1993 PONTIAC GRAND-PRIX oil filter

INST ECON: Press to display your
fuel economy at the time you press the
button. The display will be updated
every five seconds until you turn it off.
Press again to turn off the display.
SYSTEMS CHECK: Press to display
the systems monitor
(STE Model only).
If your model does not have the systems
monitor, it will display the sewice
reminder sequence.
If it has the systems
monitor, press again to display the
service reminder sequence.
Systems Monitor: This checks to be
sure the following systems in your
vehicle are in proper working order:
Front lights
Rear lights
Side lights
Doors
Hood
Washer fluid
Trunk
Fuel tank
Anti-lock brakes (if equipped)
The systems monitor briefly displays
messages as it checks these systems. If
it finds a problem, the systems monitor
will display a continuous
or flashing
message about the problem. If all
systems are satisfactory, the service
reminder sequence will begin.
If you pull a trailer, the extra trailer
lamp bulbs will not allow the systems
monitor to properly detect a burned-out
bulb. When the trailer lights are
disconnected, the systems monitor will
again monitor the bulbs.
Service Reminder Sequence: This
shows the distance remaining to the
next recommended:
Oil change (OIL)
Oil filter change (OIL FILT)
Air filter change (AIR FILT)
Tire rotation (ROT TIRE)
Tune up (TUNE UP)
Press SYSTEMS CHECK each time
you want to see the next item in the
sequence.
When you have any of these services
performed, be sure to reset the service
reminder.
ProCarManuals.com

When to Change Engine Oil
See if any one of these is true for you:
Most trips are less than 4 miles
(6 la).
It’s below freezing outside and most
trips are less than 10 miles (16
km).
The engine is at low speed most of the
time (as in door-to-door delivery, or in
stop-and-go traffic).
You tow a trailer often.
Most trips are through dusty places.
If any one of these is true for your
vehicle, then
you need to change your
oil and filter every 3,000 miles (5 000 km)
or 3 months-whichever comes first.
See the
Index under Oil Change
Indicator.
If none of them is true, change the oil
every
7,500 miles (12 500 km) or 12
months-whichever comes first. Change the filter at the first oil change
and at every other oil change after that.
If you have the STE, you have an oil
change indicator in the Driver
Information Center. See the
Index
under Driver Information Center.
Engine Block Heater
An engine block heater can be a big
help if you have to park outside in very
cold weather,
0°F (-18°C) or colder. If
your vehicle has this option, see the
Index under Engine Block Heater.
What to Do with Used Oil
CAUTION
* Used engine oil contains
L things that have caused skin
callcer in laboratory animals. Don’t
let used oil stay on your skin for
very long. Clean your skin and nails
with soap and water,
or a good
hand cleaner. Wash or properly
throw away clothing or rags
containing used engine oil.
Used oil can be a real threat to the
environment.
If you change your own
oil, be sure to drain all free-flowing oil
from the filter before disposal. Don’t
ever dispose of oil by pouring it on the
ground, into sewers, or into streams or
bodies of water. Instead, recycle it by
taking it to a place that collects used oil.
If you have a problem properly
disposing of your used oil, ask your
dealer, a service station
or a local
recycling center for help.
223
ProCarManuals.com

2. Remove the air cleaner filter.
3. Be sure to install the air cleaner filter
and replace the cover tightly.
Automatic Transaxle Fluid
When to Check and Change:
A good time to check your automatic
transaxle fluid level
is when the engine
oil is changed. Refer to the Maintenance
Schedule to determine when to change
your fluid. See the
Index under
Scheduled Maintenance Services.
How to Check:
Because this operation can be a little
difficult, you may choose to have this
done at a Pontiac dealership Service
Department.
If you do
it yourself, be sure to follow
all the instructions here, or you could
get a false reading on the dipstick.
NOTICE I
00 much or too little fluid
mage your transaxle.
Too
n mean that some of the flu
Id come out and fall on
ho
ine parts, starting a fi
I
225 . .
ProCarManuals.com

Service & Appearance Care
Capacities & Specifications
Engine Crankcase
3.1L V6 ........................................................................\
.................... 4 quarts
Twin Dual Cam (DOHC)
3.4L V6 ................................................. 5 quarts
When changing filter, up to 1 quart (2L) more oil may be needed.
When draininglreplacing converter, more fluid may be needed.
Automatic Transaxle
Pan Removal and Replacement .................................................... 4 quarts
After Complete Overhaul
............................................................. 7 quarts
Automatic Transaxle with Overdrive
When drainingheplacing converter, more fluid may be needed.
Pan Removal and Replacement .................................................... 6 quarts
After Complete Overhaul
............................................................. 8 quarts
(or more, as needed for converter and auxiliary coolers)
Manual Transaxle, 5-Speed
Complete Drain and Refill .............................................................. 2.25 quarts
3.8 L
4.8 L
3.8 L
6.6 L
5.8 L
7.5 L
2.1 L
ProCarManuals.com

Service & Appearance Care
Normal Maintenance Replacement Parts
Air Cleaner Element
Engine
Oil Filter
PCV Valve
All Engines ........................................................................\
............. AC Type A-1129C
All Engines
........................................................................\
............. AC Type PF-51
3.1L V6
........................................................................\
................ ;. AC Type CV-892C
Twin Dual Cam (DOHC) 3.4L
V6 ............................................... AC Type CV-881C
3.1L V6
........................................................................\
.................. AC Type oR44LTSM
Twin
Dual Cam (DOHC) 3.4L V6 ............................................... AC Type oR42LTSM
Spark Plugs
Gap: 0.045 inch (1.14 mm)
Gap: 0.045 inch (1.14 mm)
Batteries
Remote Lock Control Transmitter ............................................... 2016 (2)
ProCarManuals.com

Maintenance Schedule
Section A: Scheduled Maintenance Services t~ont.3
Explanation of Scheduled Maintenance Services
Below are explanations of the services listed in Schedule I
and Schedule 11.
ITEM
NO. SERVICE
1 Engine Oil and Filter Change’:-Always use SG
Energy Conserving I1 oils for proper viscosity. The
“SG” designation may be shown alone or in
combination with others, such as “SG/CC,”
“SG/CD” or
“SF, SG, CC,” etc. To determine the
preferred viscosity for your vehicle’s engine (e.g.,
SAE
5W-30 or SAE 1OW-30) see the Index under
Engine OiZ. If your vehicle is equipped with an
Engine Oil-Change Indicator (EOCI)
, the
indicator will show you when to change oil. See
the
Index under Driver Information Center.
2 Chassis Lubrication-Lubricate the transaxle shift
linkage, parking brake cable guides, underbody
contact points and linkage. Lubricate the front and
rear suspension and steering linkage. The
proper fluids and lubricants to use are listed in Section
D. Make sure whoever services your vehicle uses these. All
parts should be replaced and all necessary repairs done
before you or anyone else drives the vehicle.
ITEM
NO. SERVICE
3 Throttle Body Mounting Bolt Torque (3.1L
Code T engine only)‘x- Check the torque of the
mounting bolts and/or nuts.
Tire and Wheel Rotation and Inspection -For
long wear and maximum tire life, rotate your tires
following the instructions in this manual. See the
Index under Tires, Inspection G. Rotation. Check
the tires for uneven wear or damage.
If you see
irregular or premature wear, check the wheel alignment. Check for damaged wheels also.
4
a The U.S. Environmental Protection Agency has determined that the failure to perform this maintenance item will not nullify the emission warranty or
limit recall liability prior to the completion of vehicle useful life. General Motors, however, urges that all recommended maintenance services be
performed at the indicated intervals and the maintenance be recorded
in Section E: Maintenance Record.
296
ProCarManuals.com

ITEM
NO. SERVICE
ITEM NO. SERVICE
5
6
Engine
Accessory Drive Belt Inspection
(California
3.1L Code T, engine*)-Inspect the
belt for cracks, fraying, wear and proper tension.
Replace as needed,
Camshaft Timing Belt Inspection
(3.4L Code X
engine only)*-Inspect for cracks, wear or oiliness.
Check tensioner for proper operation. See the
service manual. (To purchase a service manual,
see the
Index under Publications.) Replace parts
as needed.
7 Cooling System Service*-Drain, flush and refill
the system with new or approved recycled coolant
conforming to
GM Specification 1825111. Keep
coolant at the proper mixture as specified. See the
Index under Coolant. This provides proper freeze
protection, corrosion inhibitor level, and engine
operating temperature.
Inspect hoses and replace if they are cracked,
swollen or deteriorated. Tighten screw-type hose
. clamps. Clean the outside of the radiator and air
conditioning condenser. Wash the pressure cap
and neck.
To help ensure proper operation, we recommend a
pressure test of both the cooling system and the
pressure cap.
8 Transaxle Service-For manual transaxles, fluid
doesn’t require changing.
For automatic transaxles, change both the fluid
and filter every
15,000 miles (25 000 lun) if the
vehicle is mainly driven under one or more of
these conditions:
In heavy city traffic where the outside
temperature regularly reaches
90°F (32°C) or
higher.
In hilly or mountainous terrain.
9
10
When doing frequent trailer towing. (With some
models,
you shouldn’t ever tow a trailer. See the
Index under Towing a Trailer.)
Uses such as found in taxi, police car or delivery
service.
If you do not use your vehicle under any
of these
conditions, change both the fluid and filter every
100,000 miles (160 000 km).
Spark Plug Replacement *-Replace spark plugs
with the proper type. See the
Index under
Replacement Parts.
Spark Plug Wire Inspection*+Inspect for
burns, cracks
or other damage. Check the boot fit
at the coils and at the spark plugs. Replace wires
as needed.
ProCarManuals.com

USAGE
Hood Latch Assembly
a. Pivots and Spring
b. Release Pawl Anchor
Hood and door hinges,
fuel door hinge trunk
access panel hinges
Weatherstrips
I
FUJID/LUBRICANT
a. Engine oil.
b. Chassis lubricant meeting requirements of NLGI Grade 2, Category LB or GC-LB
Engine oil or Lubriplate Lubricant (GM Part
No. 1050109).
(GM
Part
No. 1052497 or equivalent).
Dielectric Silicone Grease (GM Part No. 12345579 or equivalent).
See the
Index under Replacement Parts for recommended replacement filters, valves and spark plugs.
ProCarManuals.com