1994 TOYOTA CAMRY Head

METER, ANALOG
Current flow activates a magnetic
coil which causes a needle to
move, thereby providing a relative
display against a background
calibration. LED (LIGHT EMITTING DIODE)
Upon current flow, these diodes
emit light without producing the
heat of a comparable light. IGNITION COIL
Converts low±voltage DC current
into high±voltage ignition current
for firing the spark plugs. 1. SINGLE
FILAMENT
GROUND
The point at which wiring attaches
to the Body, thereby providing a
return path for an electrical circuit;
without a ground, current cannot
flow.Current flow causes a headlight
filament to heat up and emit light.
A headlight may have either a
single (1) filament or a double (2)
filament. BATTERY
Stores chemical energy and
converts it into electrical energy.
Provides DC current for the auto's
various electrical circuits.
CAPACITOR (Condenser)
A small holding unit for temporary
storage of electrical voltage.
CIRCUIT BREAKER
Basically a reusable fuse, a circuit
breaker will heat and open if too
much current flows through it. Some
units automatically reset when cool,
others must be manually reset.
DIODE
A semiconductor which allows
current flow in only one direction.
DIODE, ZENER
A diode which allows current flow
in one direction but blocks reverse
flow only up to a specific voltage.
Above that potential, it passes the
excess voltage. This acts as a
simple voltage regulator.
FUSE
A thin metal strip which burns
through when too much current
flows through it, thereby stopping
current flow and protecting a
circuit from damage.
FUSIBLE LINK
A heavy±gauge wire placed in
high amperage circuits which
burns through on overloads,
thereby protecting the circuit.
The numbers indicate the cross±
section surface area of the wires.HORN
An electric device which sounds a
loud audible signal.
LIGHT
Current flow through a filament
causes the filament to heat up
and emit light.
METER, DIGITAL
Current flow activates one or
many LED's, LCD's, or fluorescent
displays, which provide a relative
or digital display.
MOTOR
A power unit which converts
electrical energy into mechanical
energy, especially rotary motion. CIGARETTE LIGHTER
An electric resistance heating
element.
DISTRIBUTOR, IIA
Channels high±voltage current
from the ignition coil to the
individual spark plugs.2. DOUBLE
FILAMENT HEADLIGHTS
FUEL
(for High Current Fuse or
Fusible Link.)
(for Medium Current Fuse)
M
16
GLOSSARY OF TERMS AND SYMBOLS

28
ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[1MZ±FE]
A 2 A/C Triple Pressure SW (A/C Dual and Single Pressure F 1 Front Airbag Sensor LH
SW) F 2 Front Airbag Sensor RH
A 3 A/C Magnetic Clutch and Lock Sensor F 3 Front Clearance Light LH
A 4 ABS Actuator F 4 Front Clearance Light RH
A 5 ABS Actuator F 5 Front Side Marker LH
A 6 ABS Relay F 6 Front Side Marker RH
A 7 ABS Relay F 7 Front Turn Signal Light LH
A 8 ABS Speed Sensor Front LH F 8 Front Turn Signal Light RH
A 9 ABS Speed Sensor Front RH F 9 Front Wiper Motor
F 10 Fuse Box
B 2 Brake Fluid Level SW F 16 Fuse Box
F 18 Fuse Box
C 2 Cruise Control Actuator
C 17 Camshaft Position Sensor G 1 Generator (Alternator)
C 18 Crankshaft Position Sensor G 2 Generator (Alternator)
D 1 Data Link Connector 1 (Check Connector) H 1 Headlight Hi LH
D 2 Distributor H 2 Headlight Hi RH
H 3 Headlight Lo LH
E 1 EGR Gas Temp. Sensor H 4 Headlight Lo RH
E 2 Electronic Controlled Transmission Solenoid H 5 Horn LH
E 4 Engine Coolant Temp. Sensor (EFI Water Temp. H 6 Horn RH
Sensor) H 11 Heated Oxygen Sensor (Bank 1 Sensor 1)
E 5 Engine Coolant Temp. Sensor (Water Temp. Sensor) H 12 Heated Oxygen Sensor (Bank 2 Sensor 1)
(for Cooling Fan)

31
Position of Parts in Engine Compartment
[5S±FE]
H 1 Headlight Hi LH O 1 Oil Pressure SW
H 2 Headlight Hi RH O 2 Oxygen Sensor (Sub)
H 3 Headlight Lo LH O 3 Oxygen Sensor (Main)
H 4 Headlight Lo RH
H 5 Horn LH P 1 Park/Neutral Position SW (Neutral Start SW) (A/T)
H 6 Horn RH
R 1 Radiator Fan Motor
I 1 Idle Air Control Valve (ISC Valve)
I 2 Igniter S 3 Starter
I 3 Ignition Coil S 4Starter
I 4 Injector No. 1
I 5 Injector No. 2 T 1 Throttle Position Sensor
I 6 Injector No. 3
I 7 Injector No. 4 V 1 VSV (for A/C Idle±Up)
I 10 Intake Air Temp. Sensor (In±Air Temp. Sensor) V 2 VSV (for EGR System)
V 3 VSV (for Fuel Pressure Up)
K 1 Knock Sensor V 5 Vehicle Speed Sensor (Speed Sensor)
M 1 Manifold Absolute Pressure Sensor (Vacuum Sensor) W 1 Washer Motor
W 2 Water Temp. Sender
N 1 Noise Filter (for Ignition System)

39
Connector Joining Wire Harness and Wire Harness
CODEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
EB1ENGINE ROOM MAIN WIRE AND RELAY WIRE (UNDER THE R/B NO. 5)
EC1ENGINE WIRE AND ENGINE ROOM MAIN WIRE (UNDER THE J/B NO. 1)
ED1COWL WIRE AND ENGINE ROOM MAIN WIRE (UNDER THE J/B NO. 1)
EE1SENSOR WIRE AND ENGINE WIRE (SIDE OF FRONT CYLINDER HEAD)
EF1ENGINE WIRE AND COWL WIRE (NEAR THE BRAKE MASTER CYLINDER)

52
POWER SOURCE (Current Flow Chart)
The chart below shows the route by which current flows from the battery to each electrical source (Fusible Link,
Circuit Breaker, Fuse, etc.) and other parts.
The next page and following pages show the parts to which each electrical source outputs current.
Starter Battery
FL MAIN 2.0L30A AM2Ignition SW
(AM2)
Headlight Relay
(Point Side)
40A DEFOG 100A ALTGenerator
(Alternator) 7.5A SRS
Taillight Relay
(Coil Side) 40A MAIN
(Canada) 7.5A OBD
7.5A ALT±S
10A HAZ
10A HORN
15A ECU±B
15A EFI
20A DOMEHeadlight Relay
(Coil Side)
60A ABS 15A STOP
40A HEATER
Taillight Relay
(Point Side)
Engine Main
Relay (Point Side)
15A TEL
Daytime Running
Light Relay No. 2
(Coil Side)
Daytime Running
Light Relay No. 2
(Point Side)Starter Relay
(Point Side)
(5S±FE)
30A POWER
40A AM1
Daytime Running
Light Relay (Main)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
[LOCATION](1): J/B No. 1 (See page 20)(2): J/B No. 2 (See page 19)
(3): R/B No. 1 (See page 20)(7): R/B No. 7 (See page 19) 2022
25
27

53
Integration Relay 7.5A IGN
Daytime Running
Light Relay (Main)
Ignition SW
(AM1)(USA)
Starter Relay
(Coil Side) 10A MIR HTRABS Actuator
Light Control SW
[Comb. SW]15A HEAD (LH)
10A A/CABS ECU ABS Actuator
and ECU(TMM Made)
ABS Relay
Integration
Relay
Defogger Relay
(Point Side)
Heater Relay
(Point Side)
15A TAIL
Power Main Relay
(Point Side)Clutch Start
SW Light Control SW
[Comb. SW]
* These are the page numbers of the first page on which the related
system is shown.
The part indicated is located somewhere in the system, not
necessarily on the page indicated here.
(Canada)
Dimmer SW
[Comb. SW]
30A RDI FAN
30A CDS FAN15A HEAD (RH)
7.5A DRL
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
(Canada)
10A STARTER
Starter
(M/T)
(A/T)
Park/Neutral
Position SW
(Neutral Start SW)
Engine Control
Module (Engine and
Electronic Controlled
Transmission ECU)
7.5A TURN
10A GAUGE
15A ECU±IG
15A CIG/RADIO
20A WIPER (TMC Made) ABS Relay
(4): R/B No. 4 (See page 20)(5): R/B No. 5 (See page 19)(6)R/B No. 6 (See Page )
2526 26

54
POWER SOURCE (Current Flow Chart)
40A AM1
15A CIG/RADIO
40A DEFOG
15A ECU±1G
10A GAUGE
7.5A IGN
10A MIR±HTR
30A POWER
7.5A SRS
15A STOP
15A TAIL
7.5A TURN
20A WIPER
30A AM2
7.5A ALT±S
30A CDS FAN
20A DOME
15A ECU±B
15A EFI
10A HAZ
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
15A HEAD LH
15A HEAD RH
10A HORN
40A MAIN
7.5A OBD
10A STARTER
10A A/C
40A HEATER
7.5A DRL
100A ALT
60A ABS
A/C Condenser Fan Motor (5S±FE)
242
A4 A5 A11 A1*Page Nos. of
Related Systems
Parts
Code or
Location
CB or Fuse
LocationA2 A3
* These are the page numbers of the first page on which the related system is shown.
The part indicated is located somewhere in the system, not necessarily on the page indicated here.


A12 A6 A7 A13 A17 A18A14 A16 A21 B1 B2 B3 B4 B5 B6 B7 B9 B10 214 252126
252210 210 246246
252126222
224152 236 166246
252246
252126
246
252160
166 220 220
A/C Triple Pressure SW (A/C Dual
and Single Pressure SW)
A/C Magnetic Clutch and Lock
Sensor
ABS Actuator and ECU
(TMM Made)
ABS Actuator (TMC Made)
ABS Actuator and ECU
(TMM Made)
ABS Relay
A/C Amplifier
A/C SW
ABS ECU (TMC Made)
Air Inlet Control Servo Motor
Air Vent Mode Control Servo Motor
Ashtray Illumination
Auto Antenna Motor and Relay
Back±Up Light SW (M/T)
Brake Fluid Level SW
Back Door Lock Control SW
Blower Motor
Blower Resistor
Blower SW
Buckle SW LH
Back Door Lock Motor (W/G)
Buckle SW RH
A10246
252 210 210 210 214 246
252 242
246
252
ABS ECU (TMC Made)A/C Evaporator Temp. Sensor ABS Relay
[LOCATION](1)
(7): J/B No. 1 (See page 20)
: R/B No. 7 (See page )(2)
(8): J/B No. 2 (See page 19)
: Fuse Box (F10, F17 See
on page )(3): R/B No. 1 (See page 23)
2022
25
27
28 29

56
POWER SOURCE (Current Flow Chart)
*Page Nos. of
Related Systems
Parts
Code or
Location
CB or Fuse
Location
* These are the page numbers of the first page on which the related system is shown.
The part indicated is located somewhere in the system, not necessarily on the page indicated here.


D25 E9E8 130
134
138
140130
138160 80 220126
198
20480
Door Courtesy SW Front LH
Door Key Cylinder Light and SW
Engine Control Module (Engine
and Electronic Controlled
Transmission ECU) (A/T) (1MZ±FE)
40A AM1
15A CIG/RADIO
40A DEFOG
15A ECU±1G
10A GAUGE
7.5A IGN
10A MIR±HTR
30A POWER
7.5A SRS
15A STOP
15A TAIL
7.5A TURN
20A WIPER
30A AM2
7.5A ALT±S
30A CDS FAN
20A DOME
15A ECU±B
15A EFI
10A HAZ
15A HEAD (LWR±LH)
15A HEAD (LWR±RH)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
15A HEAD LH
15A HEAD RH
10A HORN
40A MAIN
7.5A OBD
10A STARTER
10A A/C
40A HEATER
7.5A DRL
100A ALT
60A ABSE7 E6 E5 E3 E2
D24 D23 D22 D21 D20 D19 D18
D17 D16 D15 D14 D13 D12130
138
140130
134
138
140130
134
138
140160 160 160 160 160 160198
220220 242 80
90
98
19880
Engine Control Module (Engine
and Electronic Controlled
Transmission ECU) (A/T) (5S±FE) Engine Control Module (Engine
and Electronic Controlled
Transmission ECU) Engine Controlled
Transmission Pattern
Select SW Engine Coolant Temp. Sensor
(Water Temp. Sensor) (for
Cooling Fan) (1MZ±FE) Electronic Controlled Transmission
Solenoid (5S±FE) Electronic Controlled Transmission
Solenoid Diode (for Tension Reducer) (C/P) Date Ling Connector 3 Door Lock Motor Rear RH
(EX. C/P) Door Lock Motor Rear LH
(EX. C/P) Door Courtesy SW Front RH
Door Courtesy SW Rear LH
Door Courtesy SW Rear RH
Door Key Lck and Unlock SW LH
(Ex. C/P)
Door Key Lck and Unlock SW RH
(Ex. C/P)
Door Lock Control SW RH
Door Lock Motor and Door Unlock
Detection SW Front LH
Door Lock Motor and Door Unlock
Detection SW Front RH
[LOCATION](1)
(7): J/B No. 1 (See page 20)
: R/B No. 7 (See page )(2)
(8): J/B No. 2 (See page 19)
: Fuse Box (F10, F17 See
on page )(3): R/B No. 1 (See page 23)
2022
25
27
28 29