1996 CHEVROLET CAMARO heater

Downloaded from www.Manualslib.com manuals search engine You can be burned if you spill coolant on hot
engine parts. Coolant contains ethylene glycol,
and
it will burn if the engine parts are hot
enough. Don’t spill coolant on a hot engine.
3. After the engine cools, open the air bleed valves on
the heater return hose and water pump inlet.
4. Fill with the proper mix. Add coolant until you see a
5. Close the bleed valves.
6. Continue to fill the radiator up to the base of the
7. Rinse or wipe the spilled coolant from the engine
and compartment.
8. Start the engine and allow it to run in idle for
approximately four minutes.
By this time, the
coolant level inside the radiator will be lower. Add
more
of the proper mix through the filler neck until
the level reaches the base of the filler neck.
steady stream
of coolant coming
from the bleed valves.
filler neck.
5-25

Downloaded from www.Manualslib.com manuals search engine What to Use
Standard Differential
Use Axle Lubricant (GM Part No. 1052271) or
SAE 80W-90 GL-5 gear lubricant.
Limited-Slip Differential
To add lubricant when the level is low, use Axle
Lubricant (GM
Part No. 12345977). To completely refill
after draining, add 2 ounces (59
ml) of Limited-Slip
Differential Lubricant Additive (GM
Part No. 1052358).
Then fill to the bottom
of the filler plug hole with Axle
Lubricant (GM Part
No. 12345977).
Engine Coolant
The cooling system in your vehicle is filled with new
DEX-COOL
TM (orange-colored, silicate-free) engine
coolant. This coolant is designed to remain in your
vehicle for
5 years or 100,000 miles (166 000 km),
whichever occurs first.
The following explains your cooling system and how to add coolant when it is low. If you have a problem with
engine overheating
or if you need to add coolant to your
radiator, see “Engine Overheating” in the Index.
A 50/50 mixture of water and the proper coolant for
your Chevrolet will:
Give freezing protection down to -34°F (-37°C).
0 Give boiling protection up to 265 “F (1 29°C).
Protect against rust and corrosion.
Help keep the proper engine temperature.
Let the warning lights and gages work as they should.
NOTICE:
When adding coolant it is important that you use
DEX-COOL (orange-colored, silicate-free)
coolant meeting
GM Specification 6277M.
If silicated coolant is added to the system,
premature engine, heater core
or radiator
corrosion may result.
In addition, the engine
coolant
will require change sooner -- at
30,000 miles (50 000 km) or 24 months,
whichever occurs first.
6-26
I b

Downloaded from www.Manualslib.com manuals search engine What to Use
Use a mixture of one-half clean water (preferably
distilled) and one-half
DEX-COOL TM (orange-colored,
silicate-free) antifreeze that meets
GM Specification
6277M, which won’t damage aluminum parts. Use
GM Engine Coolant Supplement (sealer) (GM Part
No. 3634621) with any complete coolant change. If you
use this mixture, you don’t need to add anything else.
Adding only plain water to your cooling system
can be dangerous. Plain water, or some other
liquid like alcohol, can boil before the proper
coolant mix will. Your vehicle’s coolant warning
system is set for the proper coolant mix. With
plain water or the wrong mix, your engine could
get too hot but you wouldn’t get the overheat
warning. Your engine could catch fire and you or
others could be burned. Use a
50/50 mix of clean
water and
DEX-COOL TM (orange-colored,
silicate-free) antifreeze.
1
NOTICE:
I
If you use an improper coolant mix, your
engine could overheat and be badly damaged.
The repair cost wouldn’t be covered by your
warranty.
Too much water in the mix can freeze
and crack the engine, radiator, heater core and
other parts.
If you have to add coolant more than four times a year,
have your dealer check your cooling system.
NOTICE:
If you use the proper coolant, you don’t have to
add extra inhibitors or additives which claim to
improve the system. These can be harmful.
6-27

Downloaded from www.Manualslib.com manuals search engine Replacement Bulbs
Ashtray" ................................ 194
Automatic Transmission Indicator
............. 73
Back-up ............................... 1141
Center High-Mounted Stoplamp
............. 92 1
Cluster ................................. 161
Console
................................ 194
Dome
................................ 906
Door Courtesy
............................ 74
Fog
.................................... 885
Front Parking and Turn Signal .............. 3057
GloveBox
.............................. 194
Headlamp (Low-Beam) ................. H-435 1
Headlamp (High-Beam) ................ H-4352
Heater and A/C Control
..................... 37 High-Beam Indicator
.................... 161
Indicator Lights
.......................... 161
Interior Door Handle
....................... 74
License
................................. 194
Reading
............................... 212-2
Rear
Courtesy ............................ 562
Sidemarker
............................ 194
Tail Only
............................... 194
TaiVStoplTurn
.......................... 2057
Trunk
.................................. 562
Turn Signal Indicators
..................... 161
*Manual transmission only
.
6-72

Downloaded from www.Manualslib.com manuals search engine Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall). You should let your
GM dealer’s
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a Chevrolet Service Manual. See “Service and
Owner Publications” in the Index.
Steering and Suspension Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body near
the exhaust system. Look for broken, damaged, missing or
out-of-position
parts as well as open seams, holes, loose
connections
or other conditions which could cause a heat
build-up in the floor
pan or could let exhaust fumes into
the vehicle.
See “Engine Exhaust” in the Index,
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed.
Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding, and
for damage or missing parts. Replace parts as needed.
Replace
any cables that have high effort or excessive wear.
Do not lubricate accelerator and cruise control c.ables.
Rear Axle Service
Check the gear lubricant level in the rear axle and add if
needed. See “Rear Axle” in the Index. A fluid loss may
indicate a problem. Check the axle and repair it if needed.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition. Also inspect drum brake linings
for wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc. The
parking brake is self-adjusting and no manual
adjustment is required. You may need
to have your
brakes inspected
more often if your driving habits or
conditions result in frequent braking.
7-43

Downloaded from www.Manualslib.com manuals search engine Close-OutPanel ................................ 2-58
Comfort Controls
................................ 3- 1
Compact Disc Care
....................................... 3-21
Player
.................................. 3.9. 3.15
Player Errors
........................... 3-1 1. 3. I6
Storage
..................................... 2-57
Control of a Vehicle
.............................. 4-5
Convertible Top
................................ 2-66
Convex Outside Mirror
.......................... 2-56
Coolant
....................................... 6-26
Bleedvalves
................................. 5-25
Heater. Engine
............................... 2-27
RecoveryTank
............................... 5-18
Cooling System
................................ 5- 15
Courtesy Lamps
................................ 2-53
Courtesy Transportation
........................... 8-6
Cruise Control
................................. 2-46
Customer Assistance Information
................... 8- I
Customer Satisfaction Procedure .................... 8- 1
Damage. Finish ............................... 6-63
Damage. Sheet Metal
............................ 6-63
Daytime Running Lamps
......................... 2-50
Dead Battery
................................... 5-2
Defects. Reporting Safety
......................... 8-8
Defensive Driving
............................... 4- 1
Defogger. Rear Window .......................... 3-5
Defogging
..................................... 3-4
Defrosting
..................................... 3-4
Clutch. Hydraulic
............................... 6-25
Compact Spare Tire
............................. 5-39
Customer Assistance for Text Telephone Users
......... 8-3 Delayed Illumination
............................ 2-53
Dimensions. Vehicle
............................ 6-74
Dolby@
B Noise Reduction ....................... 3-14
Door DELCO-LOC
I1 .............................. 3-17
Last Door Closed Locking Feature
................ 2-5
Lockout Prevention ............................ 2-5
Locks
....................................... 2-3
Downshifting
.................................. 2-35
Drive Position. Automatic Transmission
............. 2-30
DriverPosition
................................. 1-12
Driver’s Door Alarm DelayBhock Sensor Enable
..... 2-21
Driving
City
........................................ 4-20
Defensive
.................................... 4-1
Drunken
..................................... 4-2
Freeway
.................................... 4-21
In a Blizzard
................................. 4-27
In Foreign Countries
........................... 6-4
IntheRain
.................................. 4-17
Night
...................................... 4-15
OnCurves
.................................. 4-10
On Hill and Mountain Roads
.................... 4-23
OnSnowandIce
............................. 4-26
Throughwater
............................... 4-19
WetRoads
.................................. 4-17
Winter
...................................... 4-25
With a Trailer
................................ 4-36
DrunkenDriving
................................ 4-2
Electrical Equipment. Adding .......... 2-25. 3-20. 6-66
Electrical System
............................... 6-66
On
Grades While Towing a Trailer
............... 4-38
9-3

Downloaded from www.Manualslib.com manuals search engine Engine .................................... 6.8. 6.9
Coolant
..................................... 6-26
Coolant Heater
............................... 2-27
Coolant Level Check
.......................... 7-39
Coolant Temperature Gage
..................... 2-8 1
Exhaust ..................................... 2-41
Fuse Blocks
................................. 6-70
Identification
................................ 6-65
Oil Level Check
.............................. 7-39
Running While Parked
......................... 2-41
Starting Your
...................... 2-24.2-25. 2-26
Engineoil
.................................... 6-10
Adding ..................................... 6-12
Additives
................................... 6-15
Checking
................................... 6-11
Used
....................................... 6-15
Whentochange .............................. 6-15
Ethanol ........................................ 6-4
Overheating
................................. 5- 14
Specifications
................................ 6-73
Pressure Gage
................................ 2-85
Exhaust. Engine
................................ 2-41
Exit Lighting
............................. 2-18. 2-53
Express-Down Window
.......................... 2-42
Fabric Cleaning
............................... 6-57
Fabric Protection ............................... 6-57
Fan Control. Climate Control System ................ 3- 1
Feature Customization ........................... 2- 17
Driver’s Door Alarm Delay/Shock Sensor Enable ... 2-21
Exit Lighting/Delayed Illumination
............... 2- 18 Last Door Closed
LockingLockout Prevention
..... 2- 18
Remote Lock Control Verification
................ 2-19
Theft-Deterrent Arming Method
................. 2-20
Theft-Deterrent Arming Verification
.............. 2-20
Fifth Gear. Manual Transmission .............. 2.32. 2.33
FillingYourTank
................................ 6-5
Filter. Air ..................................... 6-17
Filter. Engine Oil
............................... 6-15
Finish Care
.................................... 6-61
Finish Damage
................................. 6-63
First Gear. Automatic Transmission
................ 2-31
First Gear. Manual Transmission
............... 2-3 1. 2-32
Flashers. Hazard Warning
......................... 5-1
Flat Tire. Changing
............................. 5-27
Floor Mats
.................................... 2-61
Fluids and Lubricants
............................ 7-44
FogLamps
.................................... 2-51
Folding Rear Seatback
............................ 1-6
Foreign Countries. Fuel
........................... 6-4
Fourth Gear. Manual Transmission ............ 2-32. 2-33
Four-Way Manual Seat
........................... 1-2
French Language Manual
........................... ii
FrontConsole .................................. 2-57
FrontTowing
.................................. 5-10
Front Turn Signal Bulb Replacement
................ 6-43
Fuel
.......................................... 6-3
Filling Your Tank
.............................. 6-5
Gage ....................................... 2-87
In Foreign Countries
........................... 6-4
Fuses and Circuit Breakers
....................... 6-67
9-4

Downloaded from www.Manualslib.com manuals search engine Gages Engine Coolant Temperature
.................... 2-8 1
Engine Oil Pressure ........................... 2-85
Fuel ....................................... 2-87
Gear Positions. Automatic Transmission
............. 2-28
Gear Positions. Manual Transmission
............... 2-3 1
GloveBox .................................... 2-57
Gross Axle Weight Rating ........................ 4-30
Gross Vehicle Weight Rating
...................... 4-30
Guide
en FranCais 11
GAWR ....................................... 4-30
.. .................................
GVWR ....................................... 4-30
Halogen Bulbs
................................ 6-37
Hatch Release
.................................. 2- 10
Hatch Release. Remote .......................... 2- 1 1
Hazard Warning Flashers .......................... 5-1
Head Restraints ................................. 1-4
Headlamps
.................................... 2-50
Aiming
..................................... 6-40
Bulb Replacement
............................ 6-37
HighLow Beam Changer
...................... 2-44
OnReminder
................................ 2-50
Wiring
..................................... 6-66
Hearing Impaired, Customer Assistance .............. 8-3
Heating
........................................ 3-3
High-Beam Headlamps
.......................... 2-44
Highway Hypnosis
.............................. 4-23
Hill and Mountain Roads
......................... 4-23
Hitches, Trailer
................................. 4-35
Hood Checking
Things Under ......................... 6-6
Release ...................................... 6- 7
Horn ......................................... 2-42
Hydraulic Clutch
............................... 6-25
Hydraulic Clutch System Check
................... 7-40
Hydroplaning
.................................. 4-19
Ignition Positions .............................. 2.22
Inflation. Tire
.................................. 6-48
Inside Daymight Rearview Mirror
................. 2-55
Inspections Brakesystem
................................ 7-43
Exhaust Systems
............................. 7-43
Radiator and Heater Hose
...................... 7-43
RearAxle
................................... 7-43
Steering
.................................... 7-43
Suspension
.................................. 7-43
Throttle Linkage
............................ 7-43
Brightness Control
............................ 2-52
Cleaning
.................................... 6-59
Cluster
..................................... 2-74
Interior Lamps
................................. 2-52
Jack. Tire .................................... 5-27
Jump Starting ................................... 5-2
Key Lock Cylinders Service
..................... 7-40
Key Release Button
............................. 2-23
Keys
.......................................... 2-1
Instrument
Panel