1993 CHEVROLET TRACKER steering

Maintenance Schedule
Section C: Periodic Maintenance Inspections
Listed below are inspections and services which should be
performed at least twice a year (for instance, each spring or
fall). You should let your
GM dealer’s service department or
other qualified service center do these
jobs. Make sure
any necessary repairs are completed at once.
CHECK
I OR SERVICE WHAT TO DO
Steering, Suspension,
and Front-Wheel-Drive
Axle Boot and Seal
Inspection
Exhaust System
Inspection
Throttle Linkage
Inspection
Rear Axle (All) and
Front Axle
(Four-wheel Drive)
Service ~ Inspect front and rear suspension and steering system for damaged, loose or missing parts, signs
of wear or lack of lubrication. On vehicles equipped with power steering, inspect power steering,
lines and hoses for proper hookup, binding, leaks, cracks, chafing, etc. On vehicles equipped
with manual steering, check
for seal leakage. Clean and then inspect drive axle boot seals for
damage, tears or leakage. Replace seals
if necessary.
Inspect the complete exhaust system. Inspect the body near the exhaust system. Look for broken,
damaged, missing,
or out-of-position parts as well as open seams, holes, loose connections, or
other conditions which could cause a heat build-up in the floor pan or could let exhaust fumes
into the vehicle. See “Engine Exhaust’’
in the Index.
Inspect the throttle linkage for interference or binding, and for damaged or missing parts.
Replace parts as needed. Check accelerator pedal for smooth operation and even pedal effort.
Check the gear lubricant level and add if needed. See “Rear Axle’’ and ‘‘Four-wheel Drive’’
in
the Index. A fluid loss may indicate a problem. Check the system(s), and repair the system(s) if
needed. Refer to “Scheduled Maintenance Services,” earlier in this part, to determine when to
change
the lubricant.
ProCarManuals.com

Maintenance Schedule
Section D: Recommended Fluids and Lubricants
Note: Fluids and lubricants identified below by name, part number or specification may be obtained from your GM dealer.
USAGE
Engine Oil
Engine Coolant
Hydraulic Brake
System
Parking Brake Guides
Power Steering System
Automatic Transmission
Wheel Bearings
FLUID/LUBRICANT
GM Goodwrench Motor Oil or equivalent for API service SG Energy Conserving I1 oils of the
recommended viscosity. The SG designation may be shown alone or in combination with others,
such as
SG/CC, SG/CD, or SF, SG, CC, etc. To determine proper viscosity for your vehicle’s
engine, see
‘ ‘Engine Oil” in the Index.
50/50 mixture of water (preferably distilled) and good quality ethylene glycol base antifreeze
(GM Part
No. 1052753) conforming to GM Specification 6038M or approved recycled coolant
conforming to GM Specification 6038M.
Delco-Supreme 1
l@ Brake Fluid (GM Part No. 1052535) or equivalent DOT-3 brake fluid.
~~
Chassis lubricant meeting requirements of NLGI Grade 2, Category LB or GC-LB (GM Part No.
1052497 or equivalent).
DEXRONB-I1 Automatic Transmission Fluid (GM Part
No. 1051855) or equivalent.
DEXRON*-I1 Automatic Transmission Fluid (GM Part
No. 1051855) or equivalent.
3.
-
-
305 9 -
Wheel bearing grease meeting requirements of NLGI Grade 2, Category GC or GC-LB (GM Part
No. 105 1344 or equivalent).
ProCarManuals.com

In Mud. Sand. Snow. or Ice ...... 155
In the Rain
.................... 160
In Water ...................... 156
Long Distance
................. 167
On Curves
.................... 132
On Grades (With a Trailer)
....... 184
On Off-Road Hills.
............. 145
On Snow or Ice
................ 174
On the Freeway
................ 165
Suggestions.
A Few More Night . . 159
Uphill
........................ 147
Winter
....................... 173
With a Trailer
................. 182
Drunken Driving
................ 123
Easy Entry Seats
................. 14
Electrical Equipment. Add-on
...... 272
Emergencies. Braking
in .......... 132
Emergencies. Steering
in ......... -134
Engine
Coolant
...................... 240
Coolant Temperature Gage
........ 85
Exhaust
....................... 64
Identification
.................. 272
Oil
.......................... 229
Oil Pressure Light
............... 86
Overheating
................... 200
Specifications
................. 277
Starting Your
................... 49
Through
Deep Standing Water
..... 50 Environment.
Your Vehicle and the
. 282
Exhaust. Engine
.................. 64
Extender. Safety Belt
.............. 39
Fabric Protection
.................... 264
Using Solvent-Type Cleaner on
... 263
Features and Controls
.............. 43
Filling Your Tank (Fuel)
.......... 226
Filter Replacement. Air
........... 234
Flashers. Hazard Warning
......... 190
Flat Tire. Changing a
............. 208
Flat. If a Tire Goes
............... 208
Fluid Using Foam-Type
Cleaner on
..... 263
Five-Speed Manual Transmission
.... 54
Flow-Through Ventilation System
... 106
Automatic Transmission
......... 234
Manual Transmission
........... 237
Recommended
............ 27 1. 305
Windshield Washer
............. 244
Fog. Tips
on Driving in ........... 163
Folding Rear Seats
................ 15
Following Distance (With
a Trailer)
..................... 183
Foreign Countries. Fuels
in ........ 225
Four-wheel Drive
........... .57. 239
Power
Steering
................ 243
Fog. Mist and Haze. Driving
in ..... 162
Foreign Material Paint Damage
..... 269 Four-Wheel-Drive
Vehicle.
Freeway Off-Road
Driving with Your Geo
. . 140
Driving
...................... 165
Driving on the
................. 165
Entering the
................... 165
Leaving the
................... 165
Free-Wheeling Hubs
.............. 58
Automatic
..................... 59
Manual
........................ 59
Fuel
........................... 223
FuelGage
....................... 83
Fuel Tank Filling
................ 226
Fuels
in Foreign Countries ......... 225
Fuse Block. Instrument Panel
...... 275
Fuse Block. Main
................ 274
Fuses and Circuit Breakers
......... 273
Gage. Engine Coolant Temperature
. . 85
Gage. Fuel
...................... 83
Gages and Indicators. Warning
Lights
......................... 82
Gasolines for Cleaner Air
.......... 224
Glass Cleaning
.................. 266
GloveBox
....................... 75
GM Participation
in Better
Business Bureau Mediation/
Arbitration Program
............ 315
Grips. Passenger Assist
............ 76
Guidelines. Utility Vehicle Driving
. . 140
327 9
ProCarManuals.com

9 9 330
Parking Brake
......................... 60
Downhill ..................... 172
Manual Transmission ............ 63
On a Hill with a Trailer.
When
You Are Ready to
Leave After ................. 185
On Hills ...................... 171
On Hills (With a Trailer) ........ 184
Over Things That Bum ........... 64
Uphill ........................ 172
Your Vehicle ................... 63
Parking and Turn Signal Light
Bulb Replacement. Front
........ 249
Parts, Replacement ............... 277
Passenger
Assist Grips
.................... 76
Positions (Safety Belt) ............ 28
Rear Seat (Safety Belt) ........... 28
Right Front Position (Safety Belt) . . 28
Passing ........................ 136
Passing (With a Trailer) ........... 183
Passing Signal .................... 70
Pavement Markings .............. 12 1
Pedal Travel. Brake .............. 13 1
Periodic Maintenance Inspections ... 303
Pockets. Front Seat Side ............ 75
Power Steering .................. 132
Power Steering Fluid ............. 243
Pregnancy. Safety Belt Use during ... 27
Pressure. Tire ................... 254
Problems on the Road ............. 189
Product Service Publications
(PSP’s)
....................... 32 1
Publications. Service ............. 320
Radiator Pressure Cap ........... 243
Radiator. How to Add Coolant ...... 206
Radio Reception. Understanding .... 115
Radio. To Play the
AM/FM Stereo
................ 108
AM/FM Stereo with
Cassette Tape Player
.......... 1 10
Rain. Driving in the .............. 160
Rainy Weather Tips. Some Other ... 161
RearAxle ...................... 238
Rear Drum Brakes ............... 13 1
Rear Vent Windows ............... 66
Rear Window
Defogger
..................... 105
Opening and Closing Your ........ 90
Removing and Installing Your ..... 91
Wiper/Washer .................. 73
Rearview Mirror. Inside ............ 74
Rearview Mirror. Inside Day/Night . . 74
Reception. Understanding Radio .... 1 15
Reclining Front Seatback ........... 13
Recommended Fluids and
Lubricants
................ 27 1. 305
Recovery Hooks. Using the ........ 218
Recovery. Off-Road .............. 135
Recreational Towing ............. 186
Towing Your Geo from the Front . . 187
Towing Your Geo from the Rear . . 186
Release. Hood ................... 227
Remote Areas. Traveling to ........ 142
Replacement Bulbs ............... 276
Replacement Parts ............... 277
Replacing Safety Belts after a Crash . . 39
Reporting Safety Defects
To General Motors
............. 318
To the Canadian Government ..... 318
To the United States Government . . 3 17
Restraint Systems. Checking Your ... 39
Restraint. Where to Put the Child .... 32
Restraints. Child .................. 34
Restraints. Head .................. 14
Road Signs ..................... 118
Color of ...................... 118
Shapeof ...................... 119
Symbols on ................... 120
Road. On the .................... 168
Road. Problems On the ............ 189
Roads. Hill and Mountain ......... 169
Roadside Assistance Program.
Chevrolet/Geo
............. - - .. 319
ProCarManuals.com

Index
Stains .......................... 264
Stalling on an Incline ............. 154
Starting Your Engine .............. 49
Starting. Jump ................... 191
Steam (Engine Overheating) ...... -200
Steering ........................ 132
Fluid, Power .................. 243
In Emergencies ................ 134
Power ....................... 132
Storage and Compartments ......... 75
Storage. Vehicle ................. 247
Stuck: In Sand. Mud. Ice or
Snow, If You’re
............... 2 17
Sun Visors ....................... 76
Sunroof. Opening and
Closing Your
................... 89
Switch, Ignition .................. 48
Symbols. Safety Warnings and ....... 6
Symbols. Vehicle ................. 18
Tachometer ..................... 82
Tailgate (Door Locks) ............. 46
Tank, Filling Your (Fuel) .......... 223
Temperature Gage, Engine
Coolant
....................... 85
Terrain. Scanning the ............. 144
Theft ........................... 47
Tips ......................... 132
Stuck in Deep Snow, If You’re ..... 177
Symbols on Road Signs ........... 120
Theft Deterrent Feature
(AM/FM Stereo with Cassette
Tape Player)
................ 1 13
Thermostat ..................... 243
Tilt Wheel ...................... -67
Tires .......................... 253
Balance ...................... 259
Chains ....................... 26 1
Changing a Flat
................ 208
Cleaning White Sidewall ........ 269
Inflation Pressure .............. 254
Inspection .................... 255
Loading Information Label ....... 252
New ......................... 256
Rotation ...................... 255
Temperature Grades ............ 258
Total Weight on Your Vehicle’s. .. 180
Traction Grades ................ 258
Treadwear .................... 258
Uniform Quality Grading ........ 257
AM/FM Stereo ................ 109
AM/FM Stereo with
Cassette Tape Player
.......... 1 1 1
Tone, Setting the
Top Strap (Child Restraint)
......... 33
Top, Convertible ................. 87
Storage ........................ 96
Top, Preparing Your Canvas for
Top, Removing and Installing
Your Canvas
................... 91
Torque Lock .................... 173
Towing a Trailer ................. 177
Towing Hook.Ups. Front ......... -198
Towing Hook.Ups. Rear .......... 199
Towing Your Vehicle ............. 196
Towing. Recreational ............. 186
From the Front ................ 187
From the Rear ................. 186
Traffic Lights ................... 120
Traffic Officer .................. 122
Trailer
Backing Up with a
.............. 183
Brakes
....................... 181
Driving on Grades .............. 184
Driving with a ................. 182
Following Distance with a ....... 183
Hitches ....................... 180
If You Do Decide to Pull a ....... 178
Making Turns with a ............ 183
Parking on Hills with a .......... 184
Passing with a ................. 183
Safety Chains ................. 181
Tongue, Weight of the .......... 180
Towing a ..................... 177
Towing. Maintenance When ..... 185
Turn Signals When Towing a ..... 183
Weight of the .................. 179
When You Are Ready to Leave
after Parking on a Hill
......... 185
ProCarManuals.com