1993 CHEVROLET TRACKER brake fluid

Service & Appearance Care
CA U TlON
R
d
fl
I1
A If you have too much brake
L,,E;ine. The fluid will burn
if the
engine is hot enough.
You or
others could be burned, and your
vehicle could be damaged. Add
brake fluid only when work
is
done on the brake hydraulic
system.
L fluid, it can spill on the
Lefer to
the Maintenance Schedule to
etermine when to check your brake
hid. See ‘‘Periodic Maintenance
Ispections” in the Index.
’ To Check Brake Fluid:
1
You can check the brake fluid without
taking
off the cap. Just look at the
windows on the brake fluid reservoir.
The fluid levels should be above
MIN.
If they aren’t, have your brake system
checked to see
if there is a leak.
After work is done
on the the brake
hydraulic system make sure the levels
are above
MIN and below the top of
each window.
What to Add:
When you do need brake fluid, use
only DOT-3 brake fluid
- such as
Delco-Supreme
II@ (GM Part No.
I DOT-5 silicone brake fluid can
damage your llehicle. Don’t use
it.
I D0n.t so1 : put In tf
wrong mnd 01 kd. For
example, just a few drops
mineral-based oil,
such as
engine oil,
in your brake systt
can damage brake system part
so badly that they’ll have to b
replaced.
Brake fluid
I Ige paint,
be careful not to spill
fluid
on your vehicle
1052535). Use new brake fluid from a
sealed container only.
ProCarManuals.com

Maintenance Schedule
Section C: Periodic Maintenance Inspections (Cont.)
CHECK
OR SERVICE
Brake System
Inspection
Clutch System Service
~
WHAT TO DO
Inspect the complete system. Inspect brake lines and hoses for proper hookup, binding, leaks,
cracks, chafing, etc. Inspect disc brake pads for wear and rotors for surface condition.
Also
inspect drum brake linings for wear and cracks. Inspect other brake parts, including drums,
wheel cylinders, calipers, parking brake, etc. Check parking brake adjustment.
You may need to
have your brakes inspected more often if your driving habits or conditions result in frequent
braking.
NOTE: A low fluid brake level can indicate worn disc brake pads which may need to be
serviced. Also,
if the brake system warning light stays on or comes on at any time something
may be wrong with either the regular or rear wheel anti-lock brake system, or both systems. See
“Brake Svstem Warning Light” in the Index.
Check clutch pedal free travel and adjust as necessary. See “Clutch Adjustment”
in the Index.
ProCarManuals.com

Maintenance Schedule
Section D: Recommended Fluids and Lubricants
Note: Fluids and lubricants identified below by name, part number or specification may be obtained from your GM dealer.
USAGE
Engine Oil
Engine Coolant
Hydraulic Brake
System
Parking Brake Guides
Power Steering System
Automatic Transmission
Wheel Bearings
FLUID/LUBRICANT
GM Goodwrench Motor Oil or equivalent for API service SG Energy Conserving I1 oils of the
recommended viscosity. The SG designation may be shown alone or in combination with others,
such as
SG/CC, SG/CD, or SF, SG, CC, etc. To determine proper viscosity for your vehicle’s
engine, see
‘ ‘Engine Oil” in the Index.
50/50 mixture of water (preferably distilled) and good quality ethylene glycol base antifreeze
(GM Part
No. 1052753) conforming to GM Specification 6038M or approved recycled coolant
conforming to GM Specification 6038M.
Delco-Supreme 1
l@ Brake Fluid (GM Part No. 1052535) or equivalent DOT-3 brake fluid.
~~
Chassis lubricant meeting requirements of NLGI Grade 2, Category LB or GC-LB (GM Part No.
1052497 or equivalent).
DEXRONB-I1 Automatic Transmission Fluid (GM Part
No. 1051855) or equivalent.
DEXRON*-I1 Automatic Transmission Fluid (GM Part
No. 1051855) or equivalent.
3.
-
-
305 9 -
Wheel bearing grease meeting requirements of NLGI Grade 2, Category GC or GC-LB (GM Part
No. 105 1344 or equivalent).
ProCarManuals.com

Index
Add-on Electrical Equipment ...... 272
Adjustment. Brake
............... 13 1
Adjustment. Clutch
............... 238
Air Cleaner
..................... 233
Air Conditioner Controls
.......... 104
Air Filter Replacement
............ 234
Alignment. Wheel
............... 259
Aluminum Wheel Cleaning
........ 269
Antenna
........................ 116
Anti-lock Brakes
................. 129
Anti-lock. To Use
................ 130
Appearance Care
................ 26 1
Appearance Care and Maintenance
Materials
..................... 27 1
Appearance Care. Service and
...... 22 1
Ashtray. Front ................... 77
Assist Grips. Passenger
............ 76
Audio Systems
.................. 106
AM/FM Stereo
................ 108
AM/FM Stereo with
Cassette Tape Player
.......... 110
Automatic Transmission
............ 5 1
Fluid ........................ 234
TorqueLock
.................. 173
Axle. Front (Four-Wheel-Drive)
.... 239
Axle, Rear
...................... 238
Ashtray and
Lighter
............... 77
Ashtrays, Other
.................. 77
Babies. Smaller Children and
(Safety Belts)
................... 30
Backing Up (With a Trailer)
........ 183
Balance. Tire
................... 259
Battery
......................... 247
Bi-Level Heating
................ 103
Bin. Coinholder and
............... 76
Bins. Instrument Panel
............. 75
Brakes
Before Leaving on a Long
Trip
..... 167
Blizzard. If You’re Caught
in a ..... 175
Adjustment
.................. -13 1
Anti-lock
..................... 129
Master Cylinder
............... 245
Parking
....................... 60
PedalTravel
.................. 131
Rear Drum
.................... 130
System Parts. Replacing
......... 247
System Warning Light
........... 84
Trailer
....................... 18 1
Wear Indicators. Disc
........... 130
Braking ........................ 127
Braking in Emergencies
........... 132
“Break-In.
.. New Vehicle .......... 48
Brightness Control
................ 7 1
Bulb Replacement ................ 248
Front Parking and Turn
Signal Light
................. 249
Headlights
.................... 248
Sidemarker Light
.............. 250
Rear Combination Light
......... 25
1 Bulbs. Halogen
.................. 248
Bulbs. Replacement
.............. 276
Canvas TOP
Preparing for Storage
............ 96
Removing and Installing Your
..... 91
Special Care
for ................ 268
Carbon Monoxide (Engine Exhaust)
. . 64
Care of Canvas Top
.............. 268
Cassette Tape Player. Care of Your
. . 115
Cassette Tape. To Play a
.......... 111
Certification Label
............... 252
Chains. Safety (Trailer)
........... 181
Chains. Tire
.................... 261
Changing a Flat Tire
.............. 208
Charging System Light
............. 85
Check Engine Light
............... 85
Capacities
and Specifications
....... 277
Checking Things under the Hood
.... 227
Checking Your Restraint Systems
.... 39
Chemical Paint Spotting ........... 270
Chevrolet/Geo Roadside
Assistance
.................... 319
Chevrolet/Geo Service Publications
Ordering Information
........... 318
Child Restraints
.................. 31
Securing in the Rear Seat
......... 34
Securing in the Right Front Seat .... 36
Top Strap. Right Front
Passenger Position Only
........ 33
325 .
ProCarManuals.com

Loading Your Vehicle ............ 252
Loading Your Vehicle for
Off-Road Driving
.............. 14 1
Locks.
Door ...................... 45
Loss of Control
.................. 138
Lubricants and Fluids
......... 27 1. 305
Maintenance Materials. Appearance Care and
. . 27 1
Periodic Inspections
............ 303
Record
....................... 308
Other Non-Emission Related
Services
.................... 296
Scheduled Services
............. 285
Underbody
.................... 270
Maintenance Schedule
............ 28 1
Schedule
I .................... 286
Schedule
II.’. .................. 288
Selecting the Right
............. 285
Services. Scheduled
............ 285
Using Your
................... 285
When Trailer Towing
........... 185
Making Turns (With a Trailer)
...... 183
Malfunction Indicator Lamp
........ 85
Manual Transmission
Five-Speed
.................... 54
Fluid ........................ 237
Shift Speeds
.................... 56
Manual. How to Use This ........... 5
Markings. Pavement .............. 12 1
Master Cylinder. Brake ........... 245
Mirrors
......................... 74
Convex Outside
................. 74
Inside Rearview
................. 74
Metal Damage. Sheet
............. 269
Inside Day/Night Rearview
....... 74
Outside Manual Adjust
........... 74
Mud. Sand. Snow. or Ice.
Driving in
.................... 155
New Vehicle
. ‘Break-In’ ........... 48
Night
Driving at
.................... 157
Driving Suggestions. A Few
More
...................... 159
Vision
....................... 158
odometer. Speedometer and
....... 80
Odometer. Trip ................... 8 1
Officer. Traffic
.................. 122
Off-Road Driving
After
........................ 157
Before You Go
................ 141
Getting Familiar with
........... 143
On Hills
...................... 145
With Your Geo Four-Wheel-
Drive Vehicle
............... 140
Loading Your Vehicle
for
........ 141 Off-Road Recovery
.............. 135
Oil. Engine
..................... 229
Additives
..................... 232
How to Check
................. 229
Pressure Light
.................. 86
What Kind to Use
.............. 231
What to
Do with Used ........... 233
When to Add
.................. 230
When
to Change ............... 232
On the Road
.................... 168
Opening and Closing
Your Rear Window
.............. 90
Operation of Lights ................ 69
Overheating, Engine
.............. 200
Owner Checks and Services
........ 302
Paint
Opening and Closing Your Sunroof
... 89
Chemical Spotting
.............. 270
Finish Care
................... 267
Finish Damage
............... 270
Park. Shifting into ................. 61
Park, Shifting out
of ............... 63
Parked, Running Your Engine
While You’re
................... 65 .
329 9 9 9
ProCarManuals.com

9 9 330
Parking Brake
......................... 60
Downhill ..................... 172
Manual Transmission ............ 63
On a Hill with a Trailer.
When
You Are Ready to
Leave After ................. 185
On Hills ...................... 171
On Hills (With a Trailer) ........ 184
Over Things That Bum ........... 64
Uphill ........................ 172
Your Vehicle ................... 63
Parking and Turn Signal Light
Bulb Replacement. Front
........ 249
Parts, Replacement ............... 277
Passenger
Assist Grips
.................... 76
Positions (Safety Belt) ............ 28
Rear Seat (Safety Belt) ........... 28
Right Front Position (Safety Belt) . . 28
Passing ........................ 136
Passing (With a Trailer) ........... 183
Passing Signal .................... 70
Pavement Markings .............. 12 1
Pedal Travel. Brake .............. 13 1
Periodic Maintenance Inspections ... 303
Pockets. Front Seat Side ............ 75
Power Steering .................. 132
Power Steering Fluid ............. 243
Pregnancy. Safety Belt Use during ... 27
Pressure. Tire ................... 254
Problems on the Road ............. 189
Product Service Publications
(PSP’s)
....................... 32 1
Publications. Service ............. 320
Radiator Pressure Cap ........... 243
Radiator. How to Add Coolant ...... 206
Radio Reception. Understanding .... 115
Radio. To Play the
AM/FM Stereo
................ 108
AM/FM Stereo with
Cassette Tape Player
.......... 1 10
Rain. Driving in the .............. 160
Rainy Weather Tips. Some Other ... 161
RearAxle ...................... 238
Rear Drum Brakes ............... 13 1
Rear Vent Windows ............... 66
Rear Window
Defogger
..................... 105
Opening and Closing Your ........ 90
Removing and Installing Your ..... 91
Wiper/Washer .................. 73
Rearview Mirror. Inside ............ 74
Rearview Mirror. Inside Day/Night . . 74
Reception. Understanding Radio .... 1 15
Reclining Front Seatback ........... 13
Recommended Fluids and
Lubricants
................ 27 1. 305
Recovery Hooks. Using the ........ 218
Recovery. Off-Road .............. 135
Recreational Towing ............. 186
Towing Your Geo from the Front . . 187
Towing Your Geo from the Rear . . 186
Release. Hood ................... 227
Remote Areas. Traveling to ........ 142
Replacement Bulbs ............... 276
Replacement Parts ............... 277
Replacing Safety Belts after a Crash . . 39
Reporting Safety Defects
To General Motors
............. 318
To the Canadian Government ..... 318
To the United States Government . . 3 17
Restraint Systems. Checking Your ... 39
Restraint. Where to Put the Child .... 32
Restraints. Child .................. 34
Restraints. Head .................. 14
Road Signs ..................... 118
Color of ...................... 118
Shapeof ...................... 119
Symbols on ................... 120
Road. On the .................... 168
Road. Problems On the ............ 189
Roads. Hill and Mountain ......... 169
Roadside Assistance Program.
Chevrolet/Geo
............. - - .. 319
ProCarManuals.com

Index
Stains .......................... 264
Stalling on an Incline ............. 154
Starting Your Engine .............. 49
Starting. Jump ................... 191
Steam (Engine Overheating) ...... -200
Steering ........................ 132
Fluid, Power .................. 243
In Emergencies ................ 134
Power ....................... 132
Storage and Compartments ......... 75
Storage. Vehicle ................. 247
Stuck: In Sand. Mud. Ice or
Snow, If You’re
............... 2 17
Sun Visors ....................... 76
Sunroof. Opening and
Closing Your
................... 89
Switch, Ignition .................. 48
Symbols. Safety Warnings and ....... 6
Symbols. Vehicle ................. 18
Tachometer ..................... 82
Tailgate (Door Locks) ............. 46
Tank, Filling Your (Fuel) .......... 223
Temperature Gage, Engine
Coolant
....................... 85
Terrain. Scanning the ............. 144
Theft ........................... 47
Tips ......................... 132
Stuck in Deep Snow, If You’re ..... 177
Symbols on Road Signs ........... 120
Theft Deterrent Feature
(AM/FM Stereo with Cassette
Tape Player)
................ 1 13
Thermostat ..................... 243
Tilt Wheel ...................... -67
Tires .......................... 253
Balance ...................... 259
Chains ....................... 26 1
Changing a Flat
................ 208
Cleaning White Sidewall ........ 269
Inflation Pressure .............. 254
Inspection .................... 255
Loading Information Label ....... 252
New ......................... 256
Rotation ...................... 255
Temperature Grades ............ 258
Total Weight on Your Vehicle’s. .. 180
Traction Grades ................ 258
Treadwear .................... 258
Uniform Quality Grading ........ 257
AM/FM Stereo ................ 109
AM/FM Stereo with
Cassette Tape Player
.......... 1 1 1
Tone, Setting the
Top Strap (Child Restraint)
......... 33
Top, Convertible ................. 87
Storage ........................ 96
Top, Preparing Your Canvas for
Top, Removing and Installing
Your Canvas
................... 91
Torque Lock .................... 173
Towing a Trailer ................. 177
Towing Hook.Ups. Front ......... -198
Towing Hook.Ups. Rear .......... 199
Towing Your Vehicle ............. 196
Towing. Recreational ............. 186
From the Front ................ 187
From the Rear ................. 186
Traffic Lights ................... 120
Traffic Officer .................. 122
Trailer
Backing Up with a
.............. 183
Brakes
....................... 181
Driving on Grades .............. 184
Driving with a ................. 182
Following Distance with a ....... 183
Hitches ....................... 180
If You Do Decide to Pull a ....... 178
Making Turns with a ............ 183
Parking on Hills with a .......... 184
Passing with a ................. 183
Safety Chains ................. 181
Tongue, Weight of the .......... 180
Towing a ..................... 177
Towing. Maintenance When ..... 185
Turn Signals When Towing a ..... 183
Weight of the .................. 179
When You Are Ready to Leave
after Parking on a Hill
......... 185
ProCarManuals.com