Page 14 of 25
20-119
Removing
- Obtain radio code for radio with anti-theft
coding.
- Switch off ignition and disconnect battery ground
(GND) cable.
- Briefly open fuel filler cap and then close it
again.
- Empty fuel tank if necessary using fuel
evacuator unit VAG1433 A.
Front wheel drive Page 20
-18
.
All wheel drive Page 20
-66
.
Note:
The fuel tank may not be filled more than
1/3.
- Remove luggage compartment liner.
- Remove cover for fuel pump flange.
WARNING!
Pa
ge 14 of 25 Fuel su
pp
ly system, servicin
g (vehicles with 2.7 ltr. turbo en
gine
)
11/19/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE04.20.4
Page 19 of 25
20-123
- Wrap wire for fuel gauge sensor around fuel
supply line (inside fuel tank) and connect to
flange.
- Seal for flange must be dry when inserted in
opening of fuel tank.
Note:
-Arrow 3- applies for vehicles with front wheel drive. - Insert flange in fuel tank.
Installation position for vehicles with all-wheel drive: -arrow 1- must be
opposite -arrow 2-.
Note:
Check that all fuel line and hose connections are securely seated.
Radio operating manual - Tighten threaded cap nut to 60 Nm with wrench 3217.
- Connect wiring and connector.
- After reconnecting the battery enter radio anti-theft code.
Pa
ge 19 of 25 Fuel su
pp
ly system, servicin
g (vehicles with 2.7 ltr. turbo en
gine
)
11/19/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE04.20.4
Page 24 of 25
20-128
Sender for fuel gauge -G, removing and
installing
Vehicles with 2.7 ltr. turbo engine
Observe all safety precautions Page 20
-1 .
Observe rules of cleanliness Page 20
-4 .
Removing
- Fuel pump flange, removing Page 20
-118
.
- Carefully lift out fuel pump flange with fuel
supply line connected and set aside.
- On the inside of the fuel pump flange disconnect
connector for fuel gauge sender.
Note: - Remove sender by pressing tab -arrows-.
The fuel accumulator housing is shown in the illustration without the
fuel tank. The illustration shows the fuel gauge sender for vehicles with front
wheel drive.
Pa
ge 24 of 25 Fuel su
pp
ly system, servicin
g (vehicles with 2.7 ltr. turbo en
gine
)
11/19/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.GE04.20.4
