1995 JEEP XJ fuel reserve

CONTENTS; INSTRUMENT PANEL AND
GAUGESÐXJ........................8E-24
CONTENTS; LAMPS...................8L-19
CONTINUITY (LEFT POSITION), POWER
MIRROR SWITCH.....................8T-3
CONTINUITY, POWER SEAT SWITCH......8R-2
CONTINUITY (RIGHT POSITION), POWER
MIRROR SWITCH.....................8T-3
CONTINUITY TESTS, IGNITION SWITCH . . . 8D-30
CONTROL AND DISPLAY SYMBOLS,
INTERNATIONAL VEHICLE.............Intro.-5
CONTROL AND DISPLAY SYMBOLS,
VEHICLE.........................Intro.-10
CONTROL CABLES, VENT DOOR.........24-32
CONTROL DIAGNOSTIC TROUBLE CODE,
SPEED..............................8H-5
CONTROL, FUEL PUMP ELECTRICAL......14-5
CONTROL (IAC) MOTOR, IDLE AIR; FUEL
SYSTEM............................14-62
CONTROL (IAC) MOTOR, IDLE AIR;
FUEL/IGNITION (XJ)................8W-30-2
CONTROL (IAC) MOTOR, IDLE AIR;
FUEL/IGNITION (YJ)................8W-30-2
CONTROL (IAC) MOTOR, IDLE AIR;
FUEL/IGNITION (XJ-RHD)............8W-30-2
CONTROL (IAC) MOTORÐPCM OUTPUT,
IDLE AIR...........................14-27
CONTROL INFORMATION (VECI) LABEL,
VEHICLE EMISSION....................25-1
CONTROL MODULE (PCM) 60-WAY
CONNECTOR, POWERTRAIN............14-40
CONTROL MODULE (PCM),
POWERTRAIN; EMISSION CONTROL
SYSTEMS...........................25-7
CONTROL MODULE (PCM),
POWERTRAIN; FUEL SYSTEM......14-20,14-64
CONTROL MODULE (PCM),
POWERTRAIN; IGNITION SYSTEMS......8D-11,
8D-23,8D-5
CONTROL MODULE, POWERTRAIN . . . 8H-1,8H-7
CONTROL MODULE (TCM) SERVICE,
TRANSMISSION.....................21-183
CONTROL MODULE, TRANSMISSION;
TRANSMISSION CONTROLS (XJ-RHD) . . 8W-31-1
CONTROL MODULEÐ4.0L ENGINE ONLY,
TRANSMISSION; TRANSMISSION
CONTROLS (XJ)...................8W-31-1
CONTROL MOTOR TEST, IDLE AIR.......14-49
CONTROL PANEL LAMP, ACCESSORY
LAMP AND HEATER; INTERIOR
LIGHTING (YJ)....................8W-44-1
CONTROL REPLACEMENT, HEATER.......24-32
CONTROL REPLACEMENT, HEATER AND
A/C................................24-23
CONTROL SERVO REMOVE/INSTALL,
SPEED..............................8H-9
CONTROL SERVO, SPEED..........8H-1,8H-6
CONTROL SWITCH REMOVE/INSTALL,
SPEED..............................8H-9
CONTROL SWITCH, SPEED.........8H-1,8H-6
CONTROL SYSTEM, EMISSION...........0-20
CONTROL SYSTEM, EVAP
(EVAPORATION)......................25-4
CONTROL SYSTEM MAINTENANCE,
EMISSION............................0-4
CONTROL THERMOSTAT, TEMPERATURE . . 24-34
CONTROL, THERMOSTATIC.............24-16
CONTROL UNIT (ECU), ELECTRONIC......5-34
CONTROL UNIT (HCU), HYDRAULIC.......5-33
CONTROL UNIT, HYDRAULIC; ANTI-LOCK
BRAKES (XJ)......................8W-32-2
CONTROL UNIT, HYDRAULIC; ANTI-LOCK
BRAKES (XJ-RHD).................8W-32-2
CONTROL UNIT, HYDRAULIC; ANTI-LOCK
BRAKES (YJ)......................8W-32-2
CONTROL VALVE FITTING O-RING SEAL,
FLOW..............................19-14
CONTROL, VEHICLE SPEED; VEHICLE
SPEED CONTROL (XJ)..............8W-33-1
CONTROL, VEHICLE SPEED; VEHICLE
SPEED CONTROL (XJ-RHD)..........8W-33-1
CONTROLÐPCM INPUT, SPEED
.........14-25
CONTROLÐPCM OUTPUT, SPEED
.......14-29
CONTROLS AND COMPONENTS,
TRANSMISSION
......................21-67
CONTROLS, EMISSION
.................25-4
CONTROLSÐPCM INPUT, AIR
CONDITIONING (A/C)
..................14-21CONTROLSÐXJ VEHICLES, AIR
CONDITIONING......................24-15
CONTROLSÐYJ VEHICLES, AIR
CONDITIONING......................24-16
CONVERSION FORMULAS AND
EQUIVALENT VALUES...............Intro.-11
CONVERSION, METRIC..............Intro.-16
CONVERSION, METRIC AND ENGLISH/
SAE .............................Intro.-11
CONVERTER, CATALYTIC............11-1,11-4
CONVERTER CLUTCH RELAY TEST,
TORQUE............................14-48
CONVERTER CLUTCH RELAY, TORQUE....14-65
CONVERTER CLUTCH RELAYÐPCM
OUTPUT, TORQUE....................14-29
CONVERTER CLUTCH (TCC) SOLENOID
AND RELAY, TORQUE; FUEL/IGNITION
(XJ).............................8W-30-4
CONVERTER CLUTCH (TCC) SOLENOID
AND RELAY, TORQUE; TRANSMISSION
CONTROLS (YJ)...................8W-31-1
CONVERTER CLUTCH (TCC) SOLENOID
AND RELAYÐ2.5L ENGINE ONLY,
TORQUE; TRANSMISSION CONTROLS
(XJ).............................8W-31-1
CONVERTER DIAGNOSIS, TORQUE . 21-86,21-87,
21-88
CONVERTER HOUSING LEAK DIAGNOSIS . . 21-75
CONVERTER INSTALLATION,
TRANSMISSION.....................21-117
CONVERTER INSTALLATION,
TRANSMISSION AND TORQUE.........21-199
CONVERTER REMOVAL, TRANSMISSION . 21-115
CONVERTER REMOVAL, TRANSMISSION
AND TORQUE......................21-198
CONVERTER STALL TEST..............21-74
CONVERTER STALL TEST, TORQUE.....21-178
CONVERTER STATOR CLUTCH
INSPECTION, TORQUE................21-199
CONVERTER, TORQUE...........21-167,21-67
CONVERTERÐPUMP SEALÐDRIVE
PLATE SERVICE.....................21-116
CONVERTOR, CATALYTIC................25-1
COOLANT............................7-20
COOLANT RESERVE/OVERFLOW SYSTEM . . 7-24
COOLANT ROUTING, SYSTEM.............7-1
COOLANT TEMPERATURE GAUGE,
ENGINE; INSTRUMENT CLUSTER (XJ) . . 8W-40-1
COOLANT TEMPERATURE SENSOR.......25-7
COOLANT TEMPERATURE SENSOR,
ENGINE; FUEL SYSTEM................14-60
COOLANT TEMPERATURE SENSOR,
ENGINE; FUEL/IGNITION (XJ).........8W-30-3
COOLANT TEMPERATURE SENSOR,
ENGINE; FUEL/IGNITION (YJ).........8W-30-3
COOLANT TEMPERATURE SENSOR,
ENGINE; IGNITION SYSTEMS.......8D-19,8D-5
COOLANT TEMPERATURE SENSOR,
ENGINE; FUEL/IGNITION (XJ-RHD).....8W-30-3
COOLANT TEMPERATURE SENSOR TEST,
ENGINE; FUEL SYSTEM................14-46
COOLANT TEMPERATURE SENSOR TEST,
ENGINE; IGNITION SYSTEMS............8D-9
COOLANT TEMPERATURE SENSORÐ
PCM INPUT, ENGINE
..................14-23
COOLANT TEMPERATURE WARNING
LAMP, ENGINE; INSTRUMENT
CLUSTER (XJ)
.....................8W-40-1
COOLANT TEMPERATURE WARNING
LAMP, ENGINE; INSTRUMENT
CLUSTER (XJ-RHD)
................8W-40-1
COOLER FLOW TESTING,
TRANSMISSION
.....................21-113
COOLER LINE AND FITTING SERVICE,
TRANSMISSION
.....................21-111
COOLER LINE FITTINGS, TRANSMISSION
. 21-197
COOLER REVERSE FLUSHING,
TRANSMISSION
.....................21-114
COOLER SERVICE, TRANSMISSION
.....21-196
COOLERS, TRANSMISSION OIL
..........7-36
COOLING FANÐXJ MODELS WITH 4.0L
6-CYLINDER ENGINE, AUXILIARY
ELECTRIC
...........................7-35
COOLING SYSTEM; COOLING SYSTEM
......7-1
COOLING SYSTEM; HEATING AND AIR
CONDITIONING
......................24-10
COOLING SYSTEM CAPACITIES
..........7-45COOLING SYSTEM CLEANING/REVERSE
FLUSHING...........................7-22
COOLING SYSTEM COMPONENTS.........7-1
COOLING SYSTEM DIAGNOSIS............7-6
COOLING SYSTEM, DRAINING...........7-21
COOLING SYSTEM, ENGINE.............0-18
COOLING SYSTEM FANS................7-32
COOLING SYSTEM FOR LEAKS, TESTING . . . 7-22
COOLING SYSTEM HOSES..............7-32
COOLING SYSTEM, REFILLING...........7-21
CORE AND HOUSING, HEATER..........24-33
CORE, HEATER......................24-26
COURTESY LAMPS AND DOME LAMP,
CARGO LAMP; INTERIOR LIGHTING
(XJ).............................8W-44-1
COURTESY LAMPS AND DOME LAMPS;
INTERIOR LIGHTING (YJ)............8W-44-1
COURTESY LAMPS, READING...........8C-1
COVER AND DISC INSTALLATION,
CLUTCH.............................6-10
COVER AND DISC REMOVAL, CLUTCH.....6-10
COVER AND DISC RUNOUT, CLUTCH.......6-3
COVER AND FRAMEÐXJ, BUCKET
SEATBACK..........................23-81
COVER, ENGINE CYLINDER HEAD....9-22,9-64
COVER, FRAME CROSSMEMBER........13-16
COVER OIL SEAL REPLACEMENT,
TIMING CASE....................9-30,9-73
COVER REPLACEMENT, PITMAN SHAFT
AND SIDE..........................19-28
COVER, TIMING CASE..............9-31,9-72
COVERÐXJ, BUCKET SEAT CUSHION....23-81
COVERÐXJ, PARKING BRAKE HANDLE . . . 23-94
COVERÐXJ, REAR SEAT CUSHION......23-82
COVERÐXJ, REAR SEATBACK..........23-84
COVERSÐXJ, B/C-PILLAR AND
LIFTGATE PILLAR TRIM...............23-88
COWL GRILLE AND SCREENÐXJ........23-12
COWL GRILLE AND SCREENÐYJ.......23-109
COWL WEATHERSTRIP SEAL/
CROSSMEMBER AIR DEFLECTORÐXJ....23-11
COWL WEATHERSTRIP SEALÐYJ......23-109
CRANKCASE VENTILATION SYSTEM;
EMISSION CONTROL SYSTEMS..........25-5
CRANKCASE VENTILATION SYSTEM;
LUBRICATION AND MAINTENANCE........0-19
CRANKING SPECIFICATIONS, 2.5L
STARTING SYSTEM COLD..............8A-23
CRANKING SPECIFICATIONS, 4.0L
STARTING SYSTEM COLD..............8A-23
CRANKSHAFT MAIN BEARINGS......9-45,9-87
CRANKSHAFT POSITION SENSOR; FUEL
SYSTEM............................14-60
CRANKSHAFT POSITION SENSOR;
FUEL/IGNITION (XJ)................8W-30-3
CRANKSHAFT POSITION SENSOR;
FUEL/IGNITION (YJ)................8W-30-3
CRANKSHAFT POSITION SENSOR;
IGNITION SYSTEMS..............8D-17,8D-3
CRANKSHAFT POSITION SENSOR;
FUEL/IGNITION (XJ-RHD)............8W-30-3
CRANKSHAFT POSITION SENSOR TEST;
FUEL SYSTEM.......................14-47
CRANKSHAFT POSITION SENSOR TEST;
IGNITION SYSTEMS...................8D-7
CRANKSHAFT POSITION SENSORÐPCM
INPUT.............................14-22
CROSSMEMBER COVER, FRAME........13-16
CROSSMEMBERÐXJ, RADIATOR
SUPPORT...........................23-6
CUSHION AND COVERÐXJ, BUCKET
SEAT ..............................23-81
CUSHION COVERÐXJ, REAR SEAT......23-82
CUSHIONÐXJ, REAR SEAT.............23-82
CUT-OFF SWITCH, LOW-PRESSURE
HIGH-PRESSURE................24-15,24-16
CYCLING CLUTCH SWITCH, FIN
SENSING......................24-15,24-31
CYLINDER AND COMBINATION VALVE
INSTALLATION (WITH ABS), MASTER.....5-20
CYLINDER AND COMBINATION VALVE
REMOVAL (WITH ABS), MASTER.........5-17
CYLINDER BENCH BLEEDING, MASTER
....5-21
CYLINDER BLOCK
.................9-49,9-91
CYLINDER BORES, HONING
..............9-2
CYLINDER, CLUTCH MASTER
............0-22
CYLINDER COMBUSTION PRESSURE
LEAKAGE TEST
........................9-6
6 INDEXJ
Description Group-Page Description Group-Page Description Group-Page

REPLACEMENTÐXJ VEHICLES, DRIVE
AXLE ASSEMBLY; REAR SUSPENSION
AND AXLES......................3-14,3-31
REPLACEMENTÐXJ, WINDSHIELD
GLASS.............................23-69
REPLACEMENTÐYJ, BACK-UP/REAR
TURN SIGNAL/TAIL LAMP BULB.........8L-28
REPLACEMENTÐYJ, DOOR FRAME
GLASS CHANNEL...................23-142
REPLACEMENTÐYJ, DOOR
WEATHERSTRIP SEAL................23-142
REPLACEMENTÐYJ, DRL MODULE......8L-30
REPLACEMENTÐYJ, FOG LAMP.........8L-25
REPLACEMENTÐYJ, FOG LAMP SWITCH . 8L-26
REPLACEMENTÐYJ, FRONT PARK/TURN
SIGNAL LAMP BULB..................8L-25
REPLACEMENTÐYJ, HEADLAMP BULB . . . 8L-23
REPLACEMENTÐYJ, HEADLAMP
DIMMER SWITCH....................8L-26
REPLACEMENTÐYJ, LIFTGATE GLASS
WEATHERSTRIP SEAL................23-125
REPLACEMENTÐYJ, SIDE MARKER
LAMP BULB.........................8L-25
REPLACEMENTÐYJ, UNDERHOOD LAMP . 8L-29
REPLACEMENTÐYJ, UNDERHOOD LAMP
BULB..............................8L-29
REPLACEMENTÐYJ VEHICLES, DRIVE
AXLE ASSEMBLY; FRONT SUSPENSION
AND AXLE...........................2-24
REPLACEMENTÐYJ VEHICLES, DRIVE
AXLE ASSEMBLY; REAR SUSPENSION
AND AXLES..........................3-14
REPLACEMENTÐYJ VEHICLES,
HARDTOP DOME/CARGO LAMP BULB....8L-31
REQUIREMENTS, FUEL..................0-1
REQUIRING NO LUBRICATION,
COMPONENTS.........................0-2
RESERVE/OVERFLOW SYSTEM,
COOLANT............................7-24
RESERVOIR REPLACEMENT (2-PIECE
MASTER CYLINDER)...................5-19
RESERVOIR, VACUUM.................8H-1
RESISTANCE, IGNITION COIL............8D-9
RESISTANCE (OHMS)ÐCOOLANT
TEMPERATURE SENSOR/MANIFOLD
AIR TEMPERATURE, SENSOR...........14-46
RESISTANCE, SPARK PLUG CABLE......8D-14
RESISTORS REPLACEMENT, BLOWER
MOTOR............................24-31
RESTRAINT REPLACEMENTÐXJ, DOOR . . . 23-41
RETAINER AND PISTON
SPECIFICATIONS, AW-4...............21-340
RETAINING BRACKETÐYJ, REARVIEW
MIRROR..........................23-144
RETURNÐPCM INPUT, SENSOR.........14-25
REVEAL MOLDINGÐXJ, WINDSHIELD....23-66
REVEAL MOLDINGÐYJ, WINDSHIELD . . . 23-144
RHD, STEERING.....................19-74
RIGHT HAND DRIVE, AUTOMATIC BELT
TENSIONERÐXJ MODELS WITH.........7-42
RIGHT HAND DRIVE, BELT SERVICEÐ
EXCEPT.............................7-40
RIGHT HAND DRIVE, BELT SERVICEÐXJ
MODELS WITH.......................7-42
RIGHT HAND DRIVE (RHD), BELT
TENSIONÐEXCEPT....................7-38
RIGHT HAND DRIVE (RHD) MODELS,
BELT TENSIONÐEXCEPT...............7-45
RIGHT HAND DRIVE VEHICLES...........23-1
RIGHT TURN RELAY; TRAILER TOW
(XJ).............................8W-54-1
RIGHT TURN RELAY; TRAILER TOW
(XJ-RHD).........................8W-54-1
RING CHARTÐAX 15 MANUAL
TRANSMISSION, SELECTIVE SNAP......21-334
RING/THRUST WASHER/THRUST PLATE
SPECIFICATIONS, 30RH/32RH SNAP.....21-335
ROCKER ARMS AND PUSH RODS....9-23,9-65
ROD AND PAWL SERVICE, PARK.......21-190
ROD BALL STUD REPLACEMENTÐXJ,
LIFTGATE SUPPORT
..................23-63
ROD BEARING FITTING CHART,
CONNECTING
.....................9-41,9-83
ROD CYLINDER DISPOSALÐXJ,
LIFTGATE SUPPORT
..................23-63
ROD CYLINDERÐXJ, LIFTGATE
SUPPORT
..........................23-62
ROD, TIE
......................19-16,19-19RODS, PISTONS AND CONNECTING . . . 9-39,9-81
RODS, ROCKER ARMS AND PUSH....9-23,9-65
RODSÐXJ, DOOR INSIDE LATCH
RELEASE AND LOCK..................23-50
ROOF VENTÐYJ, HARD TOP..........23-127
ROTOR, DISTRIBUTOR.................8D-8
ROTOR, IGNITION CABLES,
DISTRIBUTOR CAP....................0-20
ROTOR INSTALLATION.................5-51
ROTOR REFINISHING, DISC BRAKE.......5-53
ROTOR REMOVAL.....................5-51
ROTOR RUNOUT, DISC BRAKE...........5-52
ROTOR THICKNESS, DISC BRAKE........5-52
ROTORÐSPEEDOMETER DRIVE GEAR,
SPEED SENSOR.....................21-193
ROUGH AND/OR HAS A MISS, INJECTOR
DIAGNOSISÐVEHICLE RUNS...........14-52
ROUTING SCHEMATICÐ2.5L 4
CYLINDER ENGINE, VACUUM............25-3
ROUTING SCHEMATICÐ4.0L 6
CYLINDER ENGINE, VACUUM............25-3
ROUTING SCHEMATICS, VACUUM HOSE . . . 25-2
ROUTING, SYSTEM COOLANT.............7-1
RUBBER AND PLASTIC COMPONENT
INSPECTION.........................0-20
RUBBER AND PLASTIC HOSES/TUBING....0-26
RUNNING LAMP (DRL) MODULE,
DAYTIME.........................8W-50-2
RUNNING LAMP (DRL) MODULEÐ
CANADIAN VEHICLES ONLY, DAYTIME. . . 8W-50-2
RUNNING LIGHTS (CANADA ONLY)ÐXJ,
DAYTIME...........................8L-15
RUNNING LIGHTS (CANADA ONLY)ÐYJ,
DAYTIME...........................8L-30
RUNOUT............................16-4
RUNOUT, CLUTCH COVER AND DISC.......6-3
RUNOUT, DISC BRAKE ROTOR...........5-52
RUNOUT, FLYWHEEL....................6-3
RUNOUT SPECIFICATIONS..............16-4
RUNOUT, TIRE AND WHEEL.............22-8
RUNS ROUGH AND/OR HAS A MISS,
INJECTOR DIAGNOSISÐVEHICLE........14-52
SAFETY CERTIFICATION LABEL, VEHICLE . Intro.-4
SAFETY LATCH STRIKER
REPLACEMENTÐXJ..................23-11
SAFETY LATCHÐYJ, HOOD............23-109
SAFETY PRECAUTIONS AND WARNINGS . . 13-10
SAFETY PRECAUTIONS, BRAKE...........5-2
SAFETY PRECAUTIONS, CLUTCH.........6-10
SANDING,BUFFING AND POLISHING,
WET..............................23-158
SCAN TOOL, DRB; BRAKES...............5-3
SCAN TOOL, DRB; COOLING SYSTEM......7-5
SCAN TOOL, DRB; EMISSION CONTROL
SYSTEMS...........................25-2
SCAN TOOL, DRB; FUEL SYSTEM........14-54
SCAN TOOL, DRB; IGNITION SYSTEMS....8D-8
SCHEDULES, MAINTENANCE.............0-4
SCHEMATIC - YJ, BUZZER MODULE......8U-4
SCHEMATICÐ2.5L 4 CYLINDER ENGINE,
VACUUM ROUTING....................25-3
SCHEMATICÐ4.0L 6 CYLINDER ENGINE,
VACUUM ROUTING....................25-3
SCHEMATICÐXJ, AIR CONDITIONING.....24-5
SCHEMATICÐXJ, HEATING..............24-2
SCHEMATICS, BELT....................7-38
SCHEMATICS, PCM SYSTEM............14-41
SCHEMATICS, VACUUM HOSE ROUTING . . . 25-2
SCI RECEIVEÐPCM INPUT.............14-24
SCI TRANSMITÐPCM OUTPUT.........14-29
SCREENÐXJ, COWL GRILLE...........23-12
SCREENÐXJ, HEADLAMP/FOG LAMP
ADJUSTMENT USING ALIGNMENT........8L-7
SCREENÐYJ, COWL GRILLE..........23-109
SCREENÐYJ, HEADLAMP/FOG LAMP
ADJUSTMENT USING ALIGNMENT.......8L-23
SCREW ANCHOR AND BUMPERÐXJ,
LIFTGATE LICENSE PLATE..............23-65
SCUFF PLATE/COWL SIDE TRIM
PANELÐXJ, FRONT INNER.............23-86
SCUFF PLATESÐXJ, INTERIOR TRIM
PANELS
............................23-84
SCUFF PLATESÐXJ, OUTER
............23-89
SEAL AND BEARING, AXLE SHAFT
........3-17
SEAL AND BEARING SERVICE, AXLE
SHAFT
..............................3-32
SEAL AND SPRING REPLACEMENT,
VALVE STEM
.........................9-65SEAL REPLACEMENT, INNER AXLE
SHAFT OIL...........................2-35
SEAL REPLACEMENT, MANUAL VALVE
SHAFT............................21-187
SEAL REPLACEMENT, OIL PUMP.......21-199
SEAL REPLACEMENT, PINION; FRONT
SUSPENSION AND AXLE................2-25
SEAL REPLACEMENT, PINION; REAR
SUSPENSION AND AXLES...............3-33
SEAL REPLACEMENT, PINION SHAFT......3-15
SEAL REPLACEMENT, PITMAN SHAFT....19-37
SEAL REPLACEMENT, TIMING CASE
COVER OIL......................9-30,9-73
SEAL REPLACEMENTÐYJ, DOOR
WEATHERSTRIP....................23-142
SEAL REPLACEMENTÐYJ, LIFTGATE
GLASS WEATHERSTRIP..............23-125
SEAL/CROSSMEMBER AIR
DEFLECTORÐXJ, COWL
WEATHERSTRIP.....................23-11
SEALÐDRIVE PLATE SERVICE,
CONVERTERÐPUMP.................21-116
SEALÐXJ, LIFTGATE OPENING
WEATHERSTRIP.....................23-64
SEALÐYJ, BELTLINE.................23-142
SEALÐYJ, COWL WEATHERSTRIP......23-109
SEALÐYJ, TAILGATE WEATHERSTRIP . . . 23-123
SEALÐYJ, WINDSHIELD FRAME
WEATHERSTRIP....................23-146
SEALS AND BEARING REPLACEMENT,
PITMAN SHAFT......................19-34
SEALS, REAR MAIN OIL..............9-49,9-89
SEALS, VALVE SPRINGS AND OIL........9-23
SEALSÐIN CAR REPLACEMENT, PITMAN
SHAFT.............................19-23
SEALSÐXJ, DOOR WINDOW GLASS
AND DOOR OPENING WEATHERSTRIP....23-55
SEALSÐYJ, FULL-METAL DOOR
WEATHERSTRIP....................23-141
SEAT ADJUSTER/MOTORS, POWER . . . 8R-1,8R-2
SEAT ADJUSTER/MOTORS REMOVE/
INSTALL, POWER.....................8R-3
SEAT BELT INDICATOR WARNING LAMP;
INSTRUMENT CLUSTER (XJ).........8W-40-2
SEAT BELT INDICATOR WARNING LAMP;
INSTRUMENT CLUSTER (XJ-RHD).....8W-40-2
SEAT BELT SWITCH, DRIVER'S......8U-1,8U-3
SEAT CUSHION AND COVERÐXJ,
BUCKET............................23-81
SEAT CUSHION COVERÐXJ, REAR......23-82
SEAT CUSHIONÐXJ, REAR.............23-82
SEAT PLATFORMÐXJ, BUCKET.........23-82
SEAT, POWER; POWER SEAT (XJ).....8W-63-1
SEAT, POWER; POWER SEAT (XJ-RHD) . 8W-63-1
SEAT SWITCH CONTINUITY, POWER......8R-2
SEAT SWITCH, POWER............8R-1,8R-2
SEAT SWITCH REMOVE/INSTALL,
POWER.............................8R-3
SEATBACK COVER AND FRAMEÐXJ,
BUCKET............................23-81
SEATBACK COVERÐXJ, REAR..........23-84
SEATBACK LATCH STRIKER AND
BUMPERÐXJ, REAR..................23-84
SEATBACKÐXJ, REAR................23-83
SEATÐYJ, REAR BENCH..............23-153
SEATSÐXJ, FRONT BUCKET............23-81
SEATSÐYJ........................23-153
SEATSÐYJ, BUCKET.................23-153
SECOND (2) RANGE, HYDRAULIC FLOW
IN MANUAL.........................21-96
SECOND BRAKE OVERHAUL...........21-241
SECONDARY CABLES, SPARK PLUG.....8D-14,
8D-24
SECONDARY CIRCUIT DIAGNOSIS,
IGNITION...........................8D-10
SECTION IDENTIFICATION; WIRING
DIAGRAMS (XJ)......................8W-1
SECTION IDENTIFICATION; WIRING
DIAGRAMS (XJ-RHD)..................8W-1
SECTION IDENTIFICATION; WIRING
DIAGRAMS (YJ)
......................8W-1
SELECTIVE SNAP RING CHARTÐAX 15
MANUAL TRANSMISSION
.............21-334
SELF-DIAGNOSTIC TEST, COMPASS/
DISPLAY
............................8C-2
SENDING UNIT, FUEL GAUGE
...........14-16
SENSEÐPCM INPUT, AUTOMATIC
SHUTDOWN (ASD)
...................14-21
24 INDEXJ
Description Group-Page Description Group-Page Description Group-Page

SWITCH INPUT, BRAKE; FUEL/IGNITION
(YJ).............................8W-30-5
SWITCH INPUT, BRAKE; FUEL/IGNITION
(XJ-RHD).........................8W-30-5
SWITCH INSTALLATION, ACCELERATION . . . 5-39
SWITCH INSTALLATION, BRAKELIGHT.....5-32
SWITCH LAMP, IGNITION; INTERIOR
LIGHTING (XJ)....................8W-44-1
SWITCH LAMP, IGNITION; INTERIOR
LIGHTING (XJ-RHD)................8W-44-1
SWITCH, LIFTGATE WIPER/WASHER . 8K-16,8K-5
SWITCH OPERATION, ACCELERATION.....5-37
SWITCH, PARK NEUTRAL..............14-63
SWITCH, PARKING BRAKE..............5-68
SWITCH, PARK/NEUTRAL POSITION;
FUEL/IGNITION (XJ)................8W-30-4
SWITCH, PARK/NEUTRAL POSITION;
FUEL/IGNITION (YJ)................8W-30-4
SWITCH, PARK/NEUTRAL POSITION;
TRANSMISSION AND TRANSFER CASE . . 21-183
SWITCH, PARK/NEUTRAL POSITION;
FUEL/IGNITION (XJ-RHD)............8W-30-4
SWITCH, PASSENGER'S POWER LOCK....8P-6
SWITCH, PASSENGER'S POWER
WINDOW............................8S-6
SWITCH, POWER BRAKE BOOSTERÐ
BRAKE PEDALÐBRAKELIGHT............5-22
SWITCH, POWER LOCK................8P-1
SWITCH, POWER MIRROR..........8T-1,8T-2
SWITCH, POWER SEAT............8R-1,8R-2
SWITCH, POWER STEERING PRESSURE;
FUEL/IGNITION (XJ)................8W-30-5
SWITCH, POWER STEERING PRESSURE;
FUEL/IGNITION (YJ)................8W-30-4
SWITCH, POWER WINDOW.........8S-1,8S-2
SWITCH REMOVAL, ACCELERATION.......5-39
SWITCH REMOVAL, BRAKELIGHT.........5-32
SWITCH REMOVE/INSTALL - XJ,
MULTI-FUNCTION.....................8J-5
SWITCH REMOVE/INSTALL - YJ, TURN
SIGNAL/HAZARD WARNING.............8J-5
SWITCH REMOVE/INSTALL, DEFOGGER....8N-4
SWITCH REMOVE/INSTALL, HEADLAMP . . . 8E-19
SWITCH REMOVE/INSTALL, HEADLAMP
OR PANEL DIMMER..................8E-42
SWITCH REMOVE/INSTALL, HORN........8G-3
SWITCH REMOVE/INSTALL, LIFTGATE
WIPER/WASHER.................8K-24,8K-8
SWITCH REMOVE/INSTALL, POWER
LOCK...............................8P-8
SWITCH REMOVE/INSTALL, POWER
MIRROR............................8T-4
SWITCH REMOVE/INSTALL, POWER
SEAT ...............................8R-3
SWITCH REMOVE/INSTALL, POWER
WINDOW............................8S-7
SWITCH REMOVE/INSTALL, SPEED
CONTROL...........................8H-9
SWITCH REMOVE/INSTALL, WINDSHIELD
WIPER/WASHER.................8K-20,8K-7
SWITCH REPLACEMENT, BLOWER
MOTOR/AIR DOOR MOTOR.............24-32
SWITCH REPLACEMENTÐXJ, FOG LAMP . 8L-10
SWITCH REPLACEMENTÐYJ, FOG LAMP . 8L-26
SWITCH REPLACEMENTÐYJ,
HEADLAMP DIMMER..................8L-26
SWITCH SERVICE, IGNITION............19-54
SWITCH SERVICE, PARK/NEUTRAL
POSITION.........................21-109
SWITCH SERVICE PROCEDURESÐXJ,
MULTI-FUNCTION....................8L-11
SWITCH, SPEED CONTROL.........8H-1,8H-6
SWITCH, STOP LAMP.............8H-1,8H-6
SWITCH TEST, EXTENDED IDLE.........14-48
SWITCH TESTING, INTERMITTENT WIPE . . 8K-15
SWITCH TESTING, NON-INTERMITTENT
WIPE..............................8K-14
SWITCH TESTING PROCEDURESÐXJ,
MULTI-FUNCTION.....................8L-4
SWITCH, TRANSMISSION COMFORT;
TRANSMISSION CONTROLS (XJ-RHD)
. . 8W-31-1
SWITCH, WINDSHIELD WIPER/WASHER
. . 8K-13,
8K-4
SWITCH (XJ ONLY), HEADLAMP
.....8U-1,8U-3
SWITCHÐ2.5L ENGINE ONLY, POWER
STEERING PRESSURE
.................14-63
SWITCHÐ2-DOOR (LHD), DRIVER'S
POWER LOCK
........................8P-3SWITCHÐ2-DOOR (LHD), DRIVER'S
POWER WINDOW.....................8S-4
SWITCHÐ2-DOOR (RHD), DRIVER'S
POWER LOCK........................8P-4
SWITCHÐ2-DOOR (RHD), DRIVER'S
POWER WINDOW.....................8S-5
SWITCHÐ4-DOOR, DRIVER'S POWER
LOCK...............................8P-5
SWITCHÐ4-DOOR, DRIVER'S POWER
WINDOW............................8S-3
SWITCHÐPCM INPUT, BRAKE..........14-22
SWITCHÐPCM INPUT, EXTENDED IDLE . . . 14-23
SWITCHÐPCM INPUT, PARK/NEUTRAL . . . 14-24
SWITCHÐPCM INPUT, POWER
STEERING PRESSURE.................14-24
SWITCHÐXJ, HEADLAMP..............8L-10
SWITCHÐXJ MODELS, IGNITION........8D-26
SWITCHÐYJ, HEADLAMP..............8L-26
SWITCHÐYJ MODELS, IGNITION........8D-29
SYMBOLS; WIRING DIAGRAMSÐ
GENERAL INFORMATION (XJ)...........8W-2
SYMBOLS, INTERNATIONAL..............0-1
SYMBOLS, INTERNATIONAL VEHICLE
CONTROL AND DISPLAY.............Intro.-5
SYMBOLS, VEHICLE CONTROL AND
DISPLAY.........................Intro.-10
SYSTEM - XJ, TURN SIGNAL/HAZARD
WARNING...........................8J-3
SYSTEM - YJ, HAZARD WARNING........8J-4
SYSTEM - YJ, TURN SIGNAL............8J-3
SYSTEM, A/C-HEATER; AIR
CONDITIONING/HEATER (XJ).........8W-42-1
SYSTEM, A/C-HEATER; AIR
CONDITIONING/HEATER (XJ-RHD).....8W-42-1
SYSTEM, AIRBAG; RESTRAINT SYSTEMS . . 8M-1
SYSTEM, AIRBAG; STEERING...........19-47
SYSTEM CAPACITIES, COOLING..........7-45
SYSTEM, CHARGING; BATTERY/
STARTING/CHARGING SYSTEMS
DIAGNOSTICS.......................8A-17
SYSTEM, CHARGING; CHARGING
SYSTEM (XJ).....................8W-20-1
SYSTEM, CHARGING; CHARGING
SYSTEM (XJ-RHD).................8W-20-1
SYSTEM, CHARGING; CHARGING
SYSTEM (YJ).....................8W-20-1
SYSTEM, CHARGING REFRIGERANT......24-11
SYSTEM CLEANING/REVERSE FLUSHING,
COOLING............................7-22
SYSTEM COLD CRANKING
SPECIFICATIONS, 2.5L STARTING........8A-23
SYSTEM COLD CRANKING
SPECIFICATIONS, 4.0L STARTING........8A-23
SYSTEM COMPONENTS, COOLING.........7-1
SYSTEM COMPONENTS, STEERING.......19-1
SYSTEM, COOLANT RESERVE/
OVERFLOW..........................7-24
SYSTEM COOLANT ROUTING.............7-1
SYSTEM, COOLING; COOLING SYSTEM.....7-1
SYSTEM, COOLING; HEATING AND AIR
CONDITIONING......................24-10
SYSTEM, CRANKCASE VENTILATION;
EMISSION CONTROL SYSTEMS..........25-5
SYSTEM, CRANKCASE VENTILATION;
LUBRICATION AND MAINTENANCE........0-19
SYSTEM DESCRIPTION.................5-33
SYSTEM DIAGNOSIS, CHARGING........8A-19
SYSTEM DIAGNOSIS (CONT.), COOLING . . . 7-10,
7-11,7-12,7-7,7-8,7-9
SYSTEM DIAGNOSIS, COOLING
...........7-6
SYSTEM DIAGNOSIS, EXHAUST
..........11-2
SYSTEM DIAGNOSIS, HEATING
..........24-18
SYSTEM DIAGNOSIS, MANUAL
STEERING
..........................19-38
SYSTEM DIAGNOSIS, POWER STEERING
. . 19-3,
19-4,19-5,19-6,19-7,19-8,19-9
SYSTEM DIAGNOSIS, STARTING
........8A-12
SYSTEM DIAGNOSIS, SUSPENSION AND
STEERING
............................2-7
SYSTEM, DRAINING COOLING
...........7-21
SYSTEM, EMISSION CONTROL
...........0-20
SYSTEM, ENGINE COOLING
.............0-18
SYSTEM, EVACUATING REFRIGERANT
....24-11
SYSTEM, EVAP (EVAPORATION)
CONTROL
...........................25-4
SYSTEM, EXHAUST; EXHAUST SYSTEM
AND INTAKE MANIFOLD
................11-1SYSTEM, EXHAUST; LUBRICATION AND
MAINTENANCE.......................0-21
SYSTEM, EXHAUST GAS
RECIRCULATION (EGR).................25-1
SYSTEM FANS, COOLING...............7-32
SYSTEM FOR LEAKS, TESTING COOLING . . . 7-22
SYSTEM, FUEL......................14-67
SYSTEM, FUEL DELIVERY...............14-3
SYSTEM, HAZARD WARNING............8J-1
SYSTEM, HEATER; AIR CONDITIONING/
HEATER (XJ)......................8W-42-1
SYSTEM, HEATER; AIR CONDITIONING/
HEATER (XJ-RHD)..................8W-42-1
SYSTEM, HEATER; AIR CONDITIONING/
HEATER (YJ)......................8W-42-1
SYSTEM HOSES, COOLING..............7-32
SYSTEM, HYDRAULIC................21-169
SYSTEM INDICATOR LAMP, CHARGING;
INSTRUMENT CLUSTER (XJ).........8W-40-3
SYSTEM, LIFTGATE WASHER............8K-5
SYSTEM, LIFTGATE WIPER..............8K-4
SYSTEM, LIFTGATE WIPER/WASHER.....8K-10,
8K-16,8K-1
SYSTEM, LUBRICATION............9-37,9-79
SYSTEM MAINTENANCE, EMISSION
CONTROL............................0-4
SYSTEM, POWER BRAKE...............0-30
SYSTEM, POWER LOCK................8P-2
SYSTEM, POWER MIRROR..............8T-1
SYSTEM, POWER STEERING.............0-29
SYSTEM POWER-UP AND
INITIALIZATION, ABS...................5-35
SYSTEM PRESSURE RELEASE
PROCEDURE, FUEL...................14-62
SYSTEM PRESSURE TEST, FUEL....14-51,14-6
SYSTEM, REAR WIPER; WIPERS (XJ) . . 8W-53-1
SYSTEM, REAR WIPER; WIPERS
(XJ-RHD).........................8W-53-1
SYSTEM, REAR WIPER; WIPERS (YJ) . . 8W-53-1
SYSTEM, RECOVERING REFRIGERANT....24-11
SYSTEM, REFILLING COOLING...........7-21
SYSTEM SCHEMATICS, PCM............14-41
SYSTEM SERVICE (DEPLOYED), AIRBAG . . 8M-2
SYSTEM SPECIFICATIONS, CHARGING....8A-23
SYSTEM SPECIFICATIONS, STARTING....8A-23
SYSTEM, STARTING; BATTERY/
STARTING/CHARGING SYSTEMS
DIAGNOSTICS.......................8A-11
SYSTEM, STARTING; STARTING SYSTEM
(XJ).............................8W-21-1
SYSTEM, STARTING; STARTING SYSTEM
(XJ-RHD).........................8W-21-1
SYSTEM, STARTING; STARTING SYSTEM
(YJ).............................8W-21-1
SYSTEM, TURN SIGNAL................8J-1
SYSTEM, USING ON-BOARD
DIAGNOSTIC; BATTERY/STARTING/
CHARGING SYSTEMS DIAGNOSTICS.....8A-22
SYSTEM, USING ON-BOARD
DIAGNOSTIC; VEHICLE SPEED
CONTROL SYSTEM....................8H-5
SYSTEM WARNING LIGHT..............5-35
SYSTEM, WINDSHIELD WASHER . . 8K-10,8K-12,
8K-1,8K-4
SYSTEM, WINDSHIELD WIPER....8K-10,8K-12,
8K-1,8K-3
TABLE, BATTERY CHARGING TIME........8A-8
TACHOMETER; INSTRUMENT CLUSTER
(XJ).............................8W-40-2
TACHOMETER; INSTRUMENT CLUSTER
(XJ-RHD).........................8W-40-2
TACHOMETER SIGNAL; FUEL/IGNITION
(XJ).............................8W-30-5
TACHOMETER SIGNAL; FUEL/IGNITION
(YJ).............................8W-30-5
TACHOMETER SIGNAL; FUEL/IGNITION
(XJ-RHD).........................8W-30-4
TACHOMETERÐPCM OUTPUT..........14-29
TAIL LAMPS AND LICENSE PLATE
LAMPS; REAR LIGHTING (YJ)........8W-51-1
TAIL LAMPS AND REAR LICENSE PLATE
LAMPS; REAR LIGHTING (XJ)
........8W-51-1
TAIL LAMPS AND REAR LICENSE PLATE
LAMPS; REAR LIGHTING (XJ-RHD)
....8W-51-1
TAILGATE ADJUSTMENTÐYJ
..........23-121
TAILGATE HINGEÐYJ
................23-121
TAILGATE LATCH AND RELEASE
HANDLEÐYJ
.......................23-122
28 INDEXJ
Description Group-Page Description Group-Page Description Group-Page