1996 FORD CONTOUR warning

Servicing Your Contour
235
% [SV33101(ALL)01/95]
Fuses, Circuit Breakers and Relays
[SV33200(ALL)05/94]
Fuses, circuit breakers, and relays protect your vehicle's
electrical system from overloading. If electrical parts in your
vehicle are not working, the system may have been overloaded
and blown a fuse or relay, or tripped a circuit breaker. Before
you replace or repair any electrical parts, check the appropriate
circuit protector.
[SV33400(ALL)05/94]
The following charts tell you which circuit protector protects
each electrical part of your vehicle. If a fuse blows or a circuit
breaker opens a circuit, all the parts of your vehicle that use the
circuit will not work.
*
[SV33410(ALL)06/95]
Once you have determined which fuses or circuit breakers to
check, follow the procedures underChecking and replacing fuses
orChecking and replacing circuit breakerslater in this chapter.
*
[SV33500(ALL)05/95]
RWARNING
Always remove the key from the ignition before working
on or replacing fuses.
[SV33600(ALL)01/95]
The Power Distribution Box Fuses and Relays
[SV33710(ALL)02/94]
10-1/2 pica
art:0001227-A
The power distribution box location
File:cdsvo.ex
Update:Thu Jan 25 12:09:28 1996

Servicing Your Contour
243
[SV36000(ALL)05/94]
7-1/2 pica art:0001319-A
The side view of a typical fuse
[SV36200(ALL)04/94]
eight pica
chart:0001255-B*
[SV36300(ALL)05/95]
RWARNING
Always replace a fuse with one that has the specified
amperage rating. Using a fuse with a higher amperage
rating can cause severe wire damage and could start a
fire.
%*
[SV36700(ALL)03/95]
Circuit Breakers
[SV36900(ALL)02/94]
If you need to check a circuit breaker that is on the instrument
panel fuse panel, seeChecking and replacing fusesto find out how
to locate the fuse panel and pull it down.
*
[SV37000(ALL)02/95]
Diagnostic equipment is needed to check circuit breakers. Refer
to the manufacturer's instructions.
[SV37100(ALL)02/95]
Circuit breakers will reset themselves and allow the electrical
parts to work again once the overload on the circuit is gone. If
File:cdsvo.ex
Update:Thu Jan 25 12:09:28 1996

Servicing Your Contour
245
*
[SV38800(ALL)03/95]
Headlamp Bulb
[SV38900(ALL)05/94]
The headlamps on your vehicle use replaceable bulbs, one for
high beam and one for low beam on each side. When the lamp
burns out, simply replace the bulb, rather than the whole lamp.
*
[SV39000(ALL)05/95]
RWARNING
Handle a halogen headlamp bulb carefully and keep out
of children's reach. Grasp the bulb only by its plastic
base and do not touch the glass. The oil from your hand
could cause the bulb to break the next time the
headlamps are operated.
*
[SV39100(ALL)01/95]
Do not remove the burned-out bulb unless you can immediately
replace it with a new one. If a bulb is removed for an extended
period of time, contaminants may enter the headlamp housing
and affect its performance.
*
[SV39300(ALL)03/95]
Removing the headlamp bulb
*
[SV39400(ALL)05/95]1.
Make sure that the headlamp knob is in the OFF position.
*
[SV39500(ALL)02/95]2.
Lift the hood and find the bulb in the headlamp socket.
[SV39850(ALL)04/94]3.
Remove the bulb assembly by turning it clockwise and
pulling it out of the headlamp socket.
[SV40050(ALL)04/94]4.
Remove the L-shaped bulb by pressing the retaining clip at
the base of the electrical connector and sliding the bulb out.
*
[SV40300(ALL)03/95]
Installing the headlamp bulb
[SV40450(ALL)04/94]1.
Without touching the glass on the bulb, insert the new bulb.
You may want to protect the bulb by holding it with a piece
of cloth or paper towel. Make sure the retaining clip at the
base of the electrical connector locks.
[SV40550(ALL)04/94]2.
Insert the bulb assembly in the headlamp socket. Turn it
counterclockwise to lock it in place.
File:cdsvo.ex
Update:Thu Jan 25 12:09:28 1996

248
*
[SV41000(ALL)03/95]
Emission Control System
*
[SV41100(ALL)05/95]
Your vehicle is equipped with a catalytic converter which
enables your vehicle to comply with applicable exhaust emission
requirements.
*
[SV41200(ALL)05/95]
RWARNING
Exhaust leaks may result in the entry of harmful and
potentially lethal fumes into the passenger compartment.
Under extreme conditions excessive exhaust temperatures
could damage the fuel system, the interior floor covering,
or other vehicle components, possibly causing a fire.
*
[SV41300(ALL)05/95]
To make sure that the catalytic converter and the other emission
control parts continue to work properly:
*
[SV41400(ALL)01/95]
n
Use only unleaded fuel.
*
[SV41500(ALL)01/95]
n
Avoid running out of fuel.
*
[SV41600(ALL)01/95]
n
Do not turn off the ignition while your vehicle is moving,
especially at high speeds.
*
[SV41700(ALL)03/95]
n
Have the services listed in theMaintenance Schedule and
Recordbooklet performed according to the specified schedule.
The scheduled maintenance services are required because
they are considered essential to the life and performance of
your vehicle and to its emissions system.
*
[SV41720(ALL)05/95]
Ford strongly recommends the use of genuine Ford replacement
parts. If other than Ford or Motorcraft parts or Ford authorized
remanufactured parts are used for maintenance replacements or
for the service of components affecting emission control, such
non-Ford parts should be equivalent to genuine Ford Motor
Company parts in performance and durability. It is the owner's
responsibility to determine the equivalency of such parts. Please
consult your warranty booklet for complete warranty
information.
File:cdsvo.ex
Update:Thu Jan 25 12:09:28 1996

Servicing Your Contour
249
*
[SV41800(ALL)05/95]
RWARNING
Do not park, idle, or drive your vehicle in dry grass or
other dry ground cover. The emission system heats up
the engine compartment and exhaust system, which can
start a fire.
*
[SV41900(ALL)05/95]
Watch for fluid leaks, strange odors, smoke, loss of oil pressure,
the charge warning light, the check engine light, or the
temperature warning light. These sometimes indicate that the
emission system is not working properly.
*
[SV42000(ALL)01/95]
Do not make any unauthorized changes to your vehicle or
engine. Changes that cause more unburned fuel to reach the
exhaust system can increase the temperature of the engine or
exhaust system.
*
[SV42100(ALL)01/95]
By law, anyone who manufactures, repairs, services, sells, leases,
trades vehicles, or supervises a fleet of vehicles is not permitted
to intentionally remove an emission control device or prevent it
from working. In some of the United States and in Canada,
vehicle owners may be liable if their emission control device is
removed or is prevented from working.
*
[SV42300(ALL)01/95]
Do not drive your vehicle if it does not operate properly. See
your dealer if the engine runs on for more than five seconds
after you shut it off or if it misfires, surges, stalls, or backfires.
%*
[SV42400(ALL)05/95]
Information about your vehicle's emission control system is on
the Vehicle Emission Control Information decal located on or
near the engine. This decal identifies engine displacement and
gives some tune-up specifications.
File:cdsvo.ex
Update:Thu Jan 25 12:09:28 1996

261
[QI00500(ALL)05/95]
33-1/2 pica
art:0001473-A
Warning label locations
File:cdqio.ex
Update:Thu Jan 25 12:27:36 1996

275
Brake-shift interlock.................. 140
Break-in period..................... 4
Brights (high beams)................. 59,84
Bulbs, replacing
halogen...................... 245
headlamps..................... 245
high-mount brakelamp................ 246
C
Canada, customer assistance.............. 186
Canada, warranty information.............. 3
Canadian Motor Vehicle Arbitration Plan (CAMVAP) . . . 187
Capacities for refilling fluids.............. 252
Carbon monoxide in exhaust............... 51
Car seats for children (see Child safety seats)....... 26
Cassette tape player (see Electronic sound system).... 134
Catalytic converter................... 248
Chains, tires...................... 228
Changing a tire.................... 168
Charging system warning light.............. 58
Childproof locks..................... 93
Child safety restraints
child safety belts................... 38
child safety seats................... 26
Child safety seats
and air bags................... 18,26
attaching with tether straps.............. 37
automatic locking mode (retractor)........... 26
in front seat..................... 29
in rear outboard seat................. 29
tether anchorage hardware............... 37
Chime
headlamps on..................... 60
key in ignition.................... 43
safety belt...................... 56
File:cdixo.ex
Update:Thu Jan 25 12:10:47 1996

278 Electronic stereo cassette radio
(see Electronic sound system).......... 130
Electronic stereo radio (see Electronic sound system) . . . 130
Emergencies, roadside
assistance..................... 179
battery acid spills.................. 163
jump-starting.................... 163
towing....................... 175
Emergency brake (parking brake)............ 152
Emission control system
catalytic converter.................. 248
emissions warranty................ 3,248
Engine
check engine warning light.............. 61
does not start..................... 47
fuel injected engine, starting............ 43,45
fuel pump shut-off switch............... 50
preparing to start................... 44
refill capacities................... 252
service points.................... 199
starting....................... 45
starting after a collision................ 50
storing your vehicle................. 256
Engine block heater................... 49
Engine coolant
checking and adding................ 213
disposal...................... 216
low coolant warning light............... 67
preparing for storage................ 256
recovery reservoir................199, 214
refill capacities................... 252
specifications.................... 254
temperature gauge.................. 64
File:cdixo.ex
Update:Thu Jan 25 12:10:47 1996