1996 CHEVROLET TRACKER fuel cap

Capacities (Approximate)
The following approximate capacities are given in
English and metric conversions.
label under the hood and “Air Conditioning
Refrigerants” at the end of this section.
Air Conditioning?
... See the refrigerant information
Please refer to “Fluids and Lubricants” in the Index
for more information.
Automatic Transmission Drain and Refill
...... . 3.0 quarts (2.8 L)**
Overhaul
Two-Door Convertible
...... 5.4 quarts (5.1 L)
Four-Door Hardtop
........ 7.3 quarts (6.9 L)
Automatic Transmission ....... 5.5 quarts (5.2 L)
Manual Transmission
....... 5.6 quarts (5.3 L)
With Filter Change ........ 4.5 quarts (4.2 L)*
Front Differential ............ 1.1 quarts (1.0 L)
Fuel Tank
Two-Door Convertible
....... 11.1 gallons (42 L)
Four-Door Hardtop ......... 14.5 gallons (55 L)
Cooling System
Crankcase Manual Transmission
Four-wheel Drive
........ 1.6 quarts (1.5 L)**
Two-Wheel Drive .......... 2.0 quarts (1.9 L)**
Rear Differential ............. 2.3 quarts (2.2 L)
Transfer Case ............... 1.8 quarts (1.7 L)
* When changing the oil filter, additional oil may be
needed. Recheck the oil level after filling. See “Engine
Oil” in the Index.
** Recheck fluid level after filling. See “Automatic
Transmission Fluid” or “Manual Transmission Fluid” in
the Index.
Wheel Nuts
Wheel Nut Torque ............. 60 lb-ft (80 N-m)
6-63
ProCarManuals.com

Maintenance Schedule
I Short Trip/City Intervals I
Every 50,000 Miles (83 000 km): Automatic
Transmission Service (severe conditions only). Positive Crankcase Ventilation (PCV) Valve Replacement.
Every 60,000 Miles (100 000 km): Engine Timing
and Distributor Check. Fuel Tank Cap Gasket
Replacement. Emission System Hoses Inspection. Camshaft Timing Belt Replacement. Brake Fluid
Service. Spark Plug Wire Replacement (or every
60 months, whichever occurs first). Wiring Harness
and Connectors Inspection (or every 60 months,
whichever occurs
first).
Short Trip/City Intervals
At 90,000 Miles (150 000 km): Camshaft Timing
Every 100,000 Miles (166 000 km): Fuel Injector
Belt Inspection.
Inspection. Evaporative Emissions Canister
Replacement.
These intervals only summarize maintenance services.
Be sure to
follow the complete maintenance schedule
on the following pages.
7-5
ProCarManuals.com

Maintenance Schedule
Lo'ng Trip/Highway Definition I
Follow this maintenance schedule only if none of the
conditions from the
Short TripjCity Maintenance
Schedule
is true.
Driving a vehicle with a fully warmed engine under
highway conditions causes engine oil to break
down slower.
Long Trip/Highway Intervals
Every 7,500 Miles (12 500 km): Engine Oil and Filter
Change (or every
7.5 months, whichever occurs first).
Free-Wheeling Hubs Inspection
(if equipped)
(or every 3 months, whichever occurs first).
Tire Rotation.
Every 15,000 Miles (25 000 km): Engine Idle Speed
Check. Valve Lash (Clearance) Adjustment. Propeller
Shafts
and U-Joints Inspection (or every 15 months,
whichever occurs first).
Every 30,000 Miles (50 000 km): Engine Accessory
Drive Belt Inspection
(or every 24 months, whichever
occurs first). Cooling System Service (or every
30 months, whichever occurs first). Spark Plug
Replacement. Air Cleaner Filter Replacement.
Fuel
Tank, Cap and Lines Inspection. Manual
Transmission Fluid Change
(or every 30 months,
whichever occurs first). Fuel
Filter Replacement
(or every
30 months, whichever occurs first).
7-6
ProCarManuals.com

Maintenance Schedule
.I
Long TriplHighway Intervals Long Trip/Highway Intervals
Every 50,000 Miles (83 000 km): Automatic
Transmission Service (severe conditions only).
Positive Crankcase Ventilation
(PCV)
Valve Replacement.
Every 60,000 Miles (100 000 km): Engine Timing
and Distributor Check. Fuel Tank Cap Gasket
Replacement. Emission System Hoses Inspection.
Camshaft Timing Belt Replacement. Spark
Plug Wire
Replacement (or every 60 months, whichever occurs
first). Wiring Harness and Connectors Inspection
(or every 60 months, whichever occurs first). Brake
Fluid Service.
At 90,000 Miles (150 000 km): Camshaft Timing
Belt Inspection.
Every 100,000 Miles (166 000 km): Fuel Injector
Inspection. Evaporative Emissions Canister
Replacement.
These intervals only summarize maintenance services.
Be
sure to follow the complete maintenance schedule
on the following pages.
r
7-7
ProCarManuals.com

I Short Trip/City Maintenance Schedule I
30,000 Miles (50 000 km) (Continued)
17 Replace spark plugs.
An Emission Control Service.
17 Replace air cleaner filter.
An Emission Control Service.
El Inspect fuel tank, cap and lines for damage or
leaks. Inspect fuel cap gasket for
any damage.
Replace parts as needed.
An Emission Control Service.
Rotate tires. See “Tire Inspection and Rotation”
in the Index for proper rotation pattern and
additional information. During tire rotation,
check brake calipers for fieedom
of movement.
Refer to the appropriate GM service manual for
proper caliper service procedures.
Change manual transmission fluid (or every
15 months, whichever occurs first).
0 Inspect the valve lash and adjust if necessary.
An Emission Control Service.
0 Replace fuel filter (or every 30 months,
whichever occurs first, or sooner
if filter is
clogged). An Emission Control Service.
0 Check engine idle speed and adjust it
to underhood label specifications.
An Emission Control Service.?
17 Inspect the locking front hubs (if equipped)
for correct operation (or every 3 months,
whichever occurs first). Repair
or replace
as necessary.
0 Inspect propeller shafts and u-joints for
looseness and damage
(or every 15 months,
whichever occurs first). Inspect more
frequently
if used off-road or for pulling
a trailer, Tighten u-joint flange bolts
if necessary.
I DATE I ACTUAL MILEAGE ISERVICED BY1
7-14
ProCarManuals.com

Short TriplCity Maintenance Schedule L
Replace spark plug wires (or every
60 months, whichever occurs first).
An Emission Control Service.
0 Inspect the underhood wiring harness
for loose connections, chafed wires and
damage
(or every 60 months, whichever
occurs first).
An Emission Control Service.
0 Drain, refill and bleed the brake system.
Replace the camshaft timing belt.
An Emission Control Service.
0 Replace air cleaner filter.
An Emission Control Service.
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service.?
0 Rotate tires. See “Tire Inspection and Rotation”
in the Index for proper rotation pattern and
additional information. During tire rotation,
check brake calipers for fieedom of movement.
Refer to the appropriate
GM service manual for
proper caliper service procedures.
whichever occurs first).
An Emission Control Service. ?
Change manual transmission fluid (or every
‘15 months, whichever occurs first).
0 Inspect the valve lash and adjust if necessary.
An Emission Control Service.
Check engine idle speed and adjust it
to underhood label specifications.
An Emission Control Service.?
0 Inspect the locking front hubs (if equipped)
for correct operation (or every 3 months,
whichever occurs first). Repair or replace
as necessary.
0 Replace fuel filter (or every 30 months,
(Continued)
7-21
ProCarManuals.com

I Short Trip/City Maintenance Schedule I
90,000 Miles (150 000 km) (Continued)
0 Drain, flush and refill cooling system (or
every 30 months, whichever occurs first).
See “Engine Coolant” in the Index for
what to use. Inspect
hoses. Clean radiator,
condenser, pressure cap and neck. Pressure
test the cooling system and pressure cap.
An Emission Control Service.
0 Replace spark plugs.
An Emission Control Service.
0 Replace air cleaner filter.
An Emission Control Service.
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for
any
damage. Replace parts as needed.
An Emission Control Service.
otate tires. See “Tire Inspection and Rotatio
in the Index for proper rotation pattern and
additional information.
During tire rotation,
check brake calipers for heedom of movement.
Refer to the appropriate
GM service manual for
proper caliper service procedures.
15 months, whichever occurs first).
An Emission Control Service.
whichever occurs first).
An Emission Control Service.
0 Check engine idle speed and adjust it
to underhood label specifications.
An Emission Control Service.?
0 Inspect the locking front hubs (if equipped)
for correct operation (or every 3 months,
whichever occurs first). Repair or replace
as necessary.
0 Change manual transmission fluid (or every
0 Inspect the valve lash and adjust if necessary.
0 Replace fuel filter (or every 30 months,
7-28
ProCarManuals.com

I Long TriplHighway Maintenance Schedule I
Q Drain, flush and refill cooling system (or
every
30 months, whichever occurs first).
See “Engine Coolant” in the Index for
what to use. Inspect hoses. Clean radiator,
condenser, pressure cap and neck. Pressure
test the cooling system and pressure cap.
An Emission Control Service. 7
0 Replace spark plugs.
An Emission Control Service.
Replace air cleaner filter.
An Emission Control Service.
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service.
0 Change manual transmission fluid (or every
30 months, whxhever occurs first).
I7 Replace fuel filter (or every 30 months,
whichever occurs first, or sooner
if filter is
clogged).
An Emission Control Service.
17 Inspect the locking front hubs (if equipped)
for correct operation (or every
3 months,
whichever occurs first). Repair or replace
if necessary.
0 Inspect the valve lash and adjust if
necessary.
An Emission Control Service.
(Continued)
7-35
ProCarManuals.com