1993 CHEVROLET CAVALIER air filter

Downloaded from www.Manualslib.com manuals search engine Used oil can be a real threat to the
environment.
If you change your own oil, be sure to
drain all free-flowing oil from the filter
before disposal.
Don’t ever dispose
of oil by pouring it
on the ground, into sewers, or into
streams or bodies
of water. Instead,
recycle it by taking it to a place that
collects used oil. If you have a problem
properly disposing of your used oil, ask
your dealer, a service station or a local
recycling center for help.
Air Cleaner
Refer to the Maintenance Schedule to
determine when to replace the air filter.
See the
Index under Scheduled
Maintenance Services.
A Opemting the engine with the
1 air cleaner off can cause you
nr others to be burned. The air
mer not only cleans
the air, it
stops flame if the engine backfires.
If it isn’t there,
and the engine
backfires,
you could be burned.
.Don’t drive with it
off, and be
candid working on the engine with
the air cleaner off.
I
I ~~~~ NOTIC€ ~~
If the air cleaner is off, a backfire
can cause a damaging engine fire.
And, dirt can easily get into your
engine, which will damage it.
Always have the air cleaner
i~
place when you’re driving.
209 I

Downloaded from www.Manualslib.com manuals search engine Service & Appearance Care
111
2.2L L4: Air Filter Replacement
To check or replace the filter, remove
the two wing nuts and lift the cover.
21 0
3.1L V6 (Except 2-24): Air Filter
Replacement
To check or replace the filter, remove
the three wing nuts
and lift the cover.
3.1L V6 (2-24): Air Filter
Replacement
To check or replace the filter, unclip the
three clips and remove the cover.

Downloaded from www.Manualslib.com manuals search engine Service & Appearance Care
Normal Maintenance Replacement Parts
Air Cleaner Element
2.2L L4 . . . . , . . . . . . . . . . . . . . . . . . AC Type A-1172C
3.1L
V6 . . . . . . . . . . . . . . . . . . . . . . . . AC Type A-1098C
2-24
. . . . . . . . . . . . . . . . . . . . . . . . AC Type A-925C
Engine Oil Filter
2.2L L4 . . . . . . . . . . . . . . . . . . . . . . AC Type PF-47
3.1L
V6 . . . . . . . . . . . . . . . . . . . . . . . . AC Type PF-51
2.2L L4
. . . . . . . . . . . . . . . . . . . . . . . AC Type CV-9OOC
3.1L V6
. . . . . . . . . . . . . . . . . . . . . . . . AC Type CV-892C
2.2L
L4 . . . . . . . . . . . . . . . . . . . . . . . AC Type eR44LTSMA
3.1L V6
. . . . . . . . . . . . . . , . . . . . . . . . AC Type eR44LTSM
PCV Valve
Spark Plugs
Gap: 1.14 mm (0.045 inch)
Gap: 1.14
mm (0.045 inch)
. . . 256

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.)
Schedule I
Follow Schedule I if your vehicle is
MAINLY driven under one or more
of the following conditions:
When most trips are less than 4 miles
When most trips are less than 10 miles
(6 km).
(16 km) and outside temperatures
remain below freezing.
When most trips include extended
idling and/or frequent low-speed
operation, as in stop-and-go traffic.
When operating in dusty ,areas.
Schedule I should also be followed if
the vehicle is used for delivery service,
police, taxi
or other commercial
applications.
*An Emission Control Service.
b me US. Environmental Protection Agency
has determined that the failure to pelform this
maintenance item will not
nullifi the emission
warranty or limit recall liability prior to the
completion
of vehicle use&/ life. General
Motors, however, urges that all recommended maintenance services be performed at the indicated intervals and the maintenance be
recorded in Section
E: Maintenance Record.
I I
TO BE SERVICED ITEM
NO. See Explanation of Scheduled Maintenance
Sewices
following Schedules I and II.
WHEN TO PERFORM
Miles (kiloineters) or Months
(whichever
occurs first).
Chassis Lubrication 1 Every other oil change. I
I Engine Accessory Drive Belt Inspection* I Every 30,000 Miles (50 OOO km) or 24 Months. I
(ll
Transaxle Service See Explanation of Scheduled Maintenance
Services
following Schedules I and 11.
I 10 I Air Cleaner Filter Replacement* I Every 30,000 Miles (50 000 km). I
264

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.)
Schedule I/
Follow Schedule II ONLY if none of
the driving conditions specified in Schedule
I apply.
*An Emission Control Service.
~2 The US. Environmental Protection Agency
has determined that the failure to pelform this
maintenance item will not nullify the emission warranty or limit recall liability prior
to the
completion
of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be pei$ormed at the indicated intervals and the maintenance be
recorded in Section E: Maintenance Record.
TO BE SERVICED
See Explanation of Scheduled Maintenance
Services
following Schedules I and II.
WHEN TO PERFORM
Miles (kilometers) or Months
(whichever occursfirst).
I 2 I Chassis Lubrication I Every 7,500 Miles (12 500 km) or 12 Months.
I 4 I Engine Accessory Drive Belt Inspection* I Every 30,000 Miles (50 OOO km) or 24 Months.
16/
Transaxle Service See Explanation of Scheduled Maintenance Services
following Schedules I and 11.
(!-Spark Plug wire Inspection** I Every 30,000 Miles (50 OOO km).
F] Air Cleaner Filter Replacement* 1 Every 30,000 Miles (50 OOO km).
266

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services (cont.)
Explanation of Scheduled Maintenance Services
Below are explanations of the services listed in Schedule I
and Schedule II.
The proper fluids and lubricants to use are listed in
Section
D. Make sure whoever services your vehicle uses
ITEM
NO. SERVICE
1
2 Engine Oil and Filter Change-Always use SG
Energy Conserving
11 oils of proper viscosity. The
“SG’ designation may be shown alone or in
combination with others, such as “SG/CC,”
“SG/CD” or “SF,
SG, CC,” etc. To determine the
preferred viscosity
for your vehicle’s engine (e.g.,
SAE 5W-30 or SAE 10W-30), see the Index under
Engine Oil.
Chassis Lubrication-Lubricate the transaxle shift
linkage, parking brake cable guides, underbody
contact points and linkage. Lubricate the front and
rear suspension and steering linkage.
Emission Control
Service.
these. All parts should be replaced and all necessary repairs
done before you or anyone else drives the vehicle.
Note: To determine your engine’s displacement and code,
see the Index under Engine Identification.
ITEM
NO.
3
SERVICE
Tire and Wheel Inspection and Rotation-For
proper wear and maximum tire life, rotate your
tires following the instructions
in this manual. See
the Index under Eres, Inspection & Rotation.
Check the tires for uneven wear or damage. If you
see irregular or premature wear, check the wheel
alignment. Check for damaged wheels also.

Downloaded from www.Manualslib.com manuals search engine ITEM
NO. SERVICE ITEM NO. SERVICE
4
5
Engine
Accessory Drive Belt(s) Inspection*-
Inspect the belt(s) for cracks, fraying, wear and
proper tension. Replace as needed.
Cooling System Service*-Drain, flush and refill
the system with
new or approved recycled coolant
conforming to
GM Specification 1825M. Keep
coolant at the proper mixture as specified. See the
Index under Coolant. This provides proper freeze
protection, corrosion inhibitor level and engine
operating temperature.
Inspect hoses and replace if they are cracked,
swollen or deteriorated. Tighten screw-type hose
clamps. Clean the outside of the radiator and air
conditioning condenser. Wash
the pressure cap and
neck.
To help ensure proper operation, we recommend a
pressure test of both the cooling system and the
pressure cap.
6
7
8
9
Transaxle Service-For manual transaxles, fluid
doesn't require changing.
For automatic transaxles, change both the fluid and
filter every
15,000 miles (25 000 km) if the vehicle
is mainly driven under one or more of these
conditions:
In heavy city traffic where the outside temperature
In hilly or mountainous terrain.
Uses such as found in taxi, police car or delivery
regularly reaches
90" F (32" C) or higher.
service.
If you do not use your vehicle under any of
these conditions, change both the fluid and filter
every 100,000 miles (160
0oO km).
Spark Plug Replacement*-Replace spark plugs
with the proper type. See
the Index under
Replacement Parts.
Spark Plug Wire Inspection* *-Inspect for
burns, cracks or other damage. Check the boot
fit
at the coils and at the spark plugs. Replace wires as
needed.
Exhaust Gas Recirculation (EGR) System
Inspection
(2.2L L4 Code 4 engine)" *-Conduct
the
EGR system service as described in the service
manual. To purchase a service manual
, see the
Index under Service Publications.

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.)
ITEM
NO. SERVICE
10 Air Cleaner Filter Replacement*-Replace every
30,000 miles (50 OOO km) or more often under
dusty conditions.
Ask your dealer for the proper
replacement intervals for your driving conditions.
ITEM
NO. SERVICE
11 Fuel Tank, Cap and Lines Inspection**-
Inspect fuel
tank, cap and lines (including fuel rails
and injection assembly)
for damage or leaks.
Inspect fuel cap gasket for an even filler neck
imprint
or any damage. Replace parts as needed.
Periodic replacement of the fuel filter
is not
required.
*An Emission Control Service.
~2 The US. Environmental Protection Agency has determined that the fuilure to pe$orm this maintenance item will not nullijE the emission warranty or
limit recall liability prior to the completion of vehicle usefirl life. General Motors, however, urges that all r\
ecommended maintenance sewices be
per$ormed at the indicated intervals and the maintenance be recorded in Section
E: Maintenance Record.
270