Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF
Fuse
layout
<*'om
left
to
right)
No.
Component
A11
' - Dipped beam
left,
headlight range control
left
10
I- Dipped beam
right,
headlight range control
right
10
3-
Instrument
and number plate lighting 10
--
Rear
wiper, seat heating 15
5-
Windscreen wiper,
windscreen and rear window
washer/elec.
heated
washer
jets 15
5-
Blower, air conditioner 30
/- Tail and side
light
right,
engine compartment
light
10
3-
Tail and side
light
left
10
9-
Rear
window heating, mirror heating 20
10-
Fog lights, rear fog
light
15
II- High beam
left,
high beam
warning lamp 10
12-
High beam
right
10
13-
Horn, radiator fan (run-on) 10
1 Ampere No.
Component
A
14-
Reversing lights, electric outside mirrors, sliding/tilting
roof,
shift pattern auto, gearbox,
cruise
control system
(cancel contacts on the brake
and clutch pedal) 10
15-
Engine electronics 10
16-
Warning lamps,
dash
panel insert,
glove box
light
15
17-
Turn signals 10
18-
Electric fuel pump,
Lambda
probe 20
19-
Radiator fan, air conditioner 30
20-
Brake lights 10
21-
Interior
and luggage compartment lights, make-up mirror
light,
clock,
radio,
central locking 15
22-
Cigarette lighter 10
Additional
fuses
(in separate holders)
• above the relays A11
Fuse
for electric windows 20
• In the engine compartment on the bulk
head
above the brake servo:
Glow
plugs21 50
• Under the driver's seat
Fuse
for additional water heater 10
Fuse
for heater blower .30
Fuse
for water heater
glow plug 20
Fuse
for auxiliary heater3' 25
Fuse colour code:
Red:
10 Ampere
Blue:
15 Ampere
Yellow:
20 Ampere
Green:
30 Ampere
21 This fuse should only be renewed by
a
Volks
wagen dealer.
31 On vehicles
with
swivelling seats this fuse
can
be found in the side
trim
behind the
driver's seat.
123
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans
Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF
Masking
headlights
When the vehicle is used in a country which drives on the opposite side
of
the road to the
home country,
the
asymmetric dipped neadlights
will
dazzle oncoming
traffic.
To prevent this,
the
wedge-shaped sector on the headlight lenses must be covered
up
with
an
opaque adhesive strip.
The illustration shows
the
strip installed
for
the change
from
right
hand
to
left
hand
traffic.
Installing
radio
When service installing
a
radio
or
replacing
a
set
installed
by the
factory
the
following points should
be
noted:
•
The
connection*
in the
vehicle
is for
Genuine
Volkswagen radios11
from
Model
Year
1988. The supply plug has the following
wire colours and connections:
Red/white Permanent positive
(+)
Brown Negative
(-)
vehicle earth
Grey/blue
Instrument
panel lighting
Brown/red* Control wire
for
"Ignition
key" switching radio
on/
off. On no account use this
connection
for
operating
voltage supply.
Blue/white*
Speed
signal
for
automatic volume control
•
Radios
with
other connections must
be
connected
with
an adapter cable which can
also
be obtained
from
a Volkswagen dealer.
11 Not available
in all
export markets
Attention
On
no account cut wires off and
leave
them
without
insulation. If
necessary
use a proper adapter.
Otherwise the wiring can be
overloaded or short circuits can
occur
- Fire danger!
Apart from this important elec
tronic components can be damaged or the functioning impaired. If for
example the speed signal is
dis
turbed this can lead to
faulty
man agement of engine, automatic gearbox, ABS etc.
Even
connecting the speed signal to
radio sets
with
speed dependent
vol
ume control from other manufac
turers can cause
such
faults.
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans
