1994 PONTIAC FIREBIRD maintenance

ITEM
NO. SERVICE
6 Transmission Service - For
manual transmissions, fluid
doesn’t require changing. See
“Periodic Maintenance
Inspections.”
For automatic transmissions,
change both the fluid and filter
every 15,000 miles
(25 000 km)
if the vehicle is mainly driven
under one
or more of these
conditions:
In heavy city traffic where the
outside temperature regularly
reaches
90°F (32°C) or
higher.
In hilly or mountainous
terrain.
When doing frequent trailer
towing.
Uses such as found in taxi,
police car or delivery service.
If you do not use your vehicle
under any of these conditions,
change both the fluid and
filter every
100,000 miles
(166 000 km).
ITEM
NO. SERVICE
7
8
9
10
Spark Plug Replacement* -
Replace spark plugs with the
proper type. See “Replacement
Parts” in the Index.
Spark Plug Wire InsPection*t
-
Inspect for burns, cracks or other
damage. Check the boot fit at the
distributor and at the spark plugs.
Replace wires as needed.
Air Cleaner Filter Replacement”
- Replace every 30,000 miles
(50 000 km) or more often under
dusty conditions. Ask your
dealer for the proper replacement
intervals for your driving
conditions.
Fuel Tank. Cap and Lines
Inspection*-/-
- Inspect fuel tank,
cap and lines (including fuel rails
and injection assembly) for
damage or leaks. Inspect fuel cap
gasket for an even filler neck
imprint or any damage. Replace
parts as needed. Periodic
replacement of the fuel filter is
not required.
ITEM
NO. SERVICE
11 Rear Axle Fluid Change - If your
vehicle is used to pull a trailer,
have the rear axle gear lubricant
changed every
7,500 miles
(12 500 km).
If your vehicle is not used to pull
a trailer, but has a limited-sli,p
differential, have the rear axle
gear lubricant changed once, after
the first
7,500 miles (12 500.h).
* An Emission Control Service.
j- The US. Environmental Protection Agency
or the California Air Resources Board has
determined that the failure to pe$orm this
maintenance item will not nullify the emission
warranty
or limit recall liability prior to the
completion
of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be performed at the
indicated intervals and the maintenance be
recorded in “Section E: Maintenance Record.”
247. . .
ProCarManuals.com

Maintenance Schedule
Section B: Owner Checks and Services
Listed below are owner checks and services which should be performed at the intervals specified to help ensure the saf\
ety,
dependability and emission control performance of your vehicle. Be sure any necessary repairs are completed at once.
Whenever any fluids or lubricants are added
to your vehicle, make sure they are the proper ones, as shown in Section D.
At Each Fuel Fill (It is important for you or a service station attendant to perform these underhood checks at each fuel fill.)
CHECK
OR SERVICE
Engine Oil Level
Engine Coolant Level
Windshield Washer
Fluid Level
At least Once a Month
WHAT TO DO
Check the engine oil level and add the proper oil if necessary. See “Engine Oil” in the Index for
further details.
Check the engine coolant level and add the proper coolant mix if necessary. See “Coolant” in
the Index for further details.
Check the windshield washer fluid level in the windshield washer tank and add the proper fluid if
necessary. See “Windshield Washer Fluid” in the Index for further details.
CHECK
OR SERVICE ~~
Tire Inflation
Cassette Deck
WHAT TO DO
Check tire inflation. Make sure they are inflated to the pressures specified on the Tire-Loading
Information label located on the rear edge of the driver’s door. See “Tires”
in the Index for
further details.
Clean cassette deck. Cleaning should be done every
15 hours of tape play. See “Audio Systems”
in the Index for further details.
I At Least Twice a Year ___ ~~~ ~ ~
CHECK
OR SERVICE WHAT TO DO
Hydraulic Clutch
loss in
this system could indicate a problem. Have the system inspected and repaired at once.
System Inspection Check
the fluid level
in the clutch reservoir. See “Hydraulic Clutch Fluid” in the Index. A fluid
. . .248
ProCarManuals.com

Maintenance Schedule
Section B: Owner Checks and Services (Cont.)
At least Once a Year (CONK)
CHECK
OR SERVICE
Steering Column Lock
Parking Brake and
Automatic Transmission “P” (Park) Mechanism
Check
Underbody Flushing
WHAT TO DO
While parked, and with the parking brake set, try to turn the key to “LOCK” in each shift lever
position.
With an automatic transmission, the key should turn to “LOCK” only when the shift lever is
0 With a manual transmission, the key should turn to “LOCK” only when the shift lever is in
On vehicles with a key release button, try to turn the key to “LOCK” without pressing the
button. The key should turn to “LOCK” only with the key button depressed. On all vehicles,
the kev should come out only in “LOCK.”
in
“P” (Park).
“R” (Reverse).
brake, set the parking brake.
0 To check the parhng brake: With the engine running and transmission in “N” (Neutral),
slowly remove foot pressure from the regular brake pedal.
Do this until the vehicle is held by
the parking brake only.
brakes.
0 To check the “P” (Park) mechanism’s holding ability: Shift to “P” (Park). Then release all
~~ ~
At least every spring, use plain water to flush any corrosive materials from the underbody. Take
care to clean thoroughly any areas where mud and other debris can collect.
. . .250
ProCarManuals.com

Section C: Periodic Maintenance Inspections
Listed below are inspections and services which should be performed at least twi\
ce a year (for instance, each spring and fall).
You should let your
GM dealer’s service department or other qualified service center do these jobs. Make sure any necessary
repairs are completed at once.
INSPECTION
I OR SERVICE
Restraint Systems
~ ~~~~
Steering and
Suspension Inspection
Exhaust System
Inspection
Inspection
WHAT SHOULD BE DONE
Now and then, make sure all your belts, buckles, latch plates, retractors, anchorages and
reminder systems are working properly. Look for any loose parts or damage. If you see anything
that might keep a restraint system from doing its job, have it repaired.
Inspect the front and rear suspension and steering system for damaged, loose or missing parts,
signs of wear, or lack of lubrication. Inspect the power steering lines and hoses for proper
hookup, binding, leaks, cracks, chafing, etc.
Inspect the complete exhaust system. Inspect the body near the \
exhaust system. Look for broken,
damaged, missing
or out-of-position parts as well as open seams, holes, loose connections or , ’;;
other conditions which could cause a heat build-up in the floor pan or could let exhaust fumes :~
into the vehicle. See “Engine Exhaust’’ in the Index.
Inspect the throttle linkage for interference or binding, and for damaged or missing parts.
Replace parts as needed.
251 . . .
ProCarManuals.com

Maintenance Schedule
Section C: Periodic Maintenance Inspections (Cont.)
I INSPECTION
F Manual Transmission
I
Rear Axle Service
Brake System
Inspection
WHAT SHOULD BE DONE
Check the transmission fluid level; add if needed. See “Manual Transmission” in the Index.
A fluid
loss may indicate a problem. Check the system and repair if needed.
Check the gear lubricant level in the rear axle and add if needed. See “Rear Axle” in the Index.
A fluid loss may indicate a problem. Check the axle and repai\
r it if needed.
If your vehicle
is used to pull a trailer, have the rear axle gear lubricant changed every
7,500 miles
(12 500 km).
Inspect the complete system. Inspect brake lines and hoses for \
proper hookup, binding, leaks,
cracks, chafing, etc. Inspect disc brake pads for wear and rotors for surface condition. Also
inspect drum brake linings for wear and cracks. Inspect other \
brake parts, including drums,
wheel cylinders, calipers, parking brake, etc. The parking brake\
is self-adjusting and no manual
adjustment is required. You may need to have your brakes inspected more often if your driving
habits or conditions result in frequent braking.
NOTE: A low brake fluid level can indicate worn disc brake pads which may need to be serv-
iced. Also, if the brake system warning light stays on or comes on, something may be wrong
with the brake system.
See “Brake System Warning Light” in the Index. If your anti-lock brake \
system warning light stays on, comes on or flashes, something may be wrong with the anti-lock
brake system. See “Anti-Lock Brake System Warning Light’’ in the Index.
~~
. . .252
ProCarManuals.com

Maintenance Schedule
Section D: Recommended Fluids & Lubricants (Cont.)
Floor Shift Linkage
Chassis Lubrication
Rear Axle
(Standard Differential)
Rear Axle (Limited-
Slip Differential)
Windshield Washer Solvent
Hood Latch Assembly
a. Pivots and Spring
b. Release Pawl Anchor
Hood and Door
Hinges, Headlight
Door Assemblies,
Rear Folding Seat,
Fuel Door Hinge,
Rear Compartment
Lid Hinges
Weatherstrips
I
FLUlDlLUBRlCANT
Engine oil.
Chassis lubricant (GM Part
No. 1052497 or equivalent) or lubricant meeting requirements of
NLGI Grade 2, Category LB or GC-LB.
Axle Lubricant (GM Part No. 1052271) or SAE 80W-90 GL-5 Gear Lubricant.
Axle Lubricant (GM Part
No. 12345977) or SAE 8OW-90 GL-5 Gear Lubricant, and Limited-
Slip Differential Lubricant Additive (GM Part
No. 1052358 or equivalent) where required. See
“Rear Axle” in the Index.
GM Optikleen@ Washer Solvent (GM Part No. 105
15 15 or equivalent).
a. Engine oil.
b. Chassis lubricant (GM Part
No. 1052497 or equivalent) or lubricant meeting requirements of
NLGI Grade 2, Category LB
or GC-LB.
Engine oil or Lubriplate Lubricant (GM Part
No. 1050109).
Dielectric Silicone Grease (GM Part
No. 12345579 or equivalent).
I See “Replacement Parts” in the Index for recommended replacement filters, valves and spark plugs.
. . .254
ProCarManuals.com

Section E: Maintenance Record
After the scheduled services are performed, record the date, odometer reading and who performed the service in the columns
indicated. When completing the Maintenance Performed column, inse\
rt the numbers from the Schedule
I or Schedule I1
maintenance charts which correspond to the maintenance performed. Also, you should retain all maintenance receipts. Your
owner information portfolio is a convenient place to store them.
DATE READING
ODOMETER SERVIC~D BY MAINTENANCE PERFORMED
255.. .
ProCarManuals.com

Maintenance Schedule
Section E: Maintenance Record (Cont.) V
. . .256
ProCarManuals.com