1996 FORD BRONCO brakes

233
*
[DR38925( ALL)01/95]
Servicing your vehicle if you tow
*
[DR38950( ALL)08/93]
If you tow a trailer for a long distance, your
vehicle will need to be serviced more frequently
than usual. Refer to theMaintenance Schedule and
Recordbooklet for additional information.
*
[DR39000( ALL)01/93]
Trailer towing tips
*
[DR39100( ALL)11/89]
Before starting on a trip, practice turning,
stopping and backing in an area away from
heavy traffic. Get to know the ªfeelº of the
vehicle/trailer combination.
*
[DR39200( ALL)05/90]
Practice backing up. Back up very slowly, with
someone outside at the rear of your trailer to
guide you. Place your hand at the bottom of the
steering wheel and move it in the direction you
want the rear of the trailer to swing. Slight
movement of the steering wheel results in a
much larger movement of the rear of the trailer.
*
[DR39300( ALL)11/89]
Allow more room for stopping with a trailer
attached. Trailer brakes should be applied first,
whether manually or automatically controlled,
when approaching a stop.
*
[DR39400( ALL)11/89]
For a good handling truck-trailer combination,
the trailer tongue load should be approximately
10-15% of the loaded trailer weight.
*
[DR39500( ALL)05/95]
Make a thorough check of your equipment
before starting out on the road. After you have
traveled about 50 miles (80 km) stop in a
protected area and double-check your hitch and
electrical connections. Also check trailer wheel
lug nuts for tightness.
File:ltdrb.ex
Update:Fri Jun 9 15:26:57 1995

234
*
[DR39600( ALL)11/89]
When turning, drive slightly beyond the normal
turning point so the trailer wheels will clear
curbs or other obstructions.
*
[DR39725(B F )03/95]
When stopped in traffic for long periods of time
in hot weather, place the gearshift selector lever
in P (Park) to increase the engine idle speed.
This aids in engine cooling and air conditioner
efficiency. If the engine overheats, move the
function selector knob to VENT to stop the
compressor and increase the engine speed for a
short time.
*
[DR39900( ALL)05/90]
Vehicles with trailers should not be parked on a
grade. However, if you must park on a grade,
place wheel chocks under the trailer's wheels as
follows:
*
[DR40000( ALL)11/89]
q
Apply the foot service brakes and hold.
*
[DR40100( ALL)11/89]
q
Have another person place the wheel chocks
under the trailer wheels.
*
[DR40200( ALL)11/89]
q
With the chocks in place, release the foot
service brakes, making sure the chocks are
holding.
*
[DR40300(B F )03/91]
q
For automatic transmissions Ð apply the
parking brake by pressing the service brake
pedal down firmly with your right foot while
applying the parking brake pedal with your
left foot.
*
[DR40400(B F )08/94]
For manual transmissions Ð apply the
service brake and shift into N (NEUTRAL)
while still maintaining pressure on the service
brake pedal. Set the parking brake fully.
File:ltdrb.ex
Update:Fri Jun 9 15:26:57 1995

235
*
[DR40500(B F )12/91]
q
Shift an automatic transmission into Park (P).
Put the gearshift of a manual transmission in
Reverse. If your vehicle is equipped with
four-wheel drive make sure the transfer case
is not in Neutral.
*
[DR40600( ALL)01/93]
To start, after being parked on a grade:
*
[DR40700( ALL)11/89]
q
Apply the foot service brakes and hold
*
[DR40800( ALL)11/89]
q
Start the engine
*
[DR40900( ALL)11/89]
q
Shift transmission into gear and release the
parking brake
*
[DR41000( ALL)11/89]
q
Release the foot service brakes and move the
vehicle uphill to free the wheel chocks
*
[DR41100( ALL)11/89]
q
Apply the foot service brakes and hold while
another person retrieves the chocks.
*
[DR41260(B F )02/92]
Snowplowing
*
[DR41275(B )01/93]
RWARNING
Do not use this vehicle for snowplowing.
File:ltdrb.ex
Update:Fri Jun 9 15:26:57 1995

319
*
[SV36600( ALL)02/95]
If the fluid is low, carefully clean and remove
the filler cap from the reservoir. Fill the
reservoir to the MAX line with Ford High
Performance DOT 3 Brake Fluid C6AZ-19542-AA
or DOT 3 equivalent fluid meeting Ford
specification ESA-M6C25-A.
*
[SV36850( ALL)12/91]
NOTE: If brake fluid is spilled on painted
surfaces, it must be flushed and wiped
away immediately. Brake fluid may
dissolve the paint finish on your
vehicle.
*
[SV36900( ALL)01/95]
RWARNING
If you use a brake fluid that is not DOT
3, you will cause permanent damage to
your brakes.
*
[SV37000( ALL)01/95]
Do not fill the reservoir above the MAX line.
*
[SV37100( ALL)01/95]
If you find that the fluid level is excessively low
Ð below the seam or ridge on the outside of the
plastic reservoir Ð have the brake system
inspected.
*
[SV37200( ALL)01/95]
RWARNING
Do not let the reservoir for the master
cylinder run dry. This may cause the
brakes to fail.
*
[SV37400(BEF )01/89]
quarter page art:0020381-A
Brake master cylinder
File:ltsvb.ex
Update:Tue Jun 20 16:56:22 1995

352 %
*
[SV57350( ALL)01/95]
Engine
*
[SV57400( ALL)01/95]
q
Start engine every 15 days. Run at fast idle
until it reaches normal operating temperature.
*
[SV57500( ALL)01/95]
q
With your foot on the brake, shift through all
the gears while the engine is running.
%*
[SV57600( ALL)01/95]
Fuel system
*
[SV57700( ALL)07/94]
q
Fill fuel tank with high-quality unleaded fuel
until the first automatic shutoff of the fuel
pump nozzle.
*
[SV57900( ALL)03/95]
NOTE: During extended periods of vehicle
storage (60 days or more), fuel may
deteriorate due to oxidation. This can
damage rubber and other polymers in
the fuel system and may also clog
small orifices.
*
[SV58000( ALL)01/95]
Ford Gas Stabilizer should be added whenever
actual or expected storage periods exceed 60
days. Follow the instructions on the label. The
vehicle should then be operated at idle speed to
circulate the additive throughout the fuel system.
*
[SV58100( ALL)01/95]
A volatile corrosion inhibitor added to the fuel
system will protect the fuel system's inner
surfaces from corrosion. Follow the instructions
packaged with the product.
%*
[SV58200( ALL)01/95]
Cooling system
*
[SV58300( ALL)01/95]
q
Protect against freezing temperatures.
%*
[SV58400( ALL)01/95]
Battery
*
[SV58500( ALL)01/95]
q
Check and recharge as necessary.
*
[SV58600( ALL)01/95]
q
Keep connections clean and covered with a
light coat of grease.
%*
[SV58700( ALL)01/95]
Brakes
*
[SV58800( ALL)01/95]
q
Make sure brakes and parking brake are fully
released.
File:ltsvb.ex
Update:Tue Jun 20 16:56:22 1995

364 Index
Automatic transmission (continued)
fluid, checking............ 314
fluid, specification........... 347
Axle
lubricant specifications......... 347
traction lok............212, 305
B
Backing up............... 178
Basic vehicle warranty........... 4
Battery
acid, treating emergencies.....237, 312
battery saver............. 125
charging system warning light...... 81
how to service............ 311
jumping a disabled battery....... 237
maintenance-free........... 311
proper disposal, recycling....... 312
replacement, specifications....... 346
voltage gauge.............. 82
when storing your vehicle....... 352
Brake fluid
brake warning light........... 76
specifications............. 319
Brakelamp, high-mount brakelamp . . 101, 336
Brakes
adjustment.............. 203
anti-lock............... 204
anti-lock brake system (ABS)
warning light............. 77
applying the brakes.......... 207
brake warning light........... 76
fluid, checking and adding....... 318
fluid, refill capacities......... 344
fluid, specifications.......... 319
front disc............... 203
if brakes do not grip well....... 206
new brake linings............ 7
parking............... 208
stopping distances........... 207
File:ltixb.ex
Update:Fri Jun 9 15:21:14 1995

Index 365
Brakes (continued)
trailer................ 231
when storing your vehicle....... 352
Brake-shift interlock.......... 66,178
Break-in period.............. 7
Bulbs, replacing
headlamps.............. 334
high-mount brakelamp........ 336
C
Canada, customer assistance....... 264
Canadian Motor Vehicle Arbitration Plan
(CAMVAP).............. 265
Capacities for refilling fluids....... 344
Carbon monoxide in exhaust........ 71
Car seats for children
(see Child safety seats)......... 37
Cassette tape player (see Electronic
sound system)..........163, 168
Catalytic converter........... 339
CD player (see Electronic sound system) . 156
Chains, tires.............. 310
Changing a tire............. 241
Charging system gauge.......... 82
Charging system warning light....... 81
Child safety restraints........... 34
child safety belts............ 36
child safety seats............ 37
Child safety seats, attaching with
tether straps.............. 57
Chime
headlamps on............. 84
key in ignition............. 61
safety belt............... 78
Circuit breakers, checking and replacing. . 332
Cleaning your vehicle
CD player and discs......... 160
chrome and aluminum parts....... 9
engine compartment......... 281
exterior................ 8
File:ltixb.ex
Update:Fri Jun 9 15:21:14 1995

Index 373
L
Lamps
cargo lamps............. 100
checking............... 333
combination cargo and brakelamp . . . 101
courtesy lamps............ 100
daytime running light system...... 99
dome lamps............. 100
flashing the lamps.......... 107
hazard flashers............ 109
headlamps............... 98
high beams............. 106
high-mount brakelamp........ 336
interior lamps............ 100
map lamps.............. 102
replacing bulbs............ 333
trailer................ 231
Lane change indicator (see Turn signal) . . 105
Lap belts................. 19
Lights, warning and indicator
airbag................. 81
anti-lock brakes (ABS).......... 77
brake................. 76
charging system............ 81
check engine.............. 78
four-wheel drive.........191, 197
high beam............... 84
overdrive off............. 177
rear ABS................ 77
safety belt............... 78
testing the warning lights........ 64
Load limits
GAWR................ 214
GVWR................ 214
trailer towing............. 216
Locking hubs
lever operated with automatic..... 191
lever operated with manual...... 194
Lubricant specifications......... 347
File:ltixb.ex
Update:Fri Jun 9 15:21:14 1995