1996 CHEVROLET CORVETTE wheel

Downloaded from www.Manualslib.com manuals search engine Grades B and A represent higher levels of performance
on the laboratory test wheel than the minimum required
by law.
Warning: The temperature grade for
this tire is
established for a tire that
is properly inflated and not
. overloaded. Excessive speed, underinflation, or
excessive loading, either separately
or in combination,
can cause heat buildup and possible tire failure.
Wheel Alignment and Tire Balance
The wheels on your vehicle were aligned and balanced
carefully at the factory to give you the longest tire life
and best overall performance.
In most cases, you will not need to have your wheels
aligned again. However, if you notice unusual tire wear
or your vehicle pulling one way or the other, the
alignment may need to be reset. If you notice your
vehicle vibrating when driving on a smooth road, your
wheels may need to be rebalanced.
Wheel Replacement
Replace any wheel that is bent, cracked, or badly rusted
or corroded. If wheel nuts keep coming loose, the wheel,
wheel bolts and wheel nuts should be replaced. If the
wheel leaks air, replace it (except some aluminum
wheels, which can sometimes be repaired). See your
Corvette dealer if any of these conditions exist.
Your dealer will know the kind of wheel you need.
,Each new wheel should have the same load-carrying
capacity, diameter, width, offset and be mounted the
same way as the one it replaces.
If you need to replace any of your wheels, wheel bolts
or wheel nuts, replace them only with new
GM original
equipment parts.
This way, you will be sure to have the
right wheel, wheel bolts and wheel nuts for your
Corvette model.
6-52

Downloaded from www.Manualslib.com manuals search engine Used Replacement Wheels
L
Using the wrong replacement wheels, wheel bolts
or wheel nuts on your vehicle can be dangerous.
It could affect the braking and handling
of your
vehicle, make your tires lose
air and make you
lose control. You could have a collision in which
you or others could be injured. Always use the
correct wheel, wheel bolts and wheel nuts for
replacement.
NOTICE:
The wrong wheel can also cause problems with
bearing life, brake cooling, speedometer/odometer
calibration, headlamp
aim, bumper height, vehicle
ground clearance
and tire clearance to the body
and chassis.
See “Changing a Flat Tire” in the Index for more
information.
r
Putting a used wheel on your vehicle is
dangerous. You can’t know how it’s been used or
how many miles
it’s been driven. It could fail
suddenly and cause an accident.
If you have to
replace a wheel, use
a new GM original
equipment wheel.
rire Chains
NOTICE:
Don’t use tire chains. They can damage your
vehicle.
6-53

Downloaded from www.Manualslib.com manuals search engine Cleaning and Storage of Your
Hardtop
The optional hardtop has the same durable finish as the
painted surfaces of your Corvette. You can wash, polish
and wax it.
If you store the hardtop for a long time, keep it covered
in a dry place. Apply silicone grease to all the
weatherstrips.
Aluminum Wheels
Your aluminum wheels have a protective coating similar
to the painted surface of your vehicle. Don’t use strong
soaps, chemicals, chrome polish, abrasive cleaners or
abrasive cleaning brushes on them because you could
damage this coating. After rinsing thoroughly, a wax
may be applied.
NOTICE:
,
Don’t use an automatic car wash that has hard
silicon carbide cleaning brushes. These brushes
can take the protective coating
off your
aluminum wheels.
Tires
To clean your tires, use a stiff brush with a tire cleaner.
NOTICE:
When applying a tire dressing always take care to
wipe
off any overspray or splash from all painted
surfaces on the body
or wheels of the vehicle.
Petroleum-based products may damage the paint
finish.
Finish Damage
Any stone chips, fractures or deep scratches in the finish
should be repaired right away.
Minor chips and scratches can be repaired with touch-up
materials available from your dealer or other service
outlets. Larger areas
of finish damage can be corrected
in your dealer’s body and paint shop.
6-60

Downloaded from www.Manualslib.com manuals search engine Replacement Parts
Air Cleaner Filter ..................................................... A 1097C
GM Part
No. 25096933 or equivalent
Battery
.............................................................. 75B-72
Coolant High Fill Reservoir Cap
........................................... RC27
15 psi (105 kPa)
GM Part
No. 6410782 or equivalent
Crankcase Ventilation Valve
........................................... CV895C
Engine Oil Filter
....................................................... PF52
GM Part
No. 25010908 or equivalent
Flat Ratchet Wrench (Convertible Hardtop
Only) ...... GM Part No. 101 37741 or equivalent
PCV Valve
.................................................. AC Type CV895C
Serpentine Belt
................................ GM Part No. 10230259 or equivalent
Spark Plug
............................................ .4 1-943 (0.050 inch Gap)
GM Part
No. 5614244 or equivalent
Thermostat
................................... GM Part No. 10223370 or equivalent
Tom@ Wrench
................................ GM Part No. 1017231 1 or equivalent
Windshield Wiper Blade Length
...................... .......................... 20 inches (508 mm)
Type ................................................. 0.'25 inch (6.35 mm) pin
Wheel Nuts
Wheel Nut Torque .......... ......... ................... 100 lb-ft (140 N-m)
6-75

Downloaded from www.Manualslib.com manuals search engine Vehicle Dimensions
Wheelbase ........................................
Tread Front/Re
..............................................
Coupe and Convertible ..................................
GrandSpo .............................................
96.2 inches (2 444 mm)
57.7 inches (1 466 mm)
59.1 inches (1 500 mm)
60.6 inches (1 539 mm)
Length ............................................... 178.5 inches (4 535 mm)
Coupe ............................................... 70.7 inches (1 796 mm)
Convertible ........................................... 73.1 inches (1 856 mm)
Coupe ............................................... 46.3 inches (1 177 mm)
Convertible ........................................... 47.3 inches (1 202 mm)
Width
Height

Downloaded from www.Manualslib.com manuals search engine Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall). You should let your GM dealer’s
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a Corvette service manual. See “Service and
Owner Publications” in the Index.
.
Steering and Suspension Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing
parts, signs of
wear, or lack
of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc.
Tire and Wheel Inspection
Inspect the tires for uneven wear or damage. If there is
irregular or premature wear, check the wheel alignment.
Inspect for damaged wheels.
7-44

Downloaded from www.Manualslib.com manuals search engine Accessory Plug ............................... 2-52
AirBag
....................................... 1-17
How Does it Restrain
.......................... 1-2 1
Howitworks
................................ 1-19
Location
.................................... 1-19
Servicing
.................................... 1-22
What Makes it Inflate
.......................... 1-20
What Will You See After it Inflates
............... 1-21
When Should it Inflate
......................... 1-20
Air Bag Readiness Light
.................... 1 - 18. 2-76
Air Bag System
................................ 1 - 17
Aircleaner
.................................... 6-15
Air Conditioning
........................ 3.2.3.3. 3.7
Alarm. Theft-Deterrent
.......................... 2- 13
Alignment and Balance. Tire
...................... 6-52
Aluminum Wheels. Cleaning
...................... 6-60
Antenna. Power
................................ 3-20
Antifreeze
..................................... 6-25
Anti-Lock Brake System Active Light
.......... 2-80. 4-8
Anti-Lock Brake System Warning Light
......... 2-79. 4-6
Anti-Lock Brakes
............................... 4-6
Appearance Care
............................... 6-54 Appearance Care
Materials
....................... 6-62
Arbitration Program
.............................. 8-7
ASR Active Light
........................... 2-8 1. 4.8
ASR Off Light
................................. 2-81
ASR System
.................................... 4-8
ASR System Warning Light ................... 2.80. 4.8
Audio Equipment. Adding
........................ 3-18
Audio Systems
................................. 3-10
Electronic Climate Control System ................ 3-4
Overdrive
................................... 2-23
Transmission
........................... 2- 18. 2-2 1
Transmission Check
........................... 7-41
Transmission Fluid
............................ 6-18
Transmission Park Mechanism Check
............. 7-43
Transmission. Fluid Temperature Reading
......... 2-97
Transmission. Operation
....................... 2-21
Transmission. Shifting
......................... 2-21
Transmission. Starting Your Engine
.............. 2-18
Axle. Limited-Slip Rear
......................... 2-28
Ashtray
....................................... 2-50
Automatic
Axle. Rear
.................................... 6-24
9-1

Downloaded from www.Manualslib.com manuals search engine Back-up Lamp Bulb Replacement ................. 6-43
Battery
....................................... 6-35
Jump Starting
................................. 5-2
Replacement, Passive Keyless Entry
............... 2-8
BBB Auto Line
.................................. 8-7
Belt, Engine Accessory
.......................... 6-79
Better Business Bureau Mediation
................... 8-7
Brake Warnings
................................ 5-2, 5-4
Adjustment
................................ 6-34
Fluid
....................................... 6-32
Master Cylinder
.............................. 6-32
Parking
..................................... 2-28
PedalTravel
................................. 6-3 4
Replacing System Parts
........................ 6-35
System Warning Light
......................... 2-78
Transmission Shift Interlock
.................... 2-3 1
Wear ....................................... 6-34
Brakes, Anti-Lock
............................... 4-6
Brake-Transmission Shift Interlock Check
........... 7-42
Braking
........................................ 4-5
Braking in Emergencies
........................... 4-9
Break-In, New Vehicle
.......................... 2- 15
BTSI
......................................... 2-31
BTSICheck
................................... 7-42
Bulb Replacement
.............................. 6-36
Bulbs, Replacement
........................... 6-73 Canadian
Roadside Assistance
.................... 8-6
Capacities and Specifications
...................... 6-74
Cassette Deck Service
........................... 7-40
Cassette Tape Player
.................. 3-1 1.3.13. 3.15
Cassette Tape Player Care
........................ 3-19
Center Console
................................. 2-48
Center High-Mounted Stoplamp Bulb Replacement
.... 6-41
Certification Label
.............................. 4-28
Chains. Tire
................................... 6-53
Changing a Flat Tire
............................. 5-22
Charging System Indicator Light
................... 2-76
Check Gauges Light
............................. 2-93
Checking Your Restraint Systems
.................. 1-31
Chemical Paint Spotting
.......................... 6-61
Child Restraints
................................ 1-26
Securing in the Passenger Seat Position
........... 1-26
TopStrap
................................... 1-26
WheretoPut
................................ l-26
Cigarette Lighter ............................... 2-50
Circuit Breakers and Fuses
....................... 6-65
Cleaner, Air
................................... 6-15
Cleaning Aluminum Wheels
.......................... 6-60
Coated Moldings
............................. 6-55
Convertible Hardtop
........................... 6-60
Convertible Top
.............................. 6-59
CarbonMonoxide
......................... 2.32. 4.27
9-2
~