1996 FORD F SERIES MOTORHOME AND COMMERCIAL CHASSIS checking oil

28
*
[LG07500( ALL)05/94]
Engine Oil Pressure Gauge
*
[LG07601( ALL)06/93]
This gauge indicates the engine's oil pressure,
not the oil level. However, if your engine's oil
level is low, it could affect the oil pressure. With
the engine running, the pointer should move
into the NORMAL band. If the pointer drops
below the NORMAL band while the engine is
running, you have lost oil pressure and
continued operation will cause severe engine
damage.
*
[LG07701( ALL)03/95]
If you lose engine oil pressure:
*
[LG07801( ALL)01/95]
1. Pull off the road as soon as safely possible.
*
[LG07901( ALL)04/95]
2. Shut off the engine immediately or severe
engine damage could result.
*
[LG08001( ALL)02/95]
3. Check the engine's oil level, following the
instructions on checking and adding engine
oil. Refer toEngine oilin the Index. If you
do not follow these instructions, you or
others could be injured. To assure an
accurate reading, your vehicle should be on
level ground.
*
[LG08051( ALL)03/93]
4. If the level is low, add only as much oil as
necessary before you start the engine again.
Do not overfill. Do not operate the engine if
the pointer is below the NORMAL band,
regardless of the oil level. Contact your
nearest dealer for further service actions.
[LG08250( E M)03/93]
quarter page art:0020059-D
Engine oil pressure gauge
File:ltlgm.ex
Update:Tue Jun 20 16:47:10 1995

120
*
[SV13775( ALL)01/95]
Checking and Adding Engine Oil
*
[SV13800( ALL)03/95]
Since the proper amount of engine oil is
important for safe engine operation, check the oil
using the dipstick each time you put fuel in
your vehicle. Remember the engine must be off,
the oil must be warm and the vehicle must be
parked on level ground.
%*
[SV13900( ALL)03/95]
Checking the engine oil level:
*
[SV14000( ALL)02/95]
1. Turn the engine off after it has warmed up
and allow a few minutes for the engine oil
to drain back into the oil pan.
*
[SV14075( E M)03/95]
2. Set the parking brake, making sure the
gearshift is securely latched in P (Park).
*
[SV14100( ALL)02/95]
3. Open the hood. Protect yourself from engine
heat.
*
[SV14200( ALL)03/95]
4. Locate the engine oil dipstick (highlighted in
yellow) and carefully pull it out of the
engine.
*
[SV14300( ALL)01/95]
5. Wipe the dipstick clean and put it back into
position, making sure it is fully seated.
*
[SV14400( ALL)06/95]
quarter page art:0010364-D
Engine oil dipstick
File:ltsvm.ex
Update:Tue Jun 20 16:44:35 1995

122
*
[SV16625( ALL)06/95]
NOTE: Idling the engine for extended periods
will accumulate more hours of use on
your vehicles than is actually indicated
by the mileage odometer.
Consequently, the odometer reading
can be often misleading when
determining the right time to change
your engine oil and filter.
*
[SV16800( ALL)06/95]
Refer to theMaintenance Schedule and Record
booklet for additional information.
%*
[SV17250( ALL)04/95]
NOTE: Always dispose of used automotive
fluids in a responsible manner. Follow
your community's standards for
disposing of these types of fluids. Call
your local recycling center to find out
about recycling automotive fluids.
*
[SV17275( ALL)06/95]
RWARNING
Continuous contact with USED motor oil
has caused cancer in laboratory mice.
*
[SV17280( ALL)05/95]
Protect your skin by washing with soap and
water.
*
[SV17300( ALL)03/95]
Engine Coolant
*
[SV17400( ALL)02/95]
Checking the engine coolant
*
[SV17700( ALL)10/89]
Your vehicle's engine coolant protects the engine
from overheating in the summer and from
freezing in the winter. Check the level of the
engine coolant at least once a month, but
preferably each time you stop for fuel. Simply
look at the engine coolant recovery reservoir
located in the engine compartment. To locate
this reservoir, see the diagram of your vehicle's
engine underEngine typesin this chapter.
File:ltsvm.ex
Update:Tue Jun 20 16:44:35 1995

Index 209
Index
A
Accessory position on the ignition..... 10
Additives, engine oil.......... 119
Air cleaner filter, specifications...... 164
Alcohol, in fuel............. 114
Antifreeze (see Engine coolant)...... 122
Appeals (see Dispute settlement board) . . . 95
Assistance (see Customer assistance) . . 91±92
Automatic transmission, fluid, refill capacities 164
Automatic transmission
driving an automatic overdrive..... 47
fluid, adding............. 140
fluid, checking............ 139
fluid, refill capacities......... 164
fluid, specification.......... 165
Axle
lubricant specifications........ 165
refill capacities............ 164
B
Backing up................ 50
Basic vehicle warranty........... 4
Battery
acid, treating emergencies...... 79,137
charging system warning light...... 26
disconnecting.............. 82
how to service............ 136
jumping a disabled battery....... 79
maintenance-free........... 136
proper disposal, recycling....... 137
replacement, specifications....... 164
voltage gauge............. 27
when storing your vehicle....... 169
File:ltixm.ex
Update:Tue Jun 20 16:42:52 1995

Index 211
Charging system warning light....... 26
Circuit breakers,
checking and replacing........ 155
Cold engine starting............ 13
Controls
instrument panel............ 33
steering column............ 35
Coolant (see Engine coolant)
checking and adding......... 122
drain and flush............ 127
preparing for storage......... 169
proper solution............ 125
refill capacities............ 128
specifications............. 126
temperature gauge........... 30
Crankcase emission filter......... 164
Customer Assistance Center,
Ford (U.S.)............... 94
Customer Assistance Centre,
Ford of Canada............. 94
D
Dashboard (see Instrument panel)..... 33
Daytime running light system....... 34
Defects, reporting............. 99
Dipstick
automatic transmission fluid....138, 140
engine oil.............. 120
power steering fluid......... 143
Disabled vehicle (see Towing)....... 89
Dispute Settlement Board......... 95
Driveline universal joint and slip yoke . . 141
Driving under special conditions
bad weather.............. 60
high speed............... 59
high water............... 60
slippery roads............. 60
tips for safe driving........... 59
towing a trailer............. 62
File:ltixm.ex
Update:Tue Jun 20 16:42:52 1995

Index 213
Engine knocking............ 113
Engine oil
changing oil and oil filter....... 121
checking and adding......... 120
dipstick............... 120
disposal...........122, 126, 140
engine oil pressure gauge........ 28
filter, specifications.......... 164
refill capacities............ 164
specifications............. 119
synthetic oil............. 119
ªbreak-inº oils............. 7
Exhaust fumes.............. 18
Extended Service Plan, Ford........ 4
F
Federal Highway Administration
Regulation............... 7
Flashers, hazard.............. 38
Flashing the lights............. 36
Flat tire................. 83
Fluid refill capacities.......... 164
Ford Customer Assistance Center...... 94
Ford Dispute Settlement Board....... 95
Ford Extended Service Plan........ 4
Ford Motor Company of Canada..... 101
Ford of Canada Customer
Assistance Centre........... 101
Foreign registration........... 100
Four-Wheel Drive vehicles, special notice . . 5
French owner guides, how to obtain.... 3
Fuel
calculating fuel economy....... 117
capacity............... 164
choosing the right fuel........ 112
filling your vehicle with fuel...... 111
filter, specifications.......... 164
fuel gauge............... 29
improving fuel economy....... 118
octane rating............. 112
File:ltixm.ex
Update:Tue Jun 20 16:42:52 1995

214 Index
Fuel (continued)
quality................ 113
running out of fuel.......... 117
safety information relating to
automotive fuels.......... 115
storing your vehicle.......... 169
treating emergencies.......... 115
Fuel cap
removing............... 111
replacing.............111, 117
Fuel filter, specifications......... 164
Fuel gauge................ 29
Fuel pump shut-off switch, starting after
a collision............... 16
Fuse panel, instrument panel....... 148
Fuse panels, power distribution box.... 150
Fuses
checking and replacing........ 153
circuit breakers............ 155
G
Gas cap (see Fuel cap).......... 111
Gas mileage (see Fuel economy) . . . 112, 117
Gasoline (see Fuel)............ 111
Gauges, Mechanical
battery voltage gauge.......... 27
charging system gauge......... 27
engine coolant temperature gauge.... 30
engine oil pressure gauge........ 28
fuel gauge............... 29
speedometer.............. 31
GAWR (Gross Axle Weight Rating)
calculating............... 67
definition................ 65
Gearshift
automatic operation........... 48
locking the gearshift........... 9
positions................ 48
shifting the gears............ 48
shift-lock.............. 14,49
File:ltixm.ex
Update:Tue Jun 20 16:42:52 1995

Index 217
N
National Highway Traffic Safety
Administration............. 99
New vehicle break-in........... 7
O
Octane rating.............. 112
Odometer................ 32
Oil filter................ 164
Oil (see Engine oil)........... 119
On-board diagnostic (OBD II) system . . . 162
Overdrive................ 50
P
Parking brake
operation............... 57
warning light.............. 23
Parts (see Motorcraft Parts)....... 164
PCV valve, specifications........ 164
Power distribution box (see Fuses).... 150
Power steering
dipstick............... 143
driving with power steering....... 53
fluid, checking and adding...... 143
fluid, refill capacity.......... 164
fluid, specifications.......... 144
servicing................ 53
R
Rear axle
lubricant specification......... 165
refill capacity............. 164
Refill capacities for fluids........ 164
Reporting safety defects.......... 99
Roadside assistance............ 92
Roadside emergencies........... 79
Rotating the tires............ 131
File:ltixm.ex
Update:Tue Jun 20 16:42:52 1995