Page 269 of 394
![FORD WINDSTAR 1996 1.G Owners Manual Roadside Emergencies
267
%*
[RE03800(ALL)01/93]
Changing a Flat Tire
*
[RE03900(ALL)01/95]
If you get a flat tire while you are driving, do not apply the
brake heavily. Instead, gradually decrease the FORD WINDSTAR 1996 1.G Owners Manual Roadside Emergencies
267
%*
[RE03800(ALL)01/93]
Changing a Flat Tire
*
[RE03900(ALL)01/95]
If you get a flat tire while you are driving, do not apply the
brake heavily. Instead, gradually decrease the](/manual-img/11/5410/w960_5410-268.png)
Roadside Emergencies
267
%*
[RE03800(ALL)01/93]
Changing a Flat Tire
*
[RE03900(ALL)01/95]
If you get a flat tire while you are driving, do not apply the
brake heavily. Instead, gradually decrease the speed. Hold the
steering wheel firmly and slowly move to a safe place on the
side of the road. Park on a level spot, turn off the ignition, set
the parking brake, and turn on the hazard flashers.
% [RE04000(ALL)02/95]
Using the Spare Tire
*
[RE04100(ALL)03/94]
Your vehicle has a temporary spare tire (unless you ordered the
optional full-size spare tire). This spare tire is smaller than a
regular tire and is designed for emergency use only. Use it only
when you get a flat tire and replace it as soon as you can. This
spare tire is marked with the words TEMPORARY USE ONLY
so that you can easily identify it.
*
[RE04200(ALL)01/93]
RWARNING
If you use the temporary spare tire continuously or do
not follow these precautions, the tire could fail, causing
you to lose control of the vehicle, possibly injuring
yourself or others.
*
[RE04300(ALL)02/95]
When you drive with the temporary spare tire, DO NOT:
*
[RE04500(ALL)02/95]
n
exceed 50 mph (80 km/h) under any circumstances
*
[RE04600(ALL)01/93]
n
load your vehicle so that it is heavier than the maximum
vehicle load rating listed on the tire decal
*
[RE04700(ALL)01/93]
n
tow a trailer
*
[RE04800(ALL)01/93]
n
use tire chains
*
[RE04900(ALL)01/93]
n
try to repair the temporary spare tire or remove it from its
wheel
File:wnres.ex
Update:Tue Mar 19 08:18:21 1996
Page 272 of 394
![FORD WINDSTAR 1996 1.G Owners Manual 270
*
[RE06200(ALL)09/93]
10-1/2 pica
art:0040173-B
Removing the spare tire retainer
%*
[RE06800(ALL)03/95]
Changing the Tire
*
[RE06900(ALL)05/94]
You should only raise your vehicle with a jack prope FORD WINDSTAR 1996 1.G Owners Manual 270
*
[RE06200(ALL)09/93]
10-1/2 pica
art:0040173-B
Removing the spare tire retainer
%*
[RE06800(ALL)03/95]
Changing the Tire
*
[RE06900(ALL)05/94]
You should only raise your vehicle with a jack prope](/manual-img/11/5410/w960_5410-271.png)
270
*
[RE06200(ALL)09/93]
10-1/2 pica
art:0040173-B
Removing the spare tire retainer
%*
[RE06800(ALL)03/95]
Changing the Tire
*
[RE06900(ALL)05/94]
You should only raise your vehicle with a jack properly placed
at the front or rear jacking points.
*
[RE07000(ALL)12/93]1.
Make sure that your vehicle will not move or roll. Put the
gearshift lever in P (Park). Set the parking brake and block
the wheel Ð in both directions Ðthat is diagonally opposite
the tire that you are changing.
*
[RE07100(ALL)01/93]
RWARNING
When one of the front wheels is off the ground, the
transaxle alone will not prevent the vehicle from moving
or slipping off the jack, even if the vehicle is in P (Park).
*
[RE07200(ALL)01/93]
RWARNING
To prevent the vehicle from moving when you change a
tire, be sure the parking brake is set, then block (in both
directions) the wheel that is diagonally opposite (other
side and end of the vehicle) to the tire being changed.
File:wnres.ex
Update:Tue Mar 19 08:18:21 1996
Page 302 of 394
![FORD WINDSTAR 1996 1.G Owners Manual 302
*
[SV02700(ALL)01/95]
n
Never get under a vehicle while it is supported by a jack
only. If you must work under a vehicle, use safety stands.
*
[SV02800(ALL)01/95]
n
Keep all lit cigarettes and oth FORD WINDSTAR 1996 1.G Owners Manual 302
*
[SV02700(ALL)01/95]
n
Never get under a vehicle while it is supported by a jack
only. If you must work under a vehicle, use safety stands.
*
[SV02800(ALL)01/95]
n
Keep all lit cigarettes and oth](/manual-img/11/5410/w960_5410-301.png)
302
*
[SV02700(ALL)01/95]
n
Never get under a vehicle while it is supported by a jack
only. If you must work under a vehicle, use safety stands.
*
[SV02800(ALL)01/95]
n
Keep all lit cigarettes and other smoking materials away
from the battery and all fuel-related parts.
*
[SV02900(ALL)03/95]
Working Under the Hood
[SV03000(ALL)02/95]
Before you open the hood, read this section carefully.
*
[SV03100(ALL)02/95]
If you plan to work under the hood while the engine is
off:
*
[SV03200(ALL)01/93]
RWARNING
Set the parking brake and make sure the gearshift is
securely latched in P (Park). This will prevent your
vehicle from moving unexpectedly.
*
[SV03300(ALL)01/93]
RWARNING
Always remove the key from the ignition after you turn
off the engine.
*
[SV03400(ALL)03/95]
If you must work under the hood while the engine is
on:
[SV03500(ALL)05/95]
RWARNING
Set the parking brake and make sure that the gearshift is
securely latched in P (Park). This will prevent your
vehicle from moving unexpectedly.
*
[SV03600(ALL)03/95]
RWARNING
Do not wear loose clothing or jewelry that can get caught
in the moving parts.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996
Page 317 of 394
![FORD WINDSTAR 1996 1.G Owners Manual Servicing Your Windstar
317
*
[SV15000(ALL)01/95]
Neveruse:
*
[SV15100(ALL)01/95]
n
ªNon-Detergentº oils
*
[SV15200(ALL)04/95]
n
Oils labeled API SA, SB, SC, SD, SE, SF or SG
%*
[SV15300(ALL)01/95]
FORD WINDSTAR 1996 1.G Owners Manual Servicing Your Windstar
317
*
[SV15000(ALL)01/95]
Neveruse:
*
[SV15100(ALL)01/95]
n
ªNon-Detergentº oils
*
[SV15200(ALL)04/95]
n
Oils labeled API SA, SB, SC, SD, SE, SF or SG
%*
[SV15300(ALL)01/95]](/manual-img/11/5410/w960_5410-316.png)
Servicing Your Windstar
317
*
[SV15000(ALL)01/95]
Neveruse:
*
[SV15100(ALL)01/95]
n
ªNon-Detergentº oils
*
[SV15200(ALL)04/95]
n
Oils labeled API SA, SB, SC, SD, SE, SF or SG
%*
[SV15300(ALL)01/95]
n
Additional engine oil additives, oil treatments or engine
treatments
%*
[SV15400(ALL)03/95]
Engine oils with anSAE 5W-30viscosity arePREFERREDfor
your vehicle. They provide the best engine performance, fuel
economy and engine protection for all climates down to-15ÊF
(-25ÊC).
%*
[SV15550(ALL)03/95]
Synthetic engine oils which are CERTIFIED and of the preferred
viscosity may be used in your engine. The engine oil and oil
filter must still be changed according to the maintenance
schedule.
%*
[SV15600(ALL)01/95]
Checking and Adding Engine Oil
*
[SV15700(ALL)03/95]
Since the proper amount of engine oil is important for safe
engine operation, check the oil using the dipstick each time you
put fuel in your vehicle. Remember the engine must be off, the
oil must be warm and the vehicle must be parked on level
ground.
%*
[SV15800(ALL)03/95]
Checking the engine oil level:
*
[SV15900(ALL)02/95]1.
Turn the engine off after it has warmed up and allow a few
minutes for the engine oil to drain back into the oil pan.
*
[SV16000(ALL)03/95]2.
Set the parking brake, making sure the gearshift is securely
latched in P (Park).
*
[SV16100(ALL)02/95]3.
Open the hood. Protect yourself from engine heat.
[SV16200(ALL)08/94]4.
Locate the dipstick labelled ªEngine Oilº and carefully pull it
out of the engine.
*
[SV16300(ALL)01/95]5.
Wipe the dipstick clean and put it back into position, making
sure it is fully seated.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996
Page 336 of 394
![FORD WINDSTAR 1996 1.G Owners Manual 336
%*
[SV31700(ALL)02/93]
Checking the Automatic Transaxle Fluid
*
[SV31800(ALL)01/93]
With the vehicle on a level surface, start the engine and move
the gearshift lever through all of the gear range FORD WINDSTAR 1996 1.G Owners Manual 336
%*
[SV31700(ALL)02/93]
Checking the Automatic Transaxle Fluid
*
[SV31800(ALL)01/93]
With the vehicle on a level surface, start the engine and move
the gearshift lever through all of the gear range](/manual-img/11/5410/w960_5410-335.png)
336
%*
[SV31700(ALL)02/93]
Checking the Automatic Transaxle Fluid
*
[SV31800(ALL)01/93]
With the vehicle on a level surface, start the engine and move
the gearshift lever through all of the gear ranges allowing
sufficient time for each position to engage. Securely latch the
gearshift lever in the P (Park) position, fully set the parking
brake and leave the engine running.
*
[SV32000(ALL)01/93]
Wipe off the dipstick cap, pull the dipstick out and wipe the
indicator end clean. Put the dipstick back into the filler tube and
make sure it is fully seated. Pull the dipstick out and read the
fluid level.
[SV32100(ALL)10/93]
When checking fluid at normal operating temperature, the fluid
level should be within the crosshatched area on the dipstick.
[SV32200(ALL)08/94]
7-1/2 pica art:0050021-A
The automatic transmission dipstick
[SV32250(ALL)11/93]
NOTE: Your vehicle should not be driven until some fluid
has been added if the fluid level is below the bottom
hole on the dipstick and the outside temperature is
above50ÊF (10ÊC). Addonly enough fluid to bring the
level above the bottom hole. The fluid level should be
rechecked at normal operating temperature.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996
Page 368 of 394
368
[SV47350(ALL)10/93]
RWARNING
Fuel system components may be damaged by torches and
welding equipment.
%*
[SV47400(ALL)01/95]
Cooling system
*
[SV47500(ALL)01/93]
n
Protect your vehicle against freezing temperatures.
%*
[SV47600(ALL)01/95]
Battery
*
[SV47700(ALL)01/93]
n
Check and recharge the battery as necessary.
*
[SV47800(ALL)01/95]
n
Keep connections clean and covered with a light coat of
grease.
%*
[SV47900(ALL)01/95]
Brakes
*
[SV48000(ALL)01/93]
n
Make sure the brakes and parking brake are fully released.
%*
[SV48100(ALL)01/95]
Tires
*
[SV48200(ALL)05/95]
n
Maintain recommended air pressure.
*
[SV48300(ALL)01/95]
Miscellaneous
*
[SV48400(ALL)01/93]
n
Make sure all linkages, cables, levers and clevis pins under
the vehicle are covered with grease to prevent rust.
*
[SV48500(ALL)01/93]
n
Lubricate working parts to prevent corrosion.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996
Page 381 of 394

383
Index
Brakes (continued)
noise........................ 242
parking...................... 244
stopping distances.................. 243
trailer....................... 256
when storing your vehicle.............. 368
Brake-shift interlock.................. 236
Break-in period..................... 4
Built-in child seat
cleaning....................... 37
operation....................... 27
Bulbs, replacing
headlamps..................... 352
specifications.................... 358
C
Canada, customer assistance.............. 292
Canadian Motor Vehicle Arbitration Plan (CAMVAP) . . . 292
Capacities for refilling fluids.............. 363
Carbon monoxide in exhaust............... 62
Cargo net....................... 192
Car seats for children (see Child safety seats)....... 39
Cassette tape player
(see Electronic sound system)......213, 225, 228
Catalytic converter................... 359
CD player (see Electronic sound system)......... 201
Chains, tires...................... 333
Changing a tire.................... 267
Charging system warning light............ 72,85
Childproof locks.................... 144
Child safety restraints.................. 25
built-in child seat................... 27
child safety belts................... 38
child safety seats................... 39
Child safety seats
and air bags................... 20,39
attaching with tether straps.............. 50
File:wnixs.ex
Update:Tue Mar 19 08:12:49 1996
Page 384 of 394

386
Electronic sound system (continued)
radio reception................... 232
tuning the radio..............197, 209, 226
warranty and service information........... 234
Electronic stereo cassette radio
(see Electronic sound system).......... 225
Emergencies, roadside
assistance..................... 283
battery acid spills................261, 325
jump-starting.................... 261
towing....................... 281
Emergency brake (parking brake)............ 244
Emission control system
catalytic converter.................. 359
emissions warranty................. 360
Engine
check engine warning light............ 70,86
does not start..................... 61
fuel injected engine, starting.............. 57
fuel pump shut-off switch............... 61
preparing to start................... 57
service points.................... 305
starting....................... 55
starting after a collision............... 280
storing your vehicle................. 367
Engine block heater................... 60
Engine coolant
checking and adding................ 319
checking hoses................... 323
preparing for storage................ 368
proper solution...............321±322, 337
specifications.................... 365
Engine coolant temperature gauge, description..... 78,93
Engine knocking................... 311
Engine oil
changing oil and oil filter.............. 318
checking and adding................ 317
dipstick...................... 317
File:wnixs.ex
Update:Tue Mar 19 08:12:49 1996