenance Schedule I
12,000 Miles (20 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first). I
0 Lubricate steering ball joints (or every
6 months, whichever occurs first).
An Emission Control Service.
DATE ACTUAL MILEAGE SERVICED BY:
, r
15,000 Miles (25 000 km)
17 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Inspect air cleaner filter if you are driving
in dusty conditions. Replace filter
if
necessary. An Emission Control Service.
7-8

I Short Trip/City Maintenance Schedule I
30,000 Miles (50 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
Lubricate steering ball joints (or every
6 months, whichever occurs first).
[7 Replace air cleaner filter.
An Emission Control Service.
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service.
0 Rotate tires. See “Tire Inspection and
Rotation’’ in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers for
freedom of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
DATE SERVICED BY: ACTUAL MILEAGE
.7-11