1996 FORD F SERIES MOTORHOME AND COMMERCIAL CHASSIS lights

36
*
[SC01800( ALL)11/89]
If the turn indicator light in the instrument
panel does not illuminate or remains on (doesn't
flash) when you signal a turn, the turn signaling
system is malfunctioning. Have this condition
corrected as soon as possible, but make sure that
you use the accepted hand signals in the
meantime.
*
[SC03200( ALL)05/95]
High Beams
*
[SC03300( ALL)05/95]
To turn on the high beams, turn the headlamp
control knob to the headlamp ON position and
push the turn signal lever away from you until
it latches. When the high beams are ON, the
high beam indicator light on the instrument
panel comes on.
*
[SC03400( ALL)05/95]
To turn off the high beams, pull the lever
toward you until it latches. The high beam
indicator light turns off.
*
[SC03800( ALL)05/95]
one third page art:0020074-B
Headlamp high beam switch and turn signal lever
*
[SC04200( ALL)05/95]
Flashing the Lights
*
[SC04300( ALL)06/95]
To flash the headlamps, pull the lever toward
you for a moment and then release it. The
headlamps will flash whether the headlamp
knob is in the on or off position.
File:ltscm.ex
Update:Tue Jun 20 16:46:36 1995

79
Roadside Emergencies
%*
[RE00400( ALL)03/95]
Jump-Starting Your Vehicle
*
[RE00500( ALL)01/95]
Your vehicle's battery may die if you leave the
lights on or any electrical equipment on after
you turn the engine off. If this happens, you
may be able to jump-start from a booster battery
to start your vehicle.
*
[RE00600( ALL)02/95]
RWARNING
The gases around the battery can explode
if exposed to flames, sparks, or lit
cigarettes. An explosion could result in
injury or vehicle damage.
*
[RE00700( ALL)02/95]
RWARNING
To protect yourself when charging a
battery, always shield your face and eyes.
Make sure that you can breathe fresh air.
%*
[RE00800( ALL)05/95]
RWARNING
Applying too much pressure on the ends
when lifting a battery could cause acid to
spill. Lift the battery with a carrier or
with your hands on the opposite corners.
%*
[RE00900( ALL)05/95]
RWARNING
Batteries contain sulfuric acid which burns
skin, eyes, and clothing.
File:ltrem.ex
Update:Tue Jun 20 16:45:33 1995

81
*
[RE01500( ALL)03/95]
4. Check all battery terminals and remove any
excessive corrosion before you attach the
jumper cables.
*
[RE01600( ALL)02/95]
5. Turn on the heater fan in both vehicles.
Turning on the fan helps protect the
electrical system from voltage surges. Turn
off all other switches and lights in both
vehicles to prevent possible damage to either
vehicle's electrical systems.
%*
[RE01700( ALL)05/95]
Connecting the jumper cables
*
[RE01800( ALL)03/95]
1. Connect one end of the first jumper cable to
the positive (+) terminal of the discharged
battery. (You can connect either jumper cable
to the positive (+) terminal, as long as you
use the same cable for both positive
terminals.) Most jumper cables have a red
cable and a black cable. The red cable is
generally used for the positive terminals and
the black for the negative ones.
*
[RE01900( ALL)04/95]
2. Connect the other end of the first cable to
the positive (+) terminal of the booster
battery.
*
[RE02000( ALL)05/95]
3. Connect one end of the second cable to the
negative (-) terminal of the booster battery
Ð NOT to the discharged battery.
*
[RE02100( ALL)04/95]
4. Connect the other end of the second cable to
a good metallic surface on the engine or
frame of the disabled vehicle.
*
[RE02200( ALL)05/95]
RWARNING
Do not connect the end of the second
cable to the negative (-) terminal of the
battery to be jumped. A spark may cause
an explosion of the gases that surround
the battery.
File:ltrem.ex
Update:Tue Jun 20 16:45:33 1995

141 %
*
[SV35800( ALL)03/91]
Driveline Universal Joint and
Slip Yoke
[SV36050( M)06/93]
The universal joints that come standard with
your vehicle do require lubrication. Lubrication
will be necessary at the intervals shown in the
Maintenance Schedule and Recordbooklet.
%
*
[SV36300( ALL)03/95]
Brake Fluid
*
[SV36350( ALL)05/90]
Your vehicle is equipped with a brake fluid level
indicator in the master cylinder which lights the
BRAKE warning light on the instrument panel
when the brake fluid level is low.
*
[SV36400( ALL)04/95]
Under normal circumstances, your vehicle
should not use up brake fluid rapidly. However,
expect the level of the brake fluid to slowly fall
as you put more mileage on your vehicle and
the brake lining wears.
*
[SV36500( ALL)10/89]
Check the brake fluid at least once a year. You
can do this by looking at the fluid level in the
plastic reservoir on the master cylinder. The
fluid level should be at or near the MAX mark.
*
[SV36550( ALL)05/95]
RWARNING
Brake fluid is toxic.
*
[SV36560( ALL)06/95]
If brake fluid contacts eyes, flush eyes with
running water for 15 minutes. Get medical
attention if irritation persists. If taken internally,
drink water and induce vomiting. Get medical
attention immediately.
%*
[SV36600( ALL)02/95]
If the fluid is low, carefully clean and remove
the filler cap from the reservoir. Fill the
reservoir to the MAX line with Ford High
Performance DOT 3 Brake Fluid C6AZ-19542-AA
or DOT 3 equivalent fluid meeting Ford
specification ESA-M6C25-A.
File:ltsvm.ex
Update:Tue Jun 20 16:44:35 1995

Index 213
Engine knocking............ 113
Engine oil
changing oil and oil filter....... 121
checking and adding......... 120
dipstick............... 120
disposal...........122, 126, 140
engine oil pressure gauge........ 28
filter, specifications.......... 164
refill capacities............ 164
specifications............. 119
synthetic oil............. 119
ªbreak-inº oils............. 7
Exhaust fumes.............. 18
Extended Service Plan, Ford........ 4
F
Federal Highway Administration
Regulation............... 7
Flashers, hazard.............. 38
Flashing the lights............. 36
Flat tire................. 83
Fluid refill capacities.......... 164
Ford Customer Assistance Center...... 94
Ford Dispute Settlement Board....... 95
Ford Extended Service Plan........ 4
Ford Motor Company of Canada..... 101
Ford of Canada Customer
Assistance Centre........... 101
Foreign registration........... 100
Four-Wheel Drive vehicles, special notice . . 5
French owner guides, how to obtain.... 3
Fuel
calculating fuel economy....... 117
capacity............... 164
choosing the right fuel........ 112
filling your vehicle with fuel...... 111
filter, specifications.......... 164
fuel gauge............... 29
improving fuel economy....... 118
octane rating............. 112
File:ltixm.ex
Update:Tue Jun 20 16:42:52 1995

Index 215
GVWR (Gross Vehicle Weight Rating)
calculating............... 67
definition............... 65
H
Hazard flashers.............. 38
Headlamps
bulb specification........... 156
daytime running lights......... 34
flashing................ 36
high beam............... 36
turning on and off........... 33
High beams
indicator light............. 29
operation............... 36
Hitch.................. 73
Horn................... 39
Hoses, checking............. 127
I
Identification Number, Vehicle (VIN).... 5
Idle, relearning.............. 82
Ignition
positions of the ignition......... 9
removing the key............ 10
Instrument cluster............. 21
mechanical............... 23
Interval wipers.............. 37
J
Jump-starting your vehicle
attaching cables............. 81
disconnecting cables........... 82
File:ltixm.ex
Update:Tue Jun 20 16:42:52 1995

216 Index
K
Keys
positions of the ignition......... 9
removing from the ignition....... 10
stuck in lock position.......... 10
L
Lamps
bulb replacement specifications chart . . 156
daytime running light system...... 34
flashing the lamps............ 36
hazard flashers............. 38
headlamps............... 33
high beams............... 36
trailer................. 75
Lane change indicator (see Turn signal) . . . 35
Lights, warning and indicator
brake................. 23
charging system............. 26
check engine.............. 24
high beam............... 29
overdrive off.............. 49
safety belt............... 24
Load limits, trailer towing.......62±63
Lubricant specifications......... 165
Lug nuts, tightening sequence....... 87
M
Maintenance schedule and record..... 173
Maintenance (see Servicing)....... 109
Master cylinder, brakes......... 141
Mileage, calculating fuel economy..... 117
Motorcraft parts............. 164
File:ltixm.ex
Update:Tue Jun 20 16:42:52 1995

220 Index
V
Variable interval wipers.......... 37
VECI (Vehicle Emission Control Information)
decal................. 160
Vehicle Identification Number (VIN).... 5
Vehicle loading.............. 63
Vehicle storage............. 168
Voltmeter (see Battery voltage gauge).... 27
W
Warm engine, starting........... 13
Warning lights (see Lights)......... 21
Warranty Information Booklet....... 4
Wheel and tire matching......... 136
Wheel bearings lubricant specifications . . 165
Wheels, inspection and maintenance.... 129
Windshield washer fluid and wipers
operation................ 37
specifications............. 165
variable interval wipers......... 37
Wrecker towing.............. 89
File:ltixm.ex
Update:Tue Jun 20 16:42:52 1995