1996 FORD AEROSTAR belt

206 [DR29510(ALL)08/95]
RWARNING
Do not allow people to ride in any area of
the vehicle that is not equipped with seats
and safety belts.
[DR29520(ALL)08/95]
RWARNING
Be sure everyone in your vehicle is in a
seat and using a safety belt properly.
*
[DR29525(ALL)07/95]
RWARNING
Cargo should always be secured to
prevent it from shifting and causing
damage to the vehicle or harm to
passengers.
*
[DR29551(ALL)03/91]
Each additional item of equipment affects how
much cargo a vehicle can carry. If a vehicle is
overloaded, performance will suffer and service
concerns may arise.
File:10cpdra.ex
Update:Tue Aug 29 17:45:28 1995

243
*
[RE24375(ALL)03/95]
If the Engine Cranks But Does
Not Start or Does Not Start After
a Collision
*
[RE24400(ALL)07/95]
The Fuel Pump Shut-off Switch
*
[RE24500(ALL)07/95]
If the engine cranks but does not start or if you
have had a collision, the fuel pump shut-off
switch may have been triggered. The shut-off
switch is a device that stops the fuel pump
when your vehicle has been involved in a
substantial jolt.
*
[RE24600(ALL)07/95]
For information on how to check and reset the
fuel pump shut-off switch, seeFuel pump shut-off
switchin the Index.
%
*
[RE24700(ALL)05/95]
Towing Your Vehicle
[RE24750(ALL)08/95]
The recommended method to tow your Aerostar
is with flatbed or wheel lift equipment.
However, slingbelt towing is acceptable. On
vehicles equipped with an under-vehicle spare
tire carrier, remove the tire assembly from the
carrier and store it in a secure area before
towing. For E-4WD vehicles, the 4-wheel drive
system must be disabled prior to towing. The
transmission must be in N (Neutral) and the
ignition switch must be in the OFF position to
disable the Electronic 4-Wheel Drive System.
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995

299 %
*
[SV27300(ALL)04/95]
Replacing the Tires
*
[SV27400(ALL)05/95]
Replace any tires that show wear bands. When
your tire shows a wear band, it has only 1/16
inch (2 mm) of tread left.
*
[SV27500(ALL)10/89]
quarter page art:0060006-A
Wear band
*
[SV27600(ALL)01/95]
Because your vehicle's tires may wear unevenly,
you may need to replace them before a wear
band appears across the entire tread. Some spots
wear more heavily than others.
*
[SV27700(ALL)03/90]
Your wheels and tires are match-mounted for
improved ride. Before you begin to repair a tire,
mark the wheel and tire so that they are
properly aligned when remounted. This will
ensure that the tires will continue to give you
the same ride level.
*
[SV27851(ALL)01/95]
RWARNING
When replacing full size tires, never mix
radial, bias-belted, or bias-type tires. Use
only the tire sizes that are listed on the
tire pressure decal. Make sure that all tires
are the same size, speed rating, and
load-carrying capacity. Use only the tire
combinations recommended on the decal.
If you do not follow these precautions,
your vehicle may not drive properly and
safely.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

Index 359
Index
A
Accessory position on the ignition..... 61
Additives, engine oil.......... 282
Air bag supplemental restraint system . . . 26
and child safety seats.......... 34
description............. 26,28
disposal................ 32
driver air bag........... 26,28
indicator light............. 81
operation............... 28
proper seating............. 27
service and information labels...... 28
tone generator............. 31
wearing safety belts........... 27
Air cleaner filter
location............... 269
specifications............. 337
Air conditioning
auxiliary heater and air conditioner . . . 98
manual heating and air conditioning
system............... 92
Alcohol, in fuel............. 277
Antenna, radio
(see Electronic sound system) . . . 149, 182
Antifreeze (see Engine coolant)...... 284
Anti-lock brake system (ABS)
description.............. 193
see also Brake............ 193
Appeals (see Dispute settlement board) . . 248
Assistance (see Customer assistance) . . . 245
Audio system
(see Electronic sound system)..... 149
Autolamp system (see Headlamps) . . 102, 104
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995

362 Index
Changing a tire............. 229
Charging system gauge.......... 82
Charging system warning light....... 81
Child safety restraints........... 32
built-in child seat............ 48
child safety belts............ 58
child safety seats............ 34
Child safety seats............. 34
attaching with tether straps....... 46
automatic locking mode (retractor) . . 15, 34
built-in child seat............ 48
in front seat.............. 34
in rear outboard seat.......... 34
in rear seat............... 34
tether anchorage hardware........ 46
Chime
headlamps on.............. 84
key in ignition............. 62
safety belt............... 77
Circuit breakers
checking and replacing........ 322
see also fuses............. 313
Cleaning your vehicle
built-in child seat............ 57
CD player and discs.......... 160
chrome and aluminum parts....... 9
engine compartment.......... 272
exterior................ 8
exterior lamps............ 102
fabric................ 142
headlamps.............. 102
instrument panel............ 91
instrument panel lens......... 108
interior lamps............. 105
mirrors................ 144
plastic parts.............. 9
polishing................ 8
rear windows............. 100
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995

Index 363
Cleaning your vehicle (continued)
rustproofing.............. 9
safety belts............... 23
tail lamps.............. 102
upholstery and interior trim...... 142
washing................ 8
waxing................ 8
wheels................ 303
windows............... 100
Climate control system.......... 91
air conditioning............ 92
heating only system........... 95
Clock...............155, 171
Clutch, specifications.......... 338
Cold engine starting............ 65
Combination lap and shoulder belts . . 11, 13
Compact disc player
(see Electronic sound system)..... 156
Compact disc radio
(see Electronic sound system)..... 150
Console, description........... 145
Controls
instrument panel............ 89
mirrors............... 144
steering column........... 109
Coolant (see Engine coolant)....... 284
checking and adding......... 284
drain and flush............ 289
preparing for storage......... 344
proper solution............ 286
refill capacities..........289, 335
specifications............. 338
temperature gauge........... 85
warnings............... 284
Cruise control (see Speed control).... 115
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995

Index 371
Lamps (continued)
interior lamps............ 101
replacing bulbs............ 322
trailer................ 219
Lane change indicator (see Turn signal) . . 109
Lap belts................. 20
Lights, warning and indicator
airbag................. 81
brake................. 75
charging system............ 81
check engine.............. 78
door ajar................ 77
engine oil pressure........... 83
hazard warning light......... 113
high beam............... 84
oil pressure.............. 83
safety belt............... 77
service engine soon........... 78
turn signal indicator......... 109
Load limits............... 202
GAWR................ 202
GVWR................ 202
trailer towing............. 205
Lubricant specifications......... 338
Luggage rack.............. 223
Lug nuts................ 237
standard............... 239
tightening sequence.......... 241
Lumbar support, seats.......... 142
Lumbar support pad.......... 142
M
Maintenance schedule and record
(see separate Maintenance Schedule
and Record booklet).......... 3
Maintenance (see Servicing)....... 265
Master cylinder, brakes......... 309
Methanol in fuel............ 277
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995

Index 373
Power steering
dipstick............... 311
driving with power steering...... 191
fluid, checking and adding...... 311
fluid, specifications.......... 338
servicing............... 191
Prop rod, hood............. 268
R
Radio (see Electronic sound systems) . . . 149
Rear anti-lock brakes.......... 194
Rear axle
lubricant specification......... 338
refill capacity............. 335
traction lok............201, 297
Rear climate control system........ 98
Rear window
defroster................ 99
washer reservoir........... 291
Refill capacities for fluids........ 335
Regulations, National Highway Traffic
Safety Administration......... 252
Reporting safety defects......... 252
Restraints, safety (see Safety restraints)
adult................. 11
child.................. 32
infant............... 32,34
Roadside assistance........... 245
Roadside emergencies.......... 225
Rotating the tires............ 297
S
Safe driving tips............ 198
Safety belts (see Safety restraints)...... 11
Safety chains, when towing a trailer . . . 219
Safety Compliance Certification Label.... 5
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995