1994 GMC SIERRA steering

Explanation Of Scheduled Mainienance Services
Below are explanations of the services listed in the maintenance charts.
The proper fluids and lubricants to use are listed in this section. Make sure
whoever services your vehicle uses these. All parts should be replaced and
all necessary repairs done before you or anyone else drives the vehicle.
1. ENGINE OIL AND OIL FILTER CHANGE“‘ - ALWAYS USE
SJ3 ENERGY CONSERVING I1 (GASOLINE ENGINE) OR CF-4/SH
(DIESEL ENGINE) QUALITY OILS
OF THE PROPER VISCOSITY.
To determine the preferred viscosity oil for your vehicle’s engine (e.g.
SAE 5W-30 or 10W-30), see “Engine Oil”
in the Index.
2. CHASSIS LUBRICATION - Lubricate the front suspension, king
pin bushings, steering linkage, transmission, and transfer case shift
linkage, parking brake cable guides, rear driveline center splines and
front axle propshaft splines, brake pedal springs, and clutch pedal
springs at the intervals specified.
If you have a 3500
HD, lubricate the king pins and king pin bushings,
every
1,500 miles (2500 km) for Maintenance Schedule I, or every
3,000 (5000 km) for Maintenance Schedule 11.
Ball joints and king pin bushings should not be lubricated unless their
temperature
is 10” F (-12”C), or higher. When the weather is cold, let
them warm up before lubrication or
they could be damaged.
Also, be sure
to check all the vehicle fluid levels at this time.
3.
CLUTCH FORK BALL STUD LUBRICATION (5-SPEED
MANUAL TRANSMISSION WITH DEEP LOW
) - Lubricate the
clutch fork ball stud through the fitting
on the clutch housing.
Lubricant must be added “sparingly” to
the fitting, as only .0066 lb.
(.003 kg) is required to lubricate the ball stud surface. Do not add
lubricant more often than the intervals
in the Maintenance Charts. Too
much lubricant will damage the clutch assembly.
4. COOLING SYSTEM SERVICE”’? - Drain, flush and refill system
with new coolant. See “Engine Coolant” in the Index for
the proper
coolant and mixture to use
in your vehicle.
Also inspect the hoses and replace them
if they are cracked, swollen, or
deteriorated. Tighten all hose clamps (except constant tension clamps).
Remove debris and clean the outside of the radiator and air
conditioning condenser. Wash the radiator neck.
To ensure proper
operation, pressure test.
the radiator and cap.
* An Emission Control Service
?A fluid
loss in these systems may indicate a problem. Have them
inspected and repaired at once.
7-18
ProCarManuals.com

Owner Checks and Services
Listed below are owner checks and services which should be made at the
time period specified to help ensure proper safety, emission performance,
and dependability
of your vehicle.
Be sure any necessary repairs are completed at once. Whenever any fluids
or lubricants are added to your vehicle, make sure they are
the proper ones,
as shown
in this Section.
At Least Once a Month
Tire inflation pressure check - Check the tires for proper inflation. If
they are low, inflate them to the level specified on the Certification/Tire
label. See “Loading Your Vehicle” or “Inflation-Tire Pressure”
in the Index.
At Least Once a Year
Key lock cylinder lubrication - Lubricate key lock cylinders with engine
oil. See
the “Recommended Fluid and Lubricants” chart in this section.
Transmission neutral or clutch start switch operation -
1. Before you start, be sure you have enough room around the vehicle.
2. Firmly apply both the manual parking brake and the regular brake. See
“Brakes” and “Parking Brake”
in the Index. Do not use the accelerator
pedal.
3. Be ready to turn off the engine immediately if it starts.
4. On automatic transmission vehicles, try to start the engine in each gear.
The starter should work only
in “P’ (Park) or “N” (Neutral).
On manual transmission vehicles, put the shift lever
in “N” (Neutral), push
the clutch down halfway, and try to start the engine. The starter should work
only when the clutch
is pushed down all the way to the floor.
Steering column lock operation - While parked, try to turn the key to
LOCK in each gear shift position.
With an automatic transmission, the key should
turn to LOCK only when
the gear shift
is in “P” (Park).
7-23
ProCarManuals.com

Steering and Suspension Inspection? - Inspect front and rear suspension
and steering system for damaged, loose
or missing parts, signs of wear or
lack
of lubrication. Inspect power steering lines and hoses for proper
hook-up, binding, leaks, cracks, chafing, etc. Lubricate the steering linkage.
Accelerator Control System - On gasoline engines, lubricate the pivot at
the
TBI throttle lever stud with engine oil. Do not oil any accelerator or
cruise control cables. Replace any cables that have high effort
or excessive
wear.
Exhaust System Inspection - Inspect the complete system including the
three-way catalytic converter. Inspect the body near the exhaust system.
Look for broken, damaged, missing or out-of-position parts,
as well as,
open seams, holes, loose connections or other conditions which could cause
a heat buildup in
the floor pan or could let exhaust fumes seep into the
passenger compartments.
Drive Axle Service? - Check readfront axle fluid level and add as needed.
Check constant velocity joints and axle seals for leaking.
I-- ~ lsfer Case (Four-wheel Drive) Inspection? - Every 12 months or at
oil change intervals, check front axle and transfer case and add lubricant
when necessary. Oil the control lever pivot point and all exposed control
linkage. Check vent hose at transfer case for kinks and proper installation.
More frequent lubrication may be required
on heavy-duty or off-road use.
?'A fluid loss in these systems may indicate a problem. Have them inspected
and repaired at once.
7-25
ProCarManuals.com

Recommended Fluids & Lubricants
NOTE: Fluids and lubricants identified below by name, part number or
specification may be obtained from your GM Dealer.
USAGE
Engine Oil - Gasoline
Engines
Engine
Oil - Diesel Engines
Engine Coolant
Hydraulic Clutch System
Hydraulic Brake Systems
Parking Brake Cables
Power Steering System
Automatic Transmission
FLUIDLUBRICANT
API service SH or SG Energy
Conserving I1 oils
of the recommended
viscosity. The
“SH” designation may be
shown alone or
in combination with
others, such
as “SH/CD,” “SH, SG,
CD,”“SG/CD,” etc. To determine the
preferred viscosity for your vehicle’s
engine, see “Engine Oil” in the Index.
API service CF4SH. The
“CF4SH”
designation may be shown alone or in
combination
with others, such as
“CF-4/SG,” “CE/SH” or “CE/SG,” etc.
The designation may
also be listed in
reverse order, such
as “SH/CF-4.” To
determine the preferred viscosity for
your vehicle’s engine, see “Engine Oil”
in the Index.
Mixture
of water and a good quality
ethylene glycol base antifreeze
conforming
to “GM Specification
6038-M” (GM Part No. 1052753)’ or
approved recycled coolant conforming to
“GM Specification
603%”’ with a
complete coolant flush and refill.
Hydraulic Clutch Fluid (GM Part No.
I2345347 or equivalent).
Delco Supreme
11 @ brake fluid (GM
Part No.
1052535 or equivalent DOT-3
brake fluid).
Chassis Lubricant (GM Part No.
I2346003 or equivalent) or lubricant
meeting requirements of NLGI Grade
2,
Category LB or GC-LB.
GM Power Steering Fluid (GM Part
No. 1050017 or equivalent) conforming
to
“GM Specification 99850 10.”
DEXRON~ 111 or DEXRON~ IIE
Automatic Transmission Fluid.
7-26
ProCarManuals.com

F
FanNoise ...................................................... 5-25
Filter Replacement Chart
.......................................... 6-94
Finish Care
........................................................ 6-85
Damage
..................................................... 6-86
Automatic Transmission
........................................ 6-30
Brake
....................................................... 647
Coolant
..................................................... 5-17
Capacities .............................................. 6-92, 6-93
FrontAxle
................................................... 6-37
Hydraulicclutch
.............................................. 6-35
LeakCheck
............................................. 6-47. 6-51
ManualTransmission .......................................... 6-33
Power Steering
............................................... 6-43
Radiator
..................................................... 5-17
Rear Axle ................................................... 6-39
Recommended Fluids
.......................................... 7-25
Transfer Case
................................................ 6-36
Windshield Washer
............................................ 6-45
Four-WheelDrive ............................................... 244
Transfer Case
........................................... 2-35, 6-36
Front Axle ................................................... 6-37
Fuel (Diesel Engines)
............................................. 6-11
Cold Weather Operation ......................................... 6-6
Filter Replacement ............................................ 6-11
Fuel Requirements ............................................. 6-4
Gage
....................................................... 2-78
RunningOutOf
.............................................. 6-10
Tankcapacity ................................................ 6-93
WaterinFuel
................................................. 2-71
Fuel (Gasoline Engines)
............................................ 6-4
FillingYourTank
............................................. 6-13
Foreign Countries
............................................. 6-12
Gage
....................................................... 2-78
Gasolines for Cleaner Air
........................................ 6-5
Tankcapacity
................................................ 6-93
Fuses and Circuit Breakers
................................... 6-64. 6-96
FuseBlock ............................................. 6-63, 6-95
Headlights
.............................................. 6-62-6-97
Trailer Wiring Harness
......................................... 6-62
Windshield Wipers
....................................... 6-45, 6-96
Fluid
Power Windows and Other
Power Options ......................... 6-62
Gages ......................................................... 2-78
Coolant Temperature Gage
...................................... 2-79
FuelGage
................................................... 2-78
Odometer
................................................... 2-68
Oil Pressure Gage ............................................. 2-80
Speedometer
................................................. 2-68
4
ProCarManuals.com

L
Labels Certificatioflire
.............................................. 6-65
Truck-Camper
............................................... 6-68
Lights
......................................................... 2-70
BrakeSystemWarning
......................................... 2-70
Bulb Replacement
................................... 2-52.6-53. 6-98
Cargo Lamp
............................................ 2.58. 6.60
Charging System Light
......................................... 2-73
Check Gages Light
............................................ 2-75
CHMSL
..................................................... 2-82
DomeLights
................................................. 2-51
Fender
...................................................... 6-58
Front Parking/Turn Signal
....................................... 6-55
GlowPlugsLight
............................................. 2-72
Headlights (See “Headlights”)
Indicator
.................................................... 2-77
Low Coolant Warning
.......................................... 2-73
Malfunction Indicator
..................................... 2.74. 6.66
Reading
..................................................... 2-51
Service Engine
Soon ........................................... 2-74
Service Throttle Soon
.......................................... 2-72
SideMarker
.................................................. 6-58
Rear .................................................... 6-60. 6-61
Replacementchart
............................................ 6-98
RoofMarker
................................................. 6-59
TailgateMarker
................................................ 6-59
Underhood Reel Lamp
......................................... 2-53
WaterInFuel
................................................. 2-71
LoadingYourVehicle
............................................ 6-65
Lubrication
..................................................... 6-51
Accelerator Control System
..................................... 6-51
Body
....................................................... 6-51
Constant Velocity Joints
........................................ 6-51
FrontAxle
................................................... 6-37
Front Shock Absorbers
......................................... 6-49
Front Suspension and Steering Linkage
............................ 6-49
FrontWheelBearings
.......................................... 6-49
TailgateHandle
............................................... 6-52
Hood Latches and Hinge ........................................ 6-51
Hydraulic Clutch Grease Fitting
.................................. 6-35
Lockcylinders
............................................... 6-52
Propeller Shaft Slip Splines
..................................... 6-51
RearAxle ................................................... 6-35
Recommended Lubricants
...................................... 7-25
Transfer Case
................................................ 6-36
Operation
................................................... 249
6
ProCarManuals.com

Power DoorLocks
................................................... 2-6
Steering
...................................................... 4-8
Steering Fluid ................................................ 6-43
Winches ..................................................... 4-36
Power Take-Off (PTO) ........................................... 4-37
Product Service Publications
........................................ 8-6
Radiator Pressure Cap
............................................ 6-42
Radio (see “Audio Systems”)
Recommended Fluids and Lubricants
................................ 7-25
Replacement Parts ............................................... 6-91
Reporting Safety Defects ........................................... 8-5
Roadside Assistance ............................................... 8-5
RockingYourVehicle ............................................ 5-41
Recovery Hooks ................................................. 5-41
Safety Belts
.................................................... 1-10
Adults ...................................................... 1-15
Center Passenger Position ....................................... 1-24
Cleaning
.................................................... 6-84
Checking Restraint System ......................................
Child Restraints ...............................................
Children ....................................................
DriverPosition ...............................................
Extender ....................................................
Lapshoulder .................................................
Large Children ...............................................
Properwear .................................................
Questions and Answers .........................................
Rearseatpassengers ...........................................
ReminderLight ...............................................
Right Front Passenger Position ...................................
Small Children and Babies ......................................
Use During Pregnancy .........................................
SafetyChains ...................................................
Replacing After a Crash ........................................
WhyTheyWork ..............................................
144
1-32
1-30
1-16
1-43
1-16
1-41
1-15
1-14
1-25
1-15
1-44
1-23
1-30
1-23
1-11
4-41
Safety Warnings and Symbols ........................................ vi
Scheduled Maintenance Services
..................................... 7-3
Seats
Controls
...................................................... 1-2
Easy Entry Seat ................................................ 1-6
Latches
.................................................. 1-5, 1-9
ManualFront .................................................. 1-2
PowerDriver’s
................................................ 1-3
Rear ......................................................... 1-8
Reclining ..................................................... 1-3
8
ProCarManuals.com

I
Service Do-It-Yourself
.......
Parts Identification Label
Publications
..........
Replacement Parts and Fj
Service Engine Soon Light
Service Station Checks
....
11
........................................ 6-3
....................................... 6-90
.................................... 8.6, 8.8
ter Recommendations
..................... 6-94
.................................. 2.74. 6-65
....................................... 7-28
Shift Indicator Light
......................................... 2.26, 2.76
ShiftingIntoPark
................................................ 2-30
Sliding Rear Window
............................................. 2-38
SpareTire
...................................................... 5-29
Pickup Bed Mounting
..................................... 5.31. 5-40
Specification Charts .............................................. 6-91
Speedometer
.................................................... 2-68
Starting your Diesel Engine
........................................ 2-16
Starting your Gasoline Engine
...................................... 2-12
Removal
.................................................... 5-29
Storage
..................................................... 5-39
Steering
........................................................ 4-8
Column Shift Lever
............................................ 2-30
InEmergencies
................................................ 4-9
Console
................................................ 2-59. 2-61
GarageDoorOpener
........................................... 2-61
GloveBox
................................................... 2-58
Other
....................................................... 2-65
SunVisors
..................................................... 2-55
Swing-Outwindows
............................................. 2-38
Storage Compartments
............................................ 2-58
T
Tachometer ..................................................... 2-69
Tailgate
......................................................... 2-8
Theft
........................................................... 2-9
Tiltwheel
...................................................... 2-39
Tires
.......................................................... 6-71
Chains
...................................................... 6-79
Flat
........................................................ 5-26
Balancing
................................................... 6-78
Changing a Flat
.......................................... 5.25, 5.32
Hub CapsNVheel Nut Caps
...................................... 5-32
InspectionRotation
....................................... 6-73. 6-75
Loading
..................................................... 2-39
New
........................................................ 6-76
Pressure
..................................................... 6-71
Spare (See “Spare Tire”)
Underbodycarrier
............................................ 5-29
Uniform Tire Quality Grading
................................... 6-77
TorqueLock
............................................... 2.29. 2.31
Towing
ATrailer
............................................... 4-38. 6.67
Maintenance
................................................. 4-44
Recommendations
............................................. 6-70
Turnsignals
................................................. 4-42
Following Distance
............................................ 4-42
9
ProCarManuals.com