1994 CHEVROLET CAMARO oil filter

Downloaded from www.Manualslib.com manuals search engine When to Change Engine Oil:
See if any one of these is true for you:
0 Most trips are less than 4 miles
(6 km).
It’s below freezing outside and most
trips are less than
10 miles (1 6 km).
The engine is at low speed most of the
time (as in door-to-door delivery, or
in
stop-and-go traffic).
0 You tow a trailer often.
@ Most trips are through dusty places.
If any one
of these is true for your
vehiclej
then you need to change your oil
and filter every 3,000 miles (5 000 km) or
3 months - whichever comes first.
If none of them is true, change the oil
every
7,500 miles (12 500 km) or 12
months - whichever comes first. Change
the filter at the first oil change and at
every other oil change after that.
Engine Coolant Heater (Engine Block
Heater):
An engine coolant heater can be a big
help
if you have to park outside in very
cold weather,
0” F (- 18 “C) or colder. If
your vehicle has this option, see “Engine
Coolant Heater”
in the Index.
What to Do with Used Oil:
Did you know that used engine oil
contains elements that may be unhealthy
for your skin and could even cause
cancer? Don’t let used oil stay on your
skin for very long. Clean your skin and
nails with soap and water, or a good hand
cleaner. Wash or properly throw away
clothing or rags containing used engine
oil. (See the manufacturer’s warnings
about the use and disposal
of oil
products.)
Used oil can be a real threat to the
environment. If
you change your own oil,
be sure to drain all free-flowing oil from
the filter before disposal. Don’t ever
dispose of oil by putting it in the trash,
pouring
it on the ground, into sewers, or
into streams
or bodies of water. Instead,
recycle it by taking it to a place that
collects used oil. If you have a problem
properly disposing of your used oil, ask
your dealer, a service station or a local
recycling center for help.
3.4L L32 (Code S
air Cleaner
tefer to the Maintenance Schedule to
letermine when
to replace the air filter.
;ee “Scheduled Maintenance Services” ir
he Index.
191 ...

Downloaded from www.Manualslib.com manuals search engine Replacement Parts
AirCleanerFilter .............................................. A1163C
Battery
........................................................ 75-60
Engine Oil Filter
VINEngineCodeS
............................................. PF47
VIN Engine Code
P ............................................. PF25
FuelFilter
...................................................... GF578
PCV Valve VIN Engine Code
S .......................................... CV789C
VIN Engine Code
P .......................................... CV895C
VIN Engine Code S .............................. oR43TSK (0.045" Gap)
VIN Engine Code P
............................. oR45LTSP (0.050" Gap)
Thermostat Temperature Specification
......................... 180" F (82" C)
Wheel
Nut Torque ................................... 100 Ib. ft. (140 Nom)
Radiatorcap ................................................... RC24
Spark Plug
Wheel Nuts
233. ..

Downloaded from www.Manualslib.com manuals search engine Crankcase
VIN Engine Code S .................................... 4.0 qt. (3.8 L)**
Without Filter Change
................................ 4.0 qt. (3.8 L)**
With Filter Change
................................... 5.0 qt. (4.7 L)**
Fuel Tank ........................................... 15.5 gal. (58.7 L)
Five-Speed
........................................... 5.9 pt. (2.8 L)*
Six-Speed
........................................... 8.0 pt. (3.8 L)*
Rear Axle Lubricant
........................................ 3.5 pt. (1.7L)
VIN Engine Code P
Manual Transmission
Vehicle Dimensions
Tread Wheelbase
........................................... 101.1 ‘I (2 566 mm)
Front
.............................................. .60.7 ‘I (1 542 mm)
Length
.............................................. 193.2” (4 908 mm)
Coupe
............................................. 5 1.3“ (1 303 mm)
Convertible
......................................... .52.0” (1 3 12 mm)
Rear ............................................... .60.6“ (1 540 mm)
Width
............................................... 74.1 ‘I (1 883.mm)
Height
*Recheck fluid level after filling. See “Automatic Transmission Fluid” or “Manual Transmission Fluid” in the Index.
**Recheck the oil level after filling. See “Engine Oil” in the Index.
235. ..

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services
Schedule 1
MAINLY driven under one or more of
the following conditions:
When most trips are less than 4 miles
(6 km).
When most trips are less than 10 miles
(16 km) and outside temperatures
remain below freezing.
When most trips include extended
idling and/or frequent low-speed
operation, as
in stop-and-go traffic.
When towing a trailer.
0 When operating in dusty areas.
Schedule
I should also be followed if the
vehicle is used for deliverv service, police,
taxi or other commercial applications.
* An Emission Control Service.
=t The U.S. En\sironmental Protection Agency
or the California Air Resources Board has
determined that the failure to pellform this
maintemnce item will not
nullifi. the emission
warranty
or limit recall liability prior to the
cvmpletion
cf vehicle usejul life. General
Motors, however, urges rhat all rec.*ornmended
maintenance services
he performed at the
indicated intervals and the maintenance be
recorded in “Section
E: Maintenance Record.”
ITEM NO.
-
1
2
3
4
5
6
7
8 -
9
10
11
WHAT TO SERVICE
See “E,rplanation of Scheduled
Maintenunce Servicae.s”
jullowing
Schedules I and 11.
Engine Oil & Oil Filter Change*
Chassis Lubrication
Tire and Wheel Rotation
& Inspection
Engine Accessory Drive Belt(s) Inspection*
Cooling System Service”
Transmission Service Spark Plug Replacement
(3.4L L32 (Code
S) Engine)*
Spark Plug Replacement
(5.7L LTI (Code P) Engine)*
Spark Plug Wire Inspection*+
Air Cleaner Filter Replacement*
Fuel Tank, Cap & Lines Inspection*?
Rear Axle Fluid Change
(For Vehicles
Towing Trailers
or for Vehicles with
Limited-Slip Differentials)
WHEN TO PERFORM
Miles (kilometers) or Months
(whichever occursfirst).
Every 3.000 miles (5 000 km) or 3 months.
Every other oil chenge.
At 6,000 miles (10 000 km) and every
15,000 miles (25 000 km) or as necessary.
Every 30,000 miles (50
000 km) or 24 months.
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
Every 30,000 miles (50 000 km).
Every 100,000 miles ( 166 000 km).
Every 30,000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and II.
Every 30,000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
. . .240

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services (cont.)
Schedule 11
Follow Schedule I1 ONLY if none of
Jhe driving: conditions specified in
Schedule I appl~
* An Emission Contsol Ses\:icc.
il- The US. Envisonmental Psotection Agency
os the Calijosrtia Ais Resousces Bousd has
detesmined that
the failuse to pesfosm this
maintenance item will not nullib the emissiott
warsanty
or limit secall liability psios to the
completion of whicle useful life. Genesal
Motoss, howews, urges that all sccommended
maintenance semices
be pesformed at the
indicated inten*als and
rhe maintenance he
secorded in “Section E: Maintenance Record.”
ITEM NO.
1
-
2
3
-
4
5
6
-
-
-
7
-
8
9
-
10
11
WHAT TO SERVICE
“E.vplanutiol? c?fSd~eduleci
Mairztetzuncx~ Ses\.ic*es‘’ fhllolz*itlg
Schedules I Ulld !I.
Engine Oil Change”
Oil Filter Change*
Chassis Lubrication
Tire and Wheel Rotation
& Inspection
Engine Accessory Drive Belt(s) Inspection”
Cooling System Service”
Transmission Service Spark Plug Replacement
(3.4L L32 (Code S) Engine)”
Spark Plug Replacement
(5.7L LTI (Code P) Engine)*
Spark
Plug Wire Inspection”?
Air Cleaner Filter Replacement”
Fuel Tank, Cap & Lines Inspection’k+
Rear Axle Fluid Change (For Vehicles
with Limited-Slip Differentials) Every
7,500 miles (1 2 500
km) or 12 months.
At first and then every other oil chqnge.
Every 7,500 miles
( 12 SO0 km) or 12 months.
At 7.500 miles (1 2 SO0 km) and then every
15.000 miles
(25 000 km) or as necessary.
Every 30.000 miles
(50 000 km) or 24 months.
See “Explanation of Scheduled Maintenance
Services“ following Schedules
I and 11.
Every 30,000 miles (SO 000 km).
Every IOO.OOO miles ( 166 000 km).
Every 30,000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
Every 30.000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” lollowing Schedules
I and 11.
. . .242

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services (cont.)
Explanation of Scheduled
Maintenance Services
Following are explanations of the services
listed in Schedule
I and Schedule 11.
The proper fluids and lubricants to use are
listed
in Section D. Make sure whoever
services your vehicle uses these. All parts
should be replaced and all necessary
repairs done before you or anyone else
drives the vehicle.
NOTE: To determine your engine’s
displacement and code, see
“Engine Identification”
in the
Index.
ITEM
NO. SERVICE
1 Engine Oil and Filter Change” -
Always use SH or SG Energy
Conserving I1 oils of proper
viscosity. The
“SH” or “SG”
designation may be shown alone
or
in combination with others,
such as “SH/CD,”
“SH, SG,
CD,” “SG/CD,” etc. To deter-
mine the preferred viscosity for
your vehicle’s engine (e.g., SAE
ITEM
NO.
2
3
4
SERVICE
5W-30 or SAE 1OW-30)’ see
“Engine Oil”
in the Index.
Chassis Lubrication
- Lubricate
the suspension and steering
linkage. Lubricate the
transmission shift linkage.
Tire and Wheel Rotation and
InsDection
- For proper wear
and maximum tire life, rotate
your tires following the
instructions
in this manual. See
“Tires, Inspection and Rotation”
in the Index. Check the tires for
uneven wear or damage. If you
see irregular or premature wear,
check the wheel alignment.
Check for damaged wheels also.
Engine Accessory Drive Belt(s)
Inspection
- Inspect the belt(s)
for cracks, fraying, wear and
proper tension. Replace as needed. (Belts can have many
small cracks
in individual ribs
without affecting performance.)
ITEM
NO. SERVICE
5 Cooling System Service* -
Drain, flush and refill the system
with new or approved recycled
coolant conforming to
GM
Specification 1825M. Keep
coolant at the proper mixture as
specified. See “Coolant”
in the
Index. This provides proper
freeze and boil protection,
corrosion inhibitor level and
maintains proper engine
operating temperature.
Inspect hoses and replace
if they
are cracked, swollen or deterior-
ated. Tighten screw-type hose
clamps. Clean the outside
of the
radiator and air conditioning
condenser. Wash the pressure
cap and neck.
To help ensure proper operation,
we recommend a pressure test of
both the cooling system and the
pressure cap.
* An Emission Control Service.
. . .244

Downloaded from www.Manualslib.com manuals search engine USAGE FLUID/LUBRICANT
Floor
Shift Linkage
Chassis lubricant (GM Part
No. 1052497 or equivalent) or lubricant meeting requirements of
Chassis Lubrication Engine oil.
NLGI Grade 2, Category LB or GC-LB.
Rear Axle
(Standard Differential)
I
Axle Lubricant (GM Part No. 1052271) or SAE SOW-90 GL-5 Gear Lubricant.
I
Rear Axle (Limited- I Axle Lubricant (GM Part No. 12345977) or SAE 80W-90 GL-5 Gear Lubricant, and Limited-
Slip Differential) Slip Differential.Lubricant
Additive (GM Part
No. 1052358 or equivalent) where required. See
“Rear Axle”
in the Index. I
Maintenance Schedule
Section D: Recommended Fluids & Lubricants (Cont.)
Windshield Washer GM Optikleen’ Washer Solvent
(GM Part No. 1051515 or equivalent).
Solvent
I
Hood Latch Assembly
a. Pivots and Spring
b. Release Pawl
Anchor
1
~~
a.
Engine oil.
b. Chassis lubricant (GM Part
No. 1052497 or equivalent) or lubricant meeting requirements of
Hood and Door
Hinges, Rear Folding
Seat, Fuel Door Hinge,
Rear Compartment
Lid Hinges NLGI
Grade
2, Category LB or GC-LB.
Engine oil
or Lubriplate Lubricant (GM Part No. 1050109).
~
Weatherstrips I Dielectric Silicone Grease (GM Part No. 12345579 or equivalent).
See “Replacement Parts”
in the Index for recomme’nded replacement filters, valves and spark plugs.
. . .252

Downloaded from www.Manualslib.com manuals search engine ........................ 127
Acceleration Slip Regulation
System
..................... 128
System Warning Light
......... 96
Accessory Power. Retained
....... 56
Add-on Electrical Equipment
..... 227
And
Cruise Control
........... 79
Adding Coolant
................ 199
Additives. Engine Oil
............ 190
AirBags
...................... 26
How the System Works
........ 27
Servicing Your Air Bag-Equipped
Chevrolet
................. 30
Readiness Light .............. 27
Air Cleaner
.................... 19 I
Air Conditioner Controls ......... 1 10
Air Control Knob
............... 108
Air Filter Replacement ........... 192
Alignment and Tire Balance.
Wheel
...................... 219
Aluminum Wheels
.............. 224
AMFM Stereo
With Cassette Tape Player
...... I13
With Compact Disc Player ...... 116
Antenna. Fixed Mast
............ 121
Anti-Lock Brakes
.............. 127
System Warning Light
......... 95
To Use
..................... 128
Appearance Care
............... 220
Appearance Care and Materials
.... 226 Appearance Care.
Service and
..... 179
Ashtray and Lighter
............. 89
Ashtray. Front
................. 89
ASR ......................... 128
And Cruise Control
........... 79
System Warning Light ......... 96
Audio Systems ................. I 12
Audio Systems. Comfort Controls and
................. 107
Automatic
Transmission
................ 60
Transmission Fluid
............ I94
Axle. Limited-Slip Rear
.......... 66
Axle. Rear
.................... 197
Babies. Smaller Children
and (Safety Belts)
............. 34
Balance. Wheel Alignment
and Tire
.................... 219
Battery
....................... 204
Battery Replacement. Remote Lock
Control
..................... 50
BBB Auto Line - Alternative Dispute
Resolution Program. GM Participation
in ......... 259
Before Leaving
on a Long Trip .... 137
Belt Routing
................... 236
Belt. Lap-Shoulder
.............. 2 1
Bi-Level Heating ............... I09
Blizzard.
If You’re Caught in a ... 141
Box. Glove .................... 86 Brakes
Adjustment
.................. 204
Anti-Lock (ABS)
............. 127
Fluid ....................... 203
Master Cylinder
.............. 202
Parking
..................... 66
Pedal Travel
................. 204
System Parts. Replacing
........ 204
System Warning Light
......... 94
Trailer
...................... 145
Wear
...................... 203
Braking (Control of
a Vehicle) ..... 126
Braking
in Emergencies .......... 129
“Break.111.
.. New Vehicle ........ 55
Brightness Control .............. 80
Bulb Replacement
.............. 205
Center High-Mounted
Stoplight
.................. 209
Front Turn Signal
............. 210
Headlights
.................. 205
Rear Lights
.................. 205
Rear Sidemarker .............. 2 IO
Bulbs. Halogen ................. 211
Bulbs. Replacement
............. 231
Canadian Roadside Assistance
... 261
Capacities and Specifications
...... 232
Carbon Monoxide
.............. 52
Care Appearance
................. 220
Cassette Tape Player
.......... 120