1993 CHEVROLET ASTRO PASSENGER radiator

Downloaded from www.Manualslib.com manuals search engine Service & Appearance Care
0
I.
I
When using a concentrated washer fluid, follow the manufacturer'\
s instructions for adding water.
Don't mix water with ready-to-use washer fluid. Water can cause\
the
solution
to freeze and damage your washer fluid tank and other parts
of the washer system. Also, water doesn't clean as well as washer\

I
fluid.
Fill your washer fluid tank only 314 full"when it's'vety cold. This
allows for expansion, which could damage the tank
if it is completely I
full.
"L..:.i: , , I_ y:~ i; P .. .. . . .. . .... . *>,: " 2 ..., .- .. .. ;'r : ,y*: , '-I 1' .:a,' ...j , .I' _I .~ ,.., <:':,.YY<..'.% , , .', < .. c7~ Ij
" .,. , , ...j. .. :,,;,.: >: :,:. I, ~,~. .,. ._
Don't use radiator antifreeze in your windshield washer. It can
damage your washer system and paint.
I
Brake Master Cylhder
Your brake master cylinder is here. It is filled with DOT-3 brake fluid.
There are only
two reasons why the brake fluid level in your master cylinder
might go down. The first is that the brake fluid goes down to an acceptable
level during normal brake lining wear. When new linings are put in, the fluid
level goes back up. The other reason is that fluid is leaking out of the brake
system.
If it is, you should have your brake system fixed, since a leak mea\
ns
that sooner or later your brakes won't work well, or won't wo\
rk at all.
6-32

Downloaded from www.Manualslib.com manuals search engine Service & Appearance Care
Service Replacement Parf and Filter
Recommendations Table
Engine cap
Filter
Plugs Valve
Cleaner
Filter
(VIN) Radiator
Fuel
Spark"
PCV Air Oil
4.3L (Z) PF51 A773C
*Use copper-cored resistor type spark plugs. RC36 GF481
.CR43TS CV892C
A1163C PF51
4.3L (W)
RC36 GF481
CR43TS
CV789C
Filter
TO005
6-70

Downloaded from www.Manualslib.com manuals search engine Scheduled Maintenance Services
Explanation Of Scheduled Maintenance Services
Below are explanations of the services listed in the maintenance charts.
The proper fluids and lubricants to use are listed in this section. Make sure
whoever services your vehicle uses these. All parts should be \
replaced and
all necessary repairs done before you or anyone else drives th\
e vehicle.
1. ENGINE OIL AND OIL FILTER CHANGE* -ALWAYS USE SG OR
SG/CE QUALITY, ENERGY CONSERVING II OILS OF THE PROPER
VISCOSITY.
To determine the preferred viscosity oil for your vehicle’s
engine (e.g. SAE 5W-30). See “Engine Oil” in the Index.
bushings, steering linkage, transfer case shift linkage, parking \
brake cable
guides, propshaft splines, universal joints and brake pedal spri\
ngs at the
intervals specified on the proper maintenance schedule or at ev\
ery
engine oil change, whichever comes first.
2.
CHASSIS LUBRICATION -Lubricate the front suspension, king pin
Ball joints and king pin bushings should not be lubricated unl\
ess their
temperature is
10°F (-12”C), or higher. When the weather is cold, let
them warm up before lubrication or they could be damaged.
Also, be sure to check all the vehicle fluid levels at this time.
3.
COOLING SYSTEM SERVICE* -Drain, flush and refill system with new
coolant. See the Index under “Engine Coolant” for the pro\
per coolant and mixture to use in your vehicle.
Also inspect the hoses and replace them
if they are cracked, swollen, or
deteriorated. Tighten all hose clamps. Clean the outside of the radiator
and air conditioning condenser. Wash the radiator neck.
To ensure proper
operation, pressure test the radiator and cap.
4. AIR CLEANER FILTER REPLACEMENT* -Replace at specified
intervals. Replace more often under dusty conditions. Ask your \
dealer for
the proper replacement intervals for your driving conditions.
5. FRONT WHEEL BEARING REPACK (2-WHEEL DRIVE ONLY) -Clean
and repack the front wheel bearings at each brake relining, or at the
specified interval, whichever comes first.
* An Emission Control Service

Downloaded from www.Manualslib.com manuals search engine fNDEX
K
Keys ................................................ 2-3
L
Lights ............................................. 2-40
Dome
......................................... 2-44
Fog Lamps
................................ 2-42
Front Parking
............................ 6-36
Indicator
..................................... 2-64
Taillights
..................................... 6-37
Interior Override Switch
............ 2-45
Operation
................................... 2-31
Reading
..................................... 2-44
Turn Signal
................................ 6-36
Loading Your Vehicle
................... 6-42
Lubrication
..................................... 6.39
Accelerator Control System
..... 6-39
Body
........................................... 6-40
Front Suspension and Steering Linkage
................... 6-38
Front Wheel Bearings
(Two-Wheel Drive)
................. 6-38
Latches and Hinge
................... 6-40
Lock Cylinders
.......................... 6-41
Propeller Shaft Slip
SplinesAJniversal Joints
........ 6-40
Rear Axle
.................................. 6-23
Transfer Case
........................... 6-23
Luggage Carrier
............................ 2-49
M
Maintenance .................................... 7-2
Other Items
............................... 6-38
Periodic Inspections
.................. 7-13
Record
....................................... 7-1 6
Scheduled Maintenance
..... 7.3. 7-8
Underbody
................................. 6-58
Mirrors
........................................... 2-45
Inside
......................................... 2-45
Outside
............................ 2.46. 2-47
Vanity
......................................... 2-48
Model Reference
............................... iii
When Towing
a Trailer
............. 4-49
0
Odometer ....................................... 2-56
Trip
............................................. 2-57
Oil
.................................................... 6-9
Additives
.................................... 6-14
Disposal of Used
...................... 6-15
Pressure Gage
.......................... 2-62
To Check
................................... 6-10
What Kind
to Use ..................... 6-12
When
to Change ...................... 6-14
Owner Checks and Services
....... 7-11
P
Off -Road Recovery ....................... 4-20
Parking Brake
.......................................... 2-20
Downhill
..................................... 4-38
On Hills
............................ 4-37, 4-49
Uphill
.......................................... 4-38
Passing Other Vehicles
...... 4-21, 4-48
Pavement Markings
........................ 4-7
Payload Capacity
.......................... 6-43
Periodic Maintenance Inspections7-13
Power Mirrors
........................................ 2-47
Other Options
............................ 6-38
Seat
.............................................. 1-2
Visor Vanity
............................... 2-48
Windows
.................................... 2-26
Fluid
........................................... 6-30
Product Service Publications
......... 8-6
R
Radiator Pressure Cap ................ 6-29
Radio (See “Audio Systems”) Over Things That Burn
............ 2-23
Power Steering
............................. 4-18
Reading Lights
.............................. 2-44
Rear Defogger
................................ 3-8
Rear Hatch/Split-Panel Doors
........ 2-8
Rear WiperNVasher
...................... 2-34
Recommended Fluids/Lubricants
. 7-14
Reporting Safety Defects
............... 8-4
9-4