1996 FORD RANGER set

276
%*
[SV13775(ALL)01/95]
Checking and Adding Engine Oil
*
[SV13800(ALL)03/95]
Since the proper amount of engine oil is important for safe
engine operation, check the oil using the dipstick each time you
put fuel in your vehicle. Remember the engine must be off, the
oil must be warm and the vehicle must be parked on level
ground.
%*
[SV13900(ALL)04/95]
Checking the engine oil level:
*
[SV14000(ALL)02/95]1.
Turn the engine off after it has warmed up and allow a few
minutes for the engine oil to drain back into the oil pan.
*
[SV14050(ALL)06/95]2.
Set the parking brake, making sure the gearshift is securely
latched in P (Park) or 1 (manual transmission).
*
[SV14100(ALL)02/95]3.
Open the hood. Protect yourself from engine heat.
*
[SV14200(ALL)03/95]4.
Locate the engine oil dipstick (highlighted in yellow) and
carefully pull it out of the engine.
*
[SV14300(ALL)01/95]5.
Wipe the dipstick clean and put it back into position, making
sure it is fully seated.
[SV14400(ALL)10/94]
7-1/2 pica art:0021256-B
Engine oil dipstick
[SV14500(ALL)10/94]6.
Carefully, pull the dipstick out again. If the oil level is below
the ªADDº line, add engine oil as necessary. If the oil level
is beyond the letter ªFº in Full, engine damage or high oil
consumption may occur and some oil must be removed from
the engine.
*
[SV14600(ALL)01/95]7.
Put the dipstick back in and make sure it is fully seated.
File:15unsvr.ex
Update:Wed May 1 13:56:18 1996

300
*
[SV33701(ALL)05/95]
It is preferable to check the transmission fluid level at normal
operating temperature, after approximately 20 miles (30 km) of
driving. However, if necessary, you can check the fluid level
without having to drive 20 miles to obtain a normal operating
temperature if outside temperatures are above50ÊF (10ÊC).
*
[SV33801(ALL)01/95]
NOTE: If the vehicle has been operated for an extended
period at high speeds or in city traffic during hot
weather, or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow the fluid to
cool before checking.
%*
[SV33901(ALL)02/95]
Checking the Automatic Transmission Fluid
*
[SV33910(ALL)06/95]
With the vehicle on a level surface, start the engine and move
the transmission shift selector through all of the gear ranges
allowing sufficient time for each position to engage. Securely
latch the transmission shift selector in the P (Park) position,
fully set the parking brake and leave the engine running.
[SV33920(R )09/95]
NOTE: Vehicles equipped with the 4x4 option must have the
4x4 shift selector in any position other than neutral. If
in neutral the vehicle may move.
*
[SV33930(ALL)10/89]
RWARNING
Your vehicle should not be driven if the fluid level is
below the bottom hole on the dipstick and outside
temperatures are above50ÊF (10ÊC).
*
[SV33940(ALL)08/95]
Wipe off the dipstick cap (located on the passenger's side of the
engine), pull the dipstick out and wipe the indicator end clean.
Put the dipstick back into the filler tube and make sure it is
fully seated. Pull the dipstick out and read the fluid level.
File:15unsvr.ex
Update:Wed May 1 13:56:18 1996

Servicing Your Ranger
325
*
[SV49800(ALL)02/92]
Never use a metal exhaust collector when you service your
vehicle. If the metal collector contacts any of your vehicle's
plastic trim or bumper parts they could melt or deform.
*
[SV49900(ALL)01/95]
Do not drive your vehicle if it does not operate properly. See
your dealer if the engine runs on for more than five seconds
after you shut it off or if it misfires, surges, stalls, or backfires.
%*
[SV50000(ALL)05/95]
Information about your vehicle's emission control system is on
the Vehicle Emission Control Information decal located on or
near the engine. This decal identifies engine displacement and
gives some tune-up specifications.
%*
[SV51475(ALL)07/95]
Readiness for Inspection/Maintenance Testing
*
[SV51480(ALL)07/95]
In some localities it may become a legal requirement to pass an
Inspection/Maintenance (I/M) test of the On-Board Diagnostic
(OBD) II system. If the vehicle's powertrain system or its battery
has just been serviced, the OBD II system is reset to a not ready
for I/M testing condition. To prepare for I/M testing, the law
specifies a ªneed for additional mixed city and highway driving
to complete the checkº of the OBD II system. As soon as all of
the OBD II system checks are successfully completed, the OBD
II system is set to the ready condition. The amount of driving
required to reach the ready condition varies with individual
driving patterns. To complete this requirement in the minimum
amount of time, refer to the OBD II Drive Cycle defined below.
If the vehicle owner cannot or does not want to do the
additional driving required by law, a service center can perform
this drive cycle as it would any other type of repair work.
File:15unsvr.ex
Update:Wed May 1 13:56:18 1996

Index
349
A
Accessory position on the ignition............. 41
Accessory power source, power point outlet....... 126
Additives, engine oil.................. 275
Air bag supplemental restraint system
and child safety seats................. 36
description.................... 25,30
disposal....................... 34
driver air bag................... 25,30
indicator light..................... 58
operation....................... 30
passenger air bag................... 30
proper seating.................... 27
service and information labels............. 30
tone generator.................. 31,34
wearing safety belts.................. 26
Air cleaner filter
location...................... 262
specifications.................... 330
Alarm, activating remote personal............ 104
Antenna, radio (see Electronic sound system).....127, 152
Antifreeze (see Engine coolant)............. 278
Anti-lock brake system (ABS)
description..................... 177
noise........................ 179
see also Brake.................... 177
Anti-theft system
arming the system.................. 107
description..................... 107
disarming an untriggered system........... 108
disarming a triggered system............. 108
triggering...................... 107
Appeals (see Dispute settlement board)......... 243
Assistance (see Customer assistance)........... 241
File:unixr.ex
Update:Wed May 1 13:58:05 1996

351
Index
Brakes (continued)
fluid, checking and adding.............. 304
fluid, refill capacities................ 304
fluid, specifications................. 331
front disc...................... 177
if brakes do not grip well.............. 181
master cylinder................... 304
new brake linings................... 5
noise......................177, 181
parking...................... 182
power braking................... 177
rear anti-lock.................... 178
servicing....................181, 304
stopping distances................182, 184
trailer....................... 214
when storing your vehicle.............. 336
Brake-shift interlock.................. 157
Break-in period..................... 5
Brights (high beams)................. 67,88
Bulbs, replacing.................... 317
halogen...................... 318
headlamps..................... 318
C
Canada, customer assistance.............. 248
Canada, warranty information.............. 3
Carbon monoxide in exhaust............... 50
Car seats for children (see Child safety seats)....... 36
Cassette tape player (see Electronic sound system) . . 133, 149
Catalytic converter................... 323
Chains, tires...................... 295
Changing a tire.................... 223
Charging system gauge................. 64
Charging system warning light.............. 62
Child safety restraints
child safety belts................... 39
child safety seats................... 36
File:unixr.ex
Update:Wed May 1 13:58:05 1996

354
D
Dashboard (see Instrument panel)............. 73
Daytime running light system.............. 82
Defects, reporting................... 247
Defrost, windshield................. 77,80
Dipstick
automatic transmission fluid...........299, 301
engine oil..................... 276
power steering fluid................. 305
Disabled vehicle (see Towing)............. 234
Dispute Settlement Board............... 243
Doors......................... 99
lubricant specifications................ 331
Driveline universal joint and slip yoke......... 303
Driving under special conditions
bad weather.................... 185
heavy load..................... 188
high speed..................... 185
high water..................... 187
slippery roads................... 185
tips for safe driving................. 184
towing a trailer................... 191
E
Electrical system
fuses......................308, 314
operating when the engine is off............ 41
power point outlet................. 126
relays....................... 315
Electronic sound system
accessory delay.................... 41
radio reception................... 152
tuning the radio................130, 146
warranty and service information........... 154
Electronic stereo cassette radio (see Electronic
sound system)................. 129
Electronic stereo radio (see Electronic sound system) . . . 129
File:unixr.ex
Update:Wed May 1 13:58:05 1996

356
Engine idle speed control................ 47
Engine oil
changing oil and oil filter.............. 276
checking and adding................ 276
dipstick...................... 276
disposal..................258, 278, 301
engine oil pressure gauge............... 65
filter, specifications................. 330
specifications..................275, 331
synthetic oil.................... 275
ªbreak-inº oils.................... 5
viscosity...................... 275
Entry system
illuminated..................... 106
remote....................... 103
Exhaust fumes..................... 50
Extended Service Plan, Ford............... 4
F
Fan, engine fan, avoiding injury............ 258
Federal Communications Commission.......... 154
Flashers, hazard..................... 90
Flashing the lamps................... 88
Flat tire....................... 223
Foglamps........................ 81
Ford Dispute Settlement Board............. 243
Ford Extended Service Plan............... 4
Ford Motor Company of Canada............ 248
Ford of Canada Customer Assistance Centre....... 248
Foreign registration.................. 249
Four-Wheel Drive vehicles
description..................... 167
driving off road................... 174
lever operated................... 167
special driving instructions.............. 176
special notice..................... 4
Four-wheeling with Ford supplement........... 4
French owner guides, how to obtain........... 3
File:unixr.ex
Update:Wed May 1 13:58:05 1996

366
Spare tire (continued)
changing the tire................223, 227
conventional spare...............223, 225
finding the spare.................. 225
removing the spare tire............... 225
storing the flat tire...............225, 229
temporary spare.................. 223
Spark plugs, specifications............... 330
Special driving conditions............... 184
Special notice
E-4WD vehicles.................... 4
four wheel drive vehicles............... 4
Specification chart, lubricants.............. 331
Speed control
accelerating...................... 96
canceling a set speed................. 98
resetting....................... 96
resuming a set speed................. 98
tap up/tap down................... 96
when towing a trailer................ 215
Speedometer...................... 70
Starting your vehicle
preparing to start your vehicle............. 44
starting a cold engine................. 46
starting after a collision................ 48
starting a warm engine................ 46
starting your vehicle if the battery is disabled..... 219
Steering, power.................... 166
Steering wheel
horn......................... 92
locking........................ 41
speed controls.................... 93
tilting........................ 92
Storing your vehicle.................. 334
Supplemental air bag readiness light........... 58
Supplemental Restraint System (SRS)........... 25
File:unixr.ex
Update:Wed May 1 13:58:05 1996