1994 MAZDA MX-5 key

K SHIFT MECHANISM (WITH SHIFT-LOCK SYSTEM) POSSIBLE TO SHIFT BRAKEPEDAL DEPRESSED P RANGE POSSIBLE TO TURN IN LOCK POSITION I Shift-lock System Operation Inspection Shift-lock system 1. Turn the ignition switch ON, engine OFF 2. Verify that the selector lever is in P range. u 3. Without the brake pedal depressed, verify that the selec- tor lever cannot be shifted from P range. 4. Depress the brake pedal. Verify that the selector lever can be shifted from P range. 5. Shift the selector lever to R range. 6. Verify that the ignition key cannot be turned to the LOCK position. 7. Shift the selector lever to P range. 8. Verify that the ignition key can be turned to the LOCK position. 9. If not as specified, inspect and repair as necessary, re- ferring to "Troubleshooting". Emergency override button 1. Verify that the engine is off. 2. Verify that the selector is locked in P range. 3. Remove the indicator panel cover with the screwdriver as shown. 4. Insert the screwdriver into the emergency override hole, ,, push down, and verify that the selector lever can be shifted from P range. 5. If not as specified, inspect and repair as necessary, re- ferring to "Troubleshooting". Gartner Banana

MANUAL STEERING , N Removal / Installation 1. Disconnect the negative battery cable. 2. Remove in the order shown in the figure, referring to Removal Note. ,, 3. Inspect all parts and repair or replace as necessary. 4. Install in the reverse order of removal. 5. Tighten all necessary nuts and bolts to the specified torque. 6. After installation, check if the horn sounds. If the horn does not sound, remove the air bag module and connect the module connectors. (Refer to section T.) 1. Air bag module 6. Lower panel Removal 1 Installation .......... section T 7. Key interlock cable (Automatic transmission) 2. Locknut 8. Intermediate shaft bolt 3. Steering wheel 9. Steering shaft w ............... Removal Note page N-10 Disassembly 1 Inspection / 4. Column cover Assembly .................. page N-10 5. Combination switch Removal / Installation .......... section T Gartner Banana

P ANTILOCK BRAKE SYSTEM (ABS) Troubleshooting procedure 2. ALTEnuAtOR TEST START mtmE (ALTWJATOR TESTED BY RWNa ENQlNE) 3. A88 SYSTEM TEST TURN IGNITION K€Y ON (00 NOT ROES EWWE) - - 1. LOCATE ABS CONTROL UNIT. 2. DISCONNECT CONTROL UNlT HARNESS CONNECTOR FROM CONTROL UNIT. 3. CONNECT ABS TESTER HARNESS TO CONTROL UNlT HARNESS CON- NECTOR. 4. TURN IGNITION KEY TO ON POSITION. TESTER WlLL RAPIDLY DISPLAY SEVERAL MESSAGES DURING AN INITIAL SEGMENT CHECK I THEN 1 I MAZDA ABS 2 TEST 1 4 I YES ENG RUN? NO 1 I MAZDA ALT TEST I CHK ALTERNATOR NO FAULT DETECTED t I TURN OFF ENGINE I TESTER WlLL RAPIDLY DISPLAY SEVERAL MESSAGES DURING AN INITIAL SEGMENT CHECK. I THEN t 1 YES ENG RUN? NO t 1 MAZDA ABS 2 TEST I Gartner Banana

DOOR LOCK AND OPENER s DOOR LOCK AND OPENER COMPONENTS Removal 1 lnstallation 1. Raise the door glass fully. 2. Disconnect the negative battery cable. Note Remove the door screen carefully so that it may be reused. 3. Remove in the order shown in the figure, referring Removal Note. 4. Install in the reverse order of removal, referring Installation Note. 1. Regulator handle 5. Inner handle Removal Note ............. page S-10 6. Sealing pad Installation Note ........... page S-10 7. Door screen - 2. Inner handle cover 8. Door lock assembly 3. Pull handle 9. Outer handle 4. Door trim 10. Key cylinder Removal Note ............. page S-61 Gartner Banana

s TRUNK LID LOCK AND OPENER TRUNK LID LOCK AND OPENER COMPONENTS Removal / Installation 1. Remove in the order shown in the figure. 2. Install in the reverse order of removal. Rear console 6. Rear combination light .................... Removal 1 Installation ....... page S-56 Removal Section T Opener lever 7. Rear finisher ............. Opener cable Removal Note page S-28 4. Trunk end trim 8. Key cylinder 5. Trunk lid lock assembly 9. Striker ..................... Adjustment below Adjustment Trunk lid lock assembly Verify that the trunk lid can be closed easily and that there is no looseness. If necessary, loosen the lock assembly mounting bolts and adjust the lock assembly. Gartner Banana

FUSE SPECIFICATIONS Main Fuse Block u I Fuse Amperes Protected circuit HEAD INJ MAIN BTN 30A 30A COOLING FAN (AD FAN) 1 ABS I 60A I Antilock brake svstem I Headlight relay, Headlight switch Alternator, Diagnostic module (for air bag system) 80A 40A ST SIG RETRACTOR Fuse Box No.1 Except circuits protected in main fuse block: INJ 30A, HEAD 30A, RETRACTOR 30A TNS relay, Headlight switch 30A 20A EGI main relay, Coolant fan relay A/C relay 10A 30A Park l Neutral switch, Circuit-opening relay Retractable headlight actuator Fuse ENGINE METER (POWER WIND) Amperes 15A WIPER TAIL ROOM I 10A I PCME, Key reminder switch, Audio unit I Protected circuit EGI main relay, Coolant fan relay 15A 30A STOP HAZARD CIGAR 15A I Cigarette lighter, Audio unit 1 Instrument cluster, Turn signal switch, Timer and buzzer unit, Cruise control main switch Power window switch 20A 15A Fuse Box No.2 Blower switch, Wiper switch Taillights, Side marker lights, License plate lights, Parking lights 15A 15A Fuse Amperes Protected circuit I Stoplight switch, Horn switch, Cruise control unit Flasher unit Fuse Color Code (DEFOG) (ANTENNA) I Fuse amperes I Color code Fuse type 25UOTX-013 20A 20A I I 10A Red 1 I Rear window defroster Power antenna Plate type 15A 20A Light blue Yellow 30A 30A 80A Light green Pink Black Cartridge type Gartner Banana

SECT ION NAME INDEX (my) - LO a NO * - ... - a 2-C03 2-E03 2-H03 2-403 2-KO3 2-1.03 2-CO4 2-E04 2-H04 2-104 2- JOG ?-KO4 2-M04 ?-NO4 9-CO4 ?-LO5 2-8 0% ?-KO5 ?-NO!, 7-CO6 ?*C47 i?-107 ?*f-d7 ?-GO I ?- 109 ,!-LO I Z-catj il- t. 0 a 2 .. f' fl g4 ?-GO9 ;,. JO9 ?-MQY ? il'j ? CII --- - - SEC .#I ---..- 0900 5000 5910 8030 5100 5103 $105 5110 5120 5170 5180 5230 5260 5310 5520 5539 5340 5370 5580 53 YO 5500 5570 55.10 5!>40 5560 55 "0 5588 5 IOU 5790 '; 19'. 5flOti !,bSB !J n c* u LlbIJ . ---..- - - --- SECfION NAME -----.- ------------------ ..--- KEY SETS FRONT BUNPER REAR EUHPER WINDOW HOULDING L COWL GRILLES HEAD LANPS HEAD LAHP RE T RACY ORS FRONT CONBINITION Lanes REAR COHBINATIOH LAHPS L ALENSE LAHPS BRNAMM3S REAR FIWISWER BONNET TRUNK LIB FWDNT PANELS FEIiDER P WHEEL APRON PANELS 3PCU L COWL PANELS SiUE PANELS {'!.OUR PANELS, FLCOR AYTACWHEHTS (HDCC GOVEAS 1 FLOOR AVYACHHEHTS DASHEOARD EOU IPMENI 5 nf VCR NttUD SPEEDOM TCW CADI.[; nt 1 ER CONPONE ws DASHBOAKU 6 WI LATLb PAKl S COHSOLC. VLUTILATOSI St.AI'S %CAI IC'ITS AIR OhC FblOlil li00k'$ F WLlh 'l !WOH Wt't:NAN I TUUHI 1)ouu IHlnS 1 WELAICL, PAW 1s - SEC * N( -----a 6110 6115 6 120 6130 6160 6190 6300 6330 6600 6610 661 1 6638 6635 6640 6600 6662 670U &7C 1 6707 6703 6784 6 ?i!U 6720 1 6730 6 760 ba20 6140 ~uen tB1U bVQU SECTION NAHE HEATER UNIT COMPONENTS HEATER CONTROLS COMPONENTS HEATER BL OWER COHPONENT S AIR CONDITIONER COMPRESSOR COHFONENTS (AIR CON DIT JlrNEiO COOLING UI\'TS (AIR COHDITIOHEW) WINDOW GLASSES SUNROOF SWITCHES C RFtAVS (ENGINE) DASHBOARD SWlTCHES COHBINATIOM SWITCH RELAYS L UNIT (BODY) DOOR SWITCH & HDRWS AUTO CRUISE CONTROL SYSTEH AUDIO SYSTEMS (RADIO & TAPE W. CK 1 AUDIO SYSTFffS (ANTENNA 6 SPEAK El?) NIP t He HARNESSES(FRON1 L REAR ) WlW iNG HARNESS CL.AHPS UtHaSH1EL.D W4SHER ANT1 LJCI BRAKE SYSTEH) WIHDSHIELU WASHER (AH71 LOCK BRAKE SYSTEM) UINUSHIELD WIPERS FRONT hEAD$Y TWIN & PIMY TRl n s FLOOR HATS L PAW QUARTER WINDOW L VRIHS LA I L Olr HI).. AUHAOd* I1 3 Gartner Banana

SECTION NAME KEY SETS FRONT BUHPER REAR SUNPER WINDOW rlOULBIHG L COWL GRILLES HEAD LAMPS IIEAD LAHP RE 1 RACTORS FRONT COHBINATION LAWS REAR CUHBlNATIOH LAHPS L ICE HOE LAWS ORNhHENTS REAR F f Hf Ci+CR BONNET TRUNK 110 f RWT PANEL S FLHOEW & WHfkL APWOt4 P4NkL!$ LUSH & COWL PANELS SIDE PANELS FLOOR PANELS F LOOR ATTACHHENTS (HOLE COVERS ) HkTER HOOD SCf 600NC TCH CAB1.k RC 1 ER COMPONENTS SECTION nAnE ---------_L---_-----__________L_______I__________________L_______I__________________L_______I________-__________L_______I__________________L_______I__________________L_______I________ HEAI'ER Wit COMPONENTS HEATER CONTROLS COHPONENf S HEATER BLOWER COWPONENTS AIR CONBlTXOMR COHPRESSOR COHPONENTS (AIR CDh DITIONER) COOLING UNIT (AIR CO#DlTZONERI WINDOW GLASSES SUNRtOF SWiTCMES L RELAvC (ENGINE) DASMIOAWD SWITCHES CO~bfNAI~OH SWlfCiI RELAYS L UNIT i8OBV) DOOR SWITCH L HORNS AUTO CRUISE CONTROL C't SIGH AUDIO SYSTEHS (ANTENNA C WEAK ER MIWBSH2El.D YASHCK (U/U ANTI LUCI MAKC SYSICI) 7250 QUARTER WINCOW L TRIHS Gartner Banana