1996 FORD F SERIES MOTORHOME AND COMMERCIAL CHASSIS oil pressure

19 [ST10675( M)07/91]
q
HEATING Ð Set fan speed at MEDIUM or
HIGH, the function selector knob on VENT,
FLOOR, FLR DEF or DEFROST symbol and
the temperature control knob on any desired
position.
[ST10850( M)07/91]
q
AIR CONDITIONING Ð Set the fan speed at
MEDIUM or HIGH, the function selector
lever on NORM or VENT and the
temperature control knob on any desired
position.
[ST10865( M)06/90]
TAPPET NOISE
[ST10875( M)06/90]
It is normal for the oil to drain down from the
hydraulic tappets in your engine during
extended shutdown periods (overnight). As a
result, these tappets may clatter for a few
seconds after the engine starts until oil pressure
builds up. This momentary start-up noise is
normal and is not harmful to engine operation.
File:ltstm.ex
Update:Tue Jun 20 16:47:24 1995

28
*
[LG07500( ALL)05/94]
Engine Oil Pressure Gauge
*
[LG07601( ALL)06/93]
This gauge indicates the engine's oil pressure,
not the oil level. However, if your engine's oil
level is low, it could affect the oil pressure. With
the engine running, the pointer should move
into the NORMAL band. If the pointer drops
below the NORMAL band while the engine is
running, you have lost oil pressure and
continued operation will cause severe engine
damage.
*
[LG07701( ALL)03/95]
If you lose engine oil pressure:
*
[LG07801( ALL)01/95]
1. Pull off the road as soon as safely possible.
*
[LG07901( ALL)04/95]
2. Shut off the engine immediately or severe
engine damage could result.
*
[LG08001( ALL)02/95]
3. Check the engine's oil level, following the
instructions on checking and adding engine
oil. Refer toEngine oilin the Index. If you
do not follow these instructions, you or
others could be injured. To assure an
accurate reading, your vehicle should be on
level ground.
*
[LG08051( ALL)03/93]
4. If the level is low, add only as much oil as
necessary before you start the engine again.
Do not overfill. Do not operate the engine if
the pointer is below the NORMAL band,
regardless of the oil level. Contact your
nearest dealer for further service actions.
[LG08250( E M)03/93]
quarter page art:0020059-D
Engine oil pressure gauge
File:ltlgm.ex
Update:Tue Jun 20 16:47:10 1995

Severe Duty Schedule 179
*
[BK50501( ALL)01/95]
6,000 MILES (10,000 Kilometers)
*
[BK50601( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK50650( ALL)94/93]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK50801( ALL)04/93]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK50901( ALL)05/93]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK50910( ALL)05/94]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK51001( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK51150( ALL)04/93]
four pica chart:0060627-A
*
[BK51201( ALL)01/95]
9,000 MILES (15,000 Kilometers)
*
[BK51301( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK51350( ALL)04/93]
four pica chart:0060627-A
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

180 Severe Duty Schedule
*
[BK51401( ALL)01/95]
12,000 MILES (20,000 Kilometers)
*
[BK51501( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK52001( ALL)04/93]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK52101( ALL)05/93]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK52110( ALL)05/94]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK52201( FM)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK52350( ALL)04/93]
four pica chart:0060627-A
*
[BK52401( ALL)01/95]
15,000 MILES (25,000 Kilometers)
*
[BK52501( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK52550( ALL)05/95]
q
Inspect engine cooling system, hoses, and clamps;
and check coolant strength every 15,000 miles
(25,000 km) or 12 months.
*
[BK52601( ALL)94/93]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK52801( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK52901( ALL)04/94]
q
Inspect drum brake systems, hoses and lines.
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

182 Severe Duty Schedule
*
[BK54101( ALL)01/95]
21,000 MILES (35,000 Kilometers)
*
[BK54201( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK54225( ALL)01/95]
q
Change automatic transmission fluid.
*
[BK54250( ALL)04/93]
four pica chart:0060627-A
*
[BK54301( ALL)01/95]
24,000 MILES (40,000 Kilometers)
*
[BK54401( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK54501( ALL)94/93]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK54801( ALL)04/93]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK54901( ALL)05/93]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK54910( ALL)05/94]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK55101( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK55301( ALL)05/93]
q
Lubricate throttle kickdown or TV lever ball
studs.
*
[BK55350( ALL)04/93]
four pica chart:0060627-A
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

184 Severe Duty Schedule
*
[BK56400( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK56700( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK56800( ALL)04/94]
q
Inspect drum brake systems, hoses and lines.
*
[BK56900( ALL)04/94]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK57000( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK57100( ALL)04/93]
q
Inspect parking brake system for damage and
operation.
q
Inspect parking brake fluid (F-Super Duty
only).
*
[BK57450( FM)06/94]
q
Change rear axle lube (F-Super Duty only).
(4)
*
[BK57520( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK57550( ALL)04/93]
four pica chart:0060627-A
*
[BK57600( ALL)01/95]
33,000 MILES (55,000 Kilometers)
*
[BK57700( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK57750( ALL)94/93]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK58050( ALL)04/93]
four pica chart:0060627-A
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

186 Severe Duty Schedule
*
[BK59300( ALL)01/95]
42,000 MILES (70,000 Kilometers)
*
[BK59400( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK59425( ALL)01/95]
q
Change automatic transmission fluid.
*
[BK59450( ALL)94/93]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK59600( ALL)04/93]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK59700( ALL)05/93]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK59750( ALL)05/94]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK59800( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK59950( ALL)04/93]
four pica chart:0060627-A
*
[BK60000( ALL)01/95]
45,000 MILES (75,000 Kilometers)
*
[BK60100( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK60150( ALL)05/95]
q
Inspect engine cooling system, hoses, and clamps;
and check coolant strength every 15,000 miles
(25,000 km) or 12 months.
*
[BK60400( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK60500( ALL)04/94]
q
Inspect drum brake systems, hoses and lines.
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

188 Severe Duty Schedule
*
[BK61500( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK61800( ALL)05/93]
q
Lubricate throttle kickdown or TV lever ball
studs.
*
[BK62150( ALL)04/93]
four pica chart:0060627-A
*
[BK62200( ALL)01/95]
51,000 MILES (85,000 Kilometers)
*
[BK62300( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK62340( ALL)94/93]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK62350( ALL)04/93]
four pica chart:0060627-A
*
[BK62400( ALL)01/95]
54,000 MILES (90,000 Kilometers)
*
[BK62500( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK62700( ALL)04/93]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK62800( ALL)05/93]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK62850( ALL)05/94]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995