1994 PONTIAC GRAND-AM engine

Service & Appearance Care
How to Check:
The proper fluid should be added if the
level is at or below the STEP mark on the
reservoir cap. See the instructions on the
reservoir cap.
Engine Coolant
The following explains your cooling
system and how to add coolant when
it is
low.
If you have a problem with engine
overheating, see “Engine Overheating”
in
the Index,
The proper coolant for your Pontiac will:
Give freezing protection down to
-34°F (-37°C).
Give boiling protection up to 262°F
( 128 “C).
Protect against rust and corrosion.
Help keep the proper engine
temperature.
Let the warning lights work as they
should.
What to Use
Use a mixture of one-half clean water
(preferably distilled) and one-half
antifreeze that meets “GM Specification
1825-M,” which won’t damage aluminum
parts.
You can also use a recycled coolant
conforming to GM Specification 1825-M
with a complete coolant flush and refill. If
you use this mixture, you don’t need to
add anything else. NOTICE:
If you use an improper coolant mix,
your engine could overheat and be
badly damaged. The repair cost
wouldn’t be covered by your
warranty. Too much water
in the
mix can freeze and crack the engine,
radiator, heater core and other parts.
... 188
ProCarManuals.com

Adding Coolant
To Check Coolant:
When your engine is cold, the coolant
level should be at the
FULL COLD
mark, or a little higher.
To Add Coolant:
If you need more coolant, add the proper
mix at the surge tank, but only when the
engine
is cool.
‘hen replacing the pressure cap, make
Ire
it is tight.
C
189...
ProCarManuals.com

Service & Appearance Care
V
P
I
E
b
S’
C
C.
P
A
I Surge Tank Pressure
Cap
NOTICE:
Your pressure cap is an 18 psi
( 124 kPa) pressure-type cap and
must be tightly installed to prevent
coolant
loss and possible engine
damage from overheating.
irhen you replace your surge tank
ressure cap, a GM cap is recommended.
I Thermostat
lngine coolant temperature is controlled
y a thermostat in the engine coolant
ystem. The thermostat stops the flow
of
oolant through the radiator until the
oolant reaches a preset temperature.
Jhen you replace your thermostat, an
.C@ thermostat is recommended.
Power Steering Fluid
How To Check Power
Steering Fluid
Unscrew the cap and wipe the dipstick
with a clean rag. Replace the cap and
completely tighten
it. Then remove the
cap again and
look at the fluid level on
the dipstick.
0
0
When the engine compartment is hot,
the level should be at the HOT
(H)
mark.
When the engine compartment is cool,
the level should be at the
COLD (C)
mark.
1
I
1
What to Add
Refer to the Maintenance Schedule to
jetermine what kind
of fluid to use. See
“Recommended Fluids and Lubricants”
in
the Index.
NOTICE:
When adding power steering fluid
or making a complete fluid change,
always use the proper fluid. Failure
to use the proper fluid can cause
leaks and damage hoses and seals.
... 190
ProCarManuals.com

Service & Appearance Care
Brake Master Cylinder
(CONT.)
when your linings are worn, then you’ll
have too much fluid when you get new
brake linings. You should add (or remove)
brake fluid, as necessary, only when work
is done on the brake hydraulic system.
When your brake fluid falls to a low level.
your brake warning light wil1,come on.
See “Brake System Warning Light” in the
Index.
What to Add:
When you do need brake fluid, use only
DOT-3 brake fluid -- such as Delco
Supreme
11 @ (GM Part No. 1052535).
Use new brake fluid from a sealed
:ontainer only, and always clean the brak
fluid reservoir cap before removing it.
NOTICE:
e
0
Don’t let someone put in the
wrong kind
of fluid. For
example, just a few drops
of
mineral-based oil, such as
engine oil, in your brake
system can damage brake
system parts
so badly that
they’ll have to be replaced.
Brake fluid can damage
paint,
so be careful not to
spill brake fluid on your
vehicle. If you
do, wash it off
immediately. See
“Appearance Care” in the
Index.
3rake Wear
‘our Pontiac has front disc brakes and
ear drum brakes.
Xsc brake pads have built-in wear
ndicators that make a high-pitched
varning sound when the brake pads are
vorn and new pads are needed. The
ound may come and
go or be heard all
he time your vehicle is moving (except
when you are pushing on the brake pedal
irmly).
ProCarManuals.com

I
ENGINE / CODE 1994 MODEL YEAR PLANT
’ ASSEMBLY
I Vehicle Identification
Number
(VIN)
I’ Add-on Electrical
Equipment
NOTICE:
I
’his is the legal identifier for your
’ontiac. It appears on a plate in
the front
orner of the instrument panel,
on the
.river’s side. You can see it if you look
hrough the windshield from outside your ehicle. The VIN also appears on the
rehicle Certification and Service Parts
ibels and the certificates of title and
:gistration.
Engine Identification
The eighth character in your VIN is the
:ngine code. This code will help you
dentify your engine, specifications, and
eplacement parts.
Service Parts
Identijiication Label
You’ll find this label on your spare tire
cover. It’s very helpful
if you ever need to
order parts. On this label is:
0 your VIN,
0 the model designation,
0 paint information, and
a list of all production options and
special equipment.
Be sure that this label is not removed
from the vehicle.
Don’t add anything electrical to
your Pontiac unless you check with
your dealer first. Some electrical
equipment can damage your vehicle
and the damage wouldn’t be
covered by your warranty. Some
add-on electrical equipment can
keep other components from
working as they should.
Your vehicle has an air bag system.
Before attempting to add anything
electrical to your Pontiac, see “Servicing
Your Air Bag-Equipped Pontiac” in the
Index.
211 ...
ProCarManuals.com

IC
Fuse Usage
Fuse
PRNDL
F/P INJ
STOP HAZ
CTSY
AIR BAG
INST
LPS
GAUGES HORN
ALARM
HTR-A/C
RDO
TURN
DR LK
TAIL LPS
WDO WIPER
ERLS DR UNLK
FTP
ACC
AIR BAG
IGN ECM
HDLP
Rating
(AMP. )
5
20
20
15
3
5
10
15
15
25
10
20
20
20
30
25
15
10
20,
30
15
20
20
Circuitry
Electronic PRNDL Display
Fuel Pump, Injectors
Stop/Hazard Lamps
Door Locks, Power Mirrors, Cigar Lighter
Supplemental Restraint System
Interior Lights Dimming
Gauges, Warning Lights, Rear Defog
Horns
Interior Lights, Chime, Auto Door Locks, Remote Keyless Entry Heater, Air Conditioning, Anti-Lock Brakes, Daytime
Running Lights (Canada)
Radio Power, Cruise Control
Turn Signal Lamps
Auto Door Locks
Tail Lamps, Marker Lamps, License Lamp, Fog Lamps
Power Windows (Circuit Breaker)
Windshield Wipers/Washers
Engine Controls, Back-up Lamps
Automatic Door Unlock (Remove
To Disable)
Flash-to-pass
(U.S.)
Rear Window Defogger, Power Seats, Antenna
(Circuit Breaker)
Supplemental Restraint System
ECM, Ignition System
Headlamps (Circuit Breaker)
1
213 b
ProCarManuals.com

4quarts .........
4 quarts ......... 3.8 L
6 quarts ......... 5.5 L
Capacities & Specifications
Engine Crankcase (CODE M) ................................ 4 quarts ......... 3.8 L
When changing filter; up to /I3 quart (113 liter) more oil may he needed.
Engine Crankcase (CODE 3, D or A) ........................ . 3.8 L
When changing filter; up to 114 quart (114 liter) more oil may be needed.
Automatic Transaxle
Pan Removal and Replacement ...............................
After Complete Overhaul ....................................
When draining or ~-eplat*ing torque conl~erte~; more fluid may be needed.
Manual Transaxle, 5-Speed
Complete Drain and Refill
T5550 ................................................. 2.1 quarts ......... 2.0 L
Isuzu .................................................. 2.0quarts ......... 1.9 L
Cooling System
2.3L Quad OHC and Quad 4 ................................. 10.4 quarts ......... 9.8 L
3.1L V6 ................................................. 13.2 quarts. ......... 12.4 L
Refrigerant, Air Conditioning. ................................ This system uses a new non-CFC refrigerant.
Not all air conditioning refrigerants are the same. If the air See refrigerant charge label under hood.
conditioning system in your rvhic-le needs re$-igerant, he suse the
proper refrigerant is used. If you’re not sure, ask your Pontiac dealer,
For additional info)-mation, see your “Warranty and 0wwc.r
Assistance Information’’ hooklet.
215...
ProCarManuals.com

Engine Specifications
VIN Engine Code .........................
Type ...................................
Displacement ............................
Compression Ratio ........................
Firing Order .............................
Thermostat Temperature ...................
Quad
2.3L
OHC
3
L4
2.3
Liters
9.5: 1
1-3-4-2
195°F (91 "C)
Quad 4
2.3L
OHC
D
LA
2.3 Liters
9.5: 1
1-3-4-2
195°F (91 "C)
3.1L Quad 4
2.3L High
output
A M
L4 V6
2.3 Liters '3.1 Liters
10.0: 1 9.5: 1
1-3-4-2 1-2-3-4-5-6
195°F (91 "C) 195°F (91 "C)
ProCarManuals.com