1996 CHEVROLET TAHOE air suspension

Downloaded from www.Manualslib.com manuals search engine After Off-Road Driving
Remove any brush or debris that has collected on the
underbody, chassis or under the hood. These
accumulations can be a fire hazard.
After operation in mud or sand, have the brake linings
cleaned and checked. These substances can cause
glazing and uneven braking. Check the body structure,
steering, suspension, wheels, tires and exhaust system
for damage. Also, check the fuel lines and cooling
system for any leakage.
Your vehicle will require more frequent service due to
off-road use. Refer to the Maintenance Schedule for
additional information.
Driving at Night
Night driving is more dangerous than day driving. One
reason is that some drivers are likely to be impaired
-- by
alcohol or drugs, with night vision problems, or by fatigue.

Downloaded from www.Manualslib.com manuals search engine I Short Trip/City Maintenance Schedule -- Gasoline Engines
The services shown in this schedule up to 100,000 miles
( 166 000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals.
Footnotes
The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that
the failure to perform this maintenance item will
not
nullify the emission warranty or limit recall liability
prior to the completion
of the vehicle's useful life.
We, however, urge that all recommended
maintenance services
be performed at the indicated
intervals and the maintenance be recorded.
# Lubricate the front suspension, kingpin bushings,
steering linkage, transmission shift linkage, transfer
case shift linkage, parking brake cable guides, front
axle propshaft splines and brake pedal springs. Ball
joints and kingpin bushings should not be lubricated
unless their temperature
is 10°F (-12"C), or higher,
or they could be damaged.
** Drive axle service:
0 Locking Differential -- Drain fluid and refill at first
engine oil change. At subsequent oil changes, check
fluid level and add fluid as needed. If driving in
dusty areas or towing a trailer, drain fluid and refill
every
15,000 miles (25 000 km).
Standard Differential -- Clieck fluid level and add
fluid as needed at every oil change. If driving in
dusty areas or towing a trailer, drain fluid and refill
every
15,000 miles (25 000 km).
0 More frequent lubrication may be required for
heavy-duty or off-road use.
7-6

Downloaded from www.Manualslib.com manuals search engine The services shown in this schedule up to 100,000 miles
(166 00.0 km) should be performed after 100,000 miles
(166 000 km) at the same intervals.
Footnotes
-f The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that
the failure to perform this maintenance item will not
nullify the emission warranty or limit recall liability
prior to the completion of the vehicle's useful life.
We, however, urge that all recommended
maintenance services be performed at the indicated
intervals and the maintenance be recorded.
# Lubricate the front suspension, kingpin bushings,
steering linkage, transmission shift linkage, transfer
case shift linkage, parking brake cable guides, front
axle propshaft splines and brake pedal springs. Ball
joints and kingpin bushings should not be lubricated
unless their temperature is
10°F (-12"C), or higher,
or they could be damaged.
** Drive axle service:
0
0
0
Locking Differential -- Drain fluid and refill at first
engine
oil change. At subsequent oil changes, check
fluid level and add fluid as needed. If driving in
dusty areas or towing a trailer, drain fluid and refill
every
15,000 miles (25 000 km).
Standard Differential -- Check fluid level and add
fluid as needed at every engine oil change. If driving
in dusty areas or towing a trailer, drain
fluid and
refill every
15,000 miles (25 '000 km).
More frequent lubrication may be required for
heavy-duty or off-road use.
7-29

Downloaded from www.Manualslib.com manuals search engine Part C: Periodic Maintenanc,e
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall). You should let your GM dealer’s
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a GM Service Manual. See “Service and Owner
Publications” in the Index.
Steering and Suspension Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs
of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which could
cause a heat build-up in the floor pan or could let
exhaust fumes into the vehicle. See “Engine Exhaust” in
the Index.
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed,
Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding,
and for damage
or missing parts. Replace parts as
needed. Replace any cables that have high effort or
excessive wear.
Do not lubricate accelerator and cruise
control cables.
7-46

Downloaded from www.Manualslib.com manuals search engine Glove Box .................................... 2-42
Gross Axle Weight Rating
........................ 4-42
Gross Vehicle Weight Rating
..................... 4-41
Guide en Frangais
11 .. .................................
. GVWR ....................................... 4-41
Halogen Bulbs
................................ 6-35
Hazard Warning Flashers
.......................... 5- 1
Headlamps .................................... 2-35
Bulb Replacement
....................... 6.36. 6.37
HighLow Beam Changer
...................... 2-30
On Reminder
................................. 2-36
Wiring
...................................... 6-61
. Head Restraints ................................. 1-5
Hearing Impaired. Customer AssistAnce
.............. 8-3
Heating
........................................ 3-7
High-Beam Headlamps
.......................... 2-30
Highway Hypnosis
.............................. 4-35
Hill and Mountain Roads
.... i .................... 4-35
Hitches. Trailer
................................. 4-, 48
Hood Checking Things Under
......................... 6-6
Release
....................................... 6-7
Horn
......................................... 2-28
Hydroplaning
.................................. 4-3 1
Ignition Positions .............................. I. . 2-10
Illuminated Entry
................................ 2-38
Inflation, Tire
.................................. 6-44
Inside Rearview Mirror
.......................... 2-39
Inspections
........ ........................... 7-46
Brakesystem
................................ 7-47
~~ ~~~~ ~ ~ .
Exhaust System ......................... : .... 7-46
Radiator and Heater Hose
.' ..................... 7-46
RearAxle
................................... 7-47
Steering
.................................... 7-46
Suspension
.................................. 7.46 .
Throttle Linkage .............................. 7-46
Transfer Case (Four-wheel Drive)
................ 7-47
Instrumerit Panel
............................... 2-54
Brightness Control
............................. 2-38
Cleaning
...................................... 6-54
Cluster
..................................... 2-56
FuseBlock
.................................. 6-63
Interior Lamps
................................. 2-38
Jack, Tire
............................... 5-22, 5-23
Jump Starting
................................... 5-2
Key Lock Cylinders Service
....... (. ............. 7-43
Keyless Entry System ............................ 2-4
Keys
........................................... 2-1
Labels Certificationnire
.............................. 4-41
Service Parts Identification
..................... 6-60
Tire-Loading Information
........ : ............. 4-41
Vehicle Identification Number
.. : ................ 6-60
Lamps
........................................ 2-35
Dome
...................................... 2-38
Interior
..................................... 2-38
On Reminder
................................ 2-36
UnderhoodReel
.............................. 2-37
9-5