1993 PONTIAC GRAND-PRIX timing belt

Maintenance Schedule
.
Section A: Scheduled Maintenance Services ~ont.3
Schedule I
Follow Schedule I if your vehicle is
MAINLY driven under one or more of
the following conditions:
When most trips are less than 4 miles
When most trips are less than 10 miles
(6 km).
(16 lun) and outside temperatures
remain below freezing.
When most trips include extended
idling and/or frequent low-speed
operation, as in stop-and-go traffic.
When towing a trailer.*+
When operating in dusty areas.
Schedule I should also be followed if
the vehicle is used for delivery service,
police, taxi
or other commercial
applications.
An Emission Control Service.
~2 The US. Environmental Protection Agency has
determined that the failure to perform this
maintenance item will not nullify the emission
warranty
or limit recall liability prior to the
completion of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be performed at the
indicated intervals and the maintenance be
recorded in Section
E: Maintenance Record.
292
TO BE SERVICED
See Euplnrzatior~ of Scheduled Maintennitce
Sercices following Schedules I and II.
ITEM
NO.
2 I Chassis Lubrication
3 Throttle Body Mounting Bolt Torque
(3.E Engine, VIN Code T)*
41
Tire and Wheel Rotation and Inspection
Camshaft Timing Belt Inspection (3.4L Engine,
VIN Code X)*
81
Transaxle Service
10 I Spark Plug Wire Inspection*+
Exhaust Gas Recirculation
(EGR) System
Inspection
(3.4L Code X engine only)**
14 Fuel Tank, Cap & Lines Inspection**
T
WHEN TO PERFORM
Miles (kilometers) or Months
(whichever occurs first).
Every other oil change.
At
6,000 Miles (10 000 km) and then every
15,000 Miles (25 000 !an) or as necessary.
At
60,000 Miles (100 000 km) and then every
l5,000 Miles (25 000 km).
See Explmution of Scheduled Muinterzance Services
following Schedules I and II.
Every 30,000 Miles (50 000 km).
Every 30:000 Miles (50 000 km).
Every 30,000 Miles (50 000 km).
ProCarManuals.com

Maintenance Schedule
Section A: Scheduled Maintenance Services t~ont.3
Schedule I1
Follow Schedule I1 ONLY if none of
the driving conditions specified in Schedule
I apply.
'' An Emission Control Service.
A The U.S. Environmental Protection Agency has
determined that the failure to perform this
maintenance item will not
nullify the emission
warranty
or limit recall liability prior to the
completion of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be performed at the
indicated intervals and the maintenance be
recorded in Section
E: Maintenance Record.
294
TO BE SERVICED ITEM
No' See Explanation of Scheduled Maintenance
Senices
following Schedules I and II.
WHEN TO PERFORM
Miles (kilometers) or Months
(whichever occurs first).
1
Camshaft Timing Belt Inspection At 60,000 Miles (100 000 km) and then every
(3.4L Engine, VIN Code X)* l5,000 Miles (25 OOO km). I
14 Fuel Tank, Cap and Lines Inspection** Every 30,000 Miles (50 OOO km).
ProCarManuals.com

ITEM
NO. SERVICE
ITEM NO. SERVICE
5
6
Engine
Accessory Drive Belt Inspection
(California
3.1L Code T, engine*)-Inspect the
belt for cracks, fraying, wear and proper tension.
Replace as needed,
Camshaft Timing Belt Inspection
(3.4L Code X
engine only)*-Inspect for cracks, wear or oiliness.
Check tensioner for proper operation. See the
service manual. (To purchase a service manual,
see the
Index under Publications.) Replace parts
as needed.
7 Cooling System Service*-Drain, flush and refill
the system with new or approved recycled coolant
conforming to
GM Specification 1825111. Keep
coolant at the proper mixture as specified. See the
Index under Coolant. This provides proper freeze
protection, corrosion inhibitor level, and engine
operating temperature.
Inspect hoses and replace if they are cracked,
swollen or deteriorated. Tighten screw-type hose
. clamps. Clean the outside of the radiator and air
conditioning condenser. Wash the pressure cap
and neck.
To help ensure proper operation, we recommend a
pressure test of both the cooling system and the
pressure cap.
8 Transaxle Service-For manual transaxles, fluid
doesn’t require changing.
For automatic transaxles, change both the fluid
and filter every
15,000 miles (25 000 lun) if the
vehicle is mainly driven under one or more of
these conditions:
In heavy city traffic where the outside
temperature regularly reaches
90°F (32°C) or
higher.
In hilly or mountainous terrain.
9
10
When doing frequent trailer towing. (With some
models,
you shouldn’t ever tow a trailer. See the
Index under Towing a Trailer.)
Uses such as found in taxi, police car or delivery
service.
If you do not use your vehicle under any
of these
conditions, change both the fluid and filter every
100,000 miles (160 000 km).
Spark Plug Replacement *-Replace spark plugs
with the proper type. See the
Index under
Replacement Parts.
Spark Plug Wire Inspection*+Inspect for
burns, cracks
or other damage. Check the boot fit
at the coils and at the spark plugs. Replace wires
as needed.
ProCarManuals.com