1996 CHEVROLET MONTE CARLO heater

Downloaded from www.Manualslib.com manuals search engine 3. After the engine cools, open the coolant air bleed valve. 3.4L V6 (VIN Code X):
There are two bleed valves.
'hey
are located on the
thermostat housing and
heater inlet pipe. The lermostat housing
i location is shown here.
I
3.1L V6 (VIN Code M): There are two bleed valves.
One is located on the thermostat housing. The other is
located on the thermostat bypass tube.
5-19

Downloaded from www.Manualslib.com manuals search engine NOTICE:
When adding coolant it is important that you use
DEX-COOL
TM (orange-colored, silicate-free)
coolant meeting
GM Specification 6277M.
If silicated coolant is added to the system,
premature engine, heater core or radiator
corrosion may result. In addition, the engine
coolant will require change sooner
-- at
30,000 miles (50 000 km) or 24 months
whichever occurs first.
What to
Use
Use a mixture of one-half clean water (preferably
distilled) and one-half
DEX-COOL TM (orange-colored,
silicate-free) antifreeze that meets
GM Specification
6277M, which won’t damage aluminum parts. Use
GM Engine Coolant Supplement (sealer) (GM Part
No. 3634621) with any complete coolant change. If you
use this mixture, you don’t need to add anything else.
Adding only plain water to your cooling system
can be dangerous. Plain water, or some other
liquid like alcohol, can boil before the proper
coolant mix will. Your vehicle’s coolant warning
system is set for the proper coolant mix. With
plain water or the wrong mix, your engine could
get too hot but you wouldn’t get the overheat
warning. Your engine could catch fire and you or
others could be burned.
Use a 50/50 mix of clean
water and DEX-COOL
TM (orange-colored,
silicate-free) antifreeze.

Downloaded from www.Manualslib.com manuals search engine NOTICE:
If you use an improper coolant mix, your
engine could overheat and be badly damaged.
The repair cost wouldn’t be covered by your
warranty.
Too much water in the mix can freeze
and crack the engine, radiator, heater core and
other parts.
If you have to add coolant more than four times a year,
have your dealer check your cooling system.
I NOTICE:
If you use the proper coolant, you don’t have to
add extra inhibitors or additives which claim to
improve the system. These can be harmful.
Checking Coolant
r-
When your engine is cold, the coolant level should be at
the
COLD mark or a little higher. When .your engine is
warm,
the level should be up to the HOT mark or a
little higher.
6-21

Downloaded from www.Manualslib.com manuals search engine Replacement Bulbs
Exterior Lamps Bulb Number
Back-up ............................... 3057
Center High-vounted Stop
............... 89 1 T2
Front Parking/Turn Signal ............... 3357NA
Headlamp. High-Beam
................... 9005
Headlamp. Low-Beam .................... 9006
License Plate ............................ 168
Sidemarker. Front
......................... 194
Sidemarker. Rear
......................... 194
Stop/Tail/Turn Signal
..................... 3057
Interior Lamps Bulb Number
Ashtray ................................. 194
Center Instrument Cluster
............. 16 1 or 194
Console Shift Indicator
............ ‘-4 . .,-. 73
Dome
.................................. 561
Door Lock Switch
......................... 73
GloveBox .............................. 194
Heater and Air Conditioning Control
. . T- 1.75, T- 1.5
High-Beam Indicator ...................... 161
Luggage Compartment
.................... 920
Inside Rearview Mirror Reading
............. 192
Side Window Switch
....................... 73
6-60

Downloaded from www.Manualslib.com manuals search engine Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should be
performed at least twice
a year (for instance, each spring
and fall). You should let your
GM dealer’s service
department or other qualified service center do these jobs.
Make sure any necessary repairs are completed at once.
Proper procedures to perform these services may be
found
in a Chevrolet service manual. See “Service and
Owner Publications”
in the Index.
Steering, Suspension and Front-Wheel-Drive
Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear, or lack of lubrication. Inspect the power steering
lines and hoses for proper hookup, binding, leaks,
cracks, chafing, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system.
Look for broken, damaged,
missing or out-of-position parts
as well as open seams, holes, loose connections,
or other conditions which
could cause
a heat build-up in the floor pan or could let
exhaust fumes into the vehicle. See “Engine Exhaust’’ in
the Index.
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes,
fittings and clamps; replace
as needed.
Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding,
and for damage or missing parts. Replace parts
as
needed. Replace any cables that have high effort or
excessive wear.
Do not lubricate accelerator and cruise
control cables.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hookup, binding, leaks, cracks, chafing,
etc. Inspect disc brake pads for wear and rotors for
surface condition. Also inspect drum brake linings for
wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc.
Check parking brake adjustment. You may need to have
your brakes inspected more often if your driving habits
or conditions result
in frequent braking.

Downloaded from www.Manualslib.com manuals search engine Console Storage ................................ 2-35
Control of a Vehicle
.............................. 4-5
Convenience Net
............................... 2-35
Convex Outside Mirror
.......................... 2-34
Coolant
....................................... 6-19
Bleedvalves ................................. 5-19
Heater. Engine ............................... 2- 12
Recovery Tank
............................... 5-16
Cooling System
................................ 5- I4
Courtesy Lamps
................................ 2-3 1
Courtesy Transportation ........................... 8-6
Cruise Control
................................. 2-27
Cupholders
.................................... 2-34
Customer Assistance for Text Telephone Users
......... 8-3
Customer Assistance Information ................... 8- I
Customer Satisfaction Procedure .................... 8- 1
Damage. Finish ............................... 6-50
Damage. Sheet Metal
............................ 6-50
Daytime Running Lamps
......................... 2-30
Dead Battery
................................... 5-2
Defects. Reporting Safety
......................... 8-8
Defensive Driving ............................... 4- 1
Defogger. Rear Window .......................... 3-4
Defrosting
..................................... 3-4
Dimensions. Vehicle
............................ 6-63
Dolby' B Noise Reduction
.................. 3-13. 3- 17
Storage Compartment
......................... 2-35
DoorLocks
..................................... 2-3
Drive Position. Automatic Transaxle
................ 2- 15
Driver Position ................................. 1 - 1 1
Driving Defogging
..................................... 3-4
City
........................................ 4-17 Defensive
.................................... 4-1
Drunken
..................................... 4-2
Freeway
.................................... 4-18
In a Blizzard
................................. 4-24
In Foreign Countries
........................... 6-3
In the Rain .................................. 4-15
Night
...................................... 4-13
OnCurves
................................... 4-8
On Grades While Towing a Trailer ............... 4-33
On Hill and Mountain Roads
.................... 4-21
On Snow and Ice ............................. 4-23
Through Water
............................... 4-17
WetRoads
.................................. 4-15
Winter
...................................... 4-22
With a Trailer
................................ 4-32
Drunken Driving
................................ 4-2
Electrical Equipment. Adding
.......... 2- I I. 3-2 1. 6-52
Electrical System
............................... 6-52
Electronic Climate Control
........................ 3-1
Engine 6-7.
6-8
Coolant
..................................... 6-19
Coolant Heater ............................... 2-12
Coolant Level Check .......................... 7-36
Coolant Temperature Gage
..................... 2-47
Coolant Temperature Light
..................... 2-46
Exhaust
..................................... 2-21
Identification
................................ 6-52
OilLevelCheck
.............................. 7-36
Overheating
................................. 5-12
Running While Parked ......................... 2-22
Specifications ................................ 6-62
Starting Your
................................ 2-11

Downloaded from www.Manualslib.com manuals search engine Ignition Switch ................................ 2-10
Illumination. Sustained Interior .................... 2-32
Inflation. Tire
.................................. 6-37
Inside Daymight Rearview Mirror
................. 2-33
Brakesystem
................................ 7-40
Exhaust Systems
............................. 7-40
Front-Wheel-Drive Axle Boot
.................. 7-40
Front-Wheel-Drive Axle Seal
.................... 7-40
Radiator and Heater Hose
...................... 7-40
Suspension
.................................. 7-40
Throttle Linkage
.............................. 7-40
Instrument Panel
............................... 2-38
Brightness Control
............................. 2-31
Cleaning .................................... 6-47
FuseBlock
.................................. 6-53
Interior Lamps 2-3
1
Inspections .................................... 7-40
Steering
.................................... 7-40
Cluster
..................................... 2-40
.................................
.................................... J ack. Tire 5-22
Jump Starting 5-2
...................................
Key Lock Cylinders Service ..................... 7-37
Key Reminder Warning
.......................... 2- 10
Keys ........................................... 2-1 Lamps
........................................ 2-30
Courtesy
.................................... 2-31
Interior 2-31 OnReminder
................................ 2-30
Latches, Seatback 1-5
Leaving Your Vehicle
............................. 2-3
Leaving Your Vehicle with
the Engine Running ....... 2-19
Lighter 2-36
Lights Air Bag Readiness
....................... 1-18, 2-43
Anti-Lock Brake System Active
............. 2-46, 4-8
Anti-Lock Brake System Warning
............ 2-45, 4-6
Charging System
............................. 2-43
.....................................
................................
.......................................
Brake System Warning ........... 1 ............. 2-44
Engine Coolant Temperature
.................... 2-46 - lnterior .............
Low Coolant Warning .
Low Oil Level Warning
Oil Warning
.........
Safety Belt Reminder . .
Security ............
Service Engine Soon . .
Loading Your Vehicle ... ..
........................ 2-31 ~-
........................ 2-47
........................ 2-51
........................ 2-50
.................... 1-7, 2-42
........................ 2-52
........................ 2-48
........................ 4-26
Locks
......................................... 2-3
Cylinders
................................... 7-37 -
Labels 4-26
Certification 4-27
Service Parts Identification
..................... 6-52
Tire-Loading Information
...................... 4-26
Vehicle Identification Number
................... 6-52
.......................................
.................................
9-5
..
1
Door ....................
Key Lock Cylinder Service .
Power Door .............
Steering Column Lock Check
Trunk
..................
Low Coolaat Warning Light . .
Low Oil Level Warning Light .
Lubricants and Fluids ........
Lubrication Service. Body ....
..................... 2-3
....................... 7.
...................... 2-3
................... 7-39
..................... 2-6
.................... 2-47
..................... 2-51
.................... 7-41
.................... 7-37