1991 LEXUS SC300 center console

Parts Inspection
(Ignition Switch and Key Unlock
Warning Switch)
REMOVAL AND INSTALLATION OF
IGNITION SWITCH AND KEY UNLOCK
WARNING SWITCH
1. DISCONNECT BATTERY TERMINALSCAUTION: Work must be started after approx. 20 se-
conds or longer from the time the ignition switch is
turned to the ºLOCKº position and negative (±) terminal
cable is disconnected from the battery.
2. REMOVE FOLLOWING PARTS: (See page BO±112)
w No. 1 under cover
w No. 1 lower finish panel
w Console box assembly
w Instrument panel lower center
3. REMOVE IGNITION SWITCH (a) Disconnect connector.
(b) Remove three screws and the switch from the keycylinder and wire harness clamp.
4. INSTALL IGNITION SWITCH For installation, follow the removal procedure in reverse.
INSPECTION OF IGNITION SWITCH AND
KEY UNLOCK WARNING SWITCH
1. INSPECT IGNITION SWITCH(Switch continuity)
Inspect the switch continuity between terminals.
Terminal
Switch position LOCKACC
ON
START
If continuity is not as specified, replace the switch.
BE±26
±
BODY ELECTRICAL SYSTEM Ignition Switch
WhereEverybodyKnowsYourName

Page 3 of 11
AIR CONDITIONING EVAPORATOR ODOR ± AC001±97 September 12, 1997
ES 3001. Removal of parts.
('92±'96) (a) Pull down the carpet from the center
console as indicated by red arrow in the
illustration.
(b) Remove the plate on the side of the heater unit using steps and
,
indicated with red arrows to show
direction, in the illustration.
CAUTION:
Do not bend the cable.
NOTE:
The Plate will be reused.
(c) Remove the filter.
(d) Remove the blower controller.
2. Clean the Evaporator. Follow the general procedures given
on page 2.
NOTE:
Location for insertion of spray nozzle
is indicated by the red arrow in the
illustration.
WhereEverybodyKnowsYourName

234
AUTOMATIC AIR CONDITIONER
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
EB134ENGINE WIRE AND ENGINE ROOM MAIN WIRE (FRONT SIDE OF R/B NO. 2)
IE136ENGINE ROOM MAIN WIRE AND COWL WIRE (R/B NO. 4)
IE236ENGINE ROOM MAIN WIRE AND COWL WIRE (BEHIND GLOVE BOX)
IG136INSTRUMENT PANEL WIRE AND COWL WIRE (R/B NO. 5)
II136ENGINE WIRE AND A/C WIRE (BEHIND GLOVE BOX)
IJ236ENGINE WIRE AND COWL WIRE (RIGHT KICK PANEL)
IK136ENGINE WIRE AND INSTRUMENT PANEL WIRE (RIGHT KICK PANEL)
IN138ENGINE ROOM MAIN WIRE AND A/C WIRE (BEHIND GLOVE BOX)
IQ138INSTRUMENT PANEL WIRE AND CONSOLE BOX WIRE (UNDER THE INSTRUMENT PANEL CENTER)
IR138CONSOLE BOX WIRE AND A/C SUB WIRE (BEHIND GLOVE BOX)IR238CONSOLE BOX WIRE AND A/C SUB WIRE (BEHIND GLOVE BOX)
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
EA34FRONT SIDE OF RIGHT FENDER
EB34FRONT SIDE OF LEFT FENDER
ED34REAR SIDE OF INTAKE MANIFOLD
IF36LEFT KICK PANEL
IJ36RIGHT KICK PANEL
: SPLICE POINTS
CODESEE PAGEWIRE HARNESS WITH SPLICE POINTSCODESEE PAGEWIRE HARNESS WITH SPLICE POINTS
E1134ENGINE ROOM MAIN WIREI2838CONSOLE BOX WIREE1834ENGINE WIREI2938CONSOLE BOX WIRE
I2738A/C WIREI3238ENGINE WIRE
WhereEverybodyKnowsYourName

4
XXXX10 4
XXXX10
BDB
R2 R2
A32
12 3
45678 A
A32
13
8X A
R4
3
89
C
R5
X23 456
7891011121314
205
A32 AUTO ANTENNA MOTOR AND RELAY
3±GROUND : ALWAYS APPROX. 12 VOLTS
6±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ON POSITION
8±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ACC OR ON POSITION
7±GROUND : ALWAYS CONTINUITY
R 4(A), R 5(C) RADIO AND PLAYER
(A) 3, (C) 3±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ACC OR ON POSITION
: PARTS LOCATION
CODESEE PAGECODESEE PAGECODESEE PAGE
A32A30R2A29 (W/ CD PLAYER)R 4B29 (W/ CD PLAYER)A32B30R 2D29 (W/O CD PLAYER)R 5C29 (W/O CD PLAYER)
: RELAY BLOCKS
CODESEE PAGERELAY BLOCKS (RELAY BLOCK LOCATION)
219ENGINE COMPARTMENT LEFT
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1C20FLOOR WIRE
1E20INSTRUMENT PANEL WIRE
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
IE136ENGINE ROOM MAIN WIRE AND COWL WIRE (R/B NO. 4)
IG236INSTRUMENT PANEL WIRE AND COWL WIRE (R/B NO. 5)
IQ138INSTRUMENT PANEL WIRE AND CONSOLE BOX WIRE (UNDER THE INSTRUMENT PANEL CENTER)IQ238INSTRUMENT PANEL WIRE AND CONSOLE BOX WIRE (UNDER THE INSTRUMENT PANEL CENTER)
BV140FLOOR NO 3 WIRE AND CONSOLE BOX WIRE (UNDER THE INSTRUMENT PANEL CENTER)BV240FLOOR NO. 3 WIRE AND CONSOLE BOX WIRE (UNDER THE INSTRUMENT PANEL CENTER)
Bc140FLOOR NO 3 WIRE AND FLOOR WIRE (UNDER THE LEFT SIDE OF REAR SEAT CUSHION)Bc240FLOOR NO. 3 WIRE AND FLOOR WIRE (UNDER THE LEFT SIDE OF REAR SEAT CUSHION)
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
BM40BACK PANEL CENTER
: SPLICE POINTS
CODESEE PAGEWIRE HARNESS WITH SPLICE POINTSCODESEE PAGEWIRE HARNESS WITH SPLICE POINTS
I3138CONSOLE BOX WIRE
SERVICE HINTS
WhereEverybodyKnowsYourName

208
CELLULAR MOBILE TELEPHONE
T16 (A) TELEPHONE TRANSCEIVER AND SPEAKER RELAY
(A) 9±GROUND : ALWAYS APPROX. 12 VOLTS
(A) 10±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ACC OR ON POSITION
(A) 11±GROUND : ALWAYS CONTINUITY
: PARTS LOCATION
CODESEE PAGECODESEE PAGECODESEE PAGE
C1628R 4A29 (W/ CD PLAYER)S1431
F1230R 5B29 (W/O CD PLAYER)T16A31
M 131R 6C29 (W/O CD PLAYER)T17B31
: RELAY BLOCKS
CODESEE PAGERELAY BLOCKS (RELAY BLOCK LOCATION)
219ENGINE COMPARTMENT LEFT
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1C20FLOOR WIRE
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
IP138FRONT DOOR RH WIRE AND COWL WIRE (RIGHT KICK PANEL)
BS140ENGINE ROOM MAIN WIRE AND FLOOR WIRE (LEFT KICK PANEL)
BT140FLOOR WIRE AND COWL WIRE (LEFT KICK PANEL)
BV140FLOOR NO 3 WIRE AND CONSOLE BOX WIRE (UNDER THE INSTRUMENT PANEL CENTER)BV240FLOOR NO. 3 WIRE AND CONSOLE BOX WIRE (UNDER THE INSTRUMENT PANEL CENTER)
Bc140FLOOR NO 3 WIRE AND COWL WIRE (UNDER THE LEFT SIDE OF REAR SEAT CUSHIONBc240FLOOR NO. 3 WIRE AND COWL WIRE (UNDER THE LEFT SIDE OF REAR SEAT CUSHION
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
EB34FRONT SIDE OF LEFT FENDER
: SPLICE POINTS
CODESEE PAGEWIRE HARNESS WITH SPLICE POINTSCODESEE PAGEWIRE HARNESS WITH SPLICE POINTS
I 338COWL WIREB3440FLOOR MAIN WIREI 838COWL WIREB3540FLOOR MAIN WIRE
I 2638ENGINE ROOM MAIN WIREB3640FLOOR NO. 3 WIRE
B 840FLOOR MAIN WIRE
SERVICE HINTS
WhereEverybodyKnowsYourName

39
CODEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
IN1ENGINE ROOM MAIN WIRE AND A/C WIRE (BEHIND GLOVE BOX)
IO1ENGINE ROOM MAIN WIRE AND INSTRUMENT PANEL WIRE (RIGHT KICK PANEL)
IP1FRONT DOOR RH WIRE AND COWL WIRE (RIGHT KICK PANEL)IP2FRONT DOOR RH WIRE AND COWL WIRE (RIGHT KICK PANEL)
IQ1INSTRUMENT PANEL WIRE AND CONSOLE BOX WIRE (UNDER THE INSTRUMENT PANEL CENTER)IQ2INSTRUMENT PANEL WIRE AND CONSOLE BOX WIRE (UNDER THE INSTRUMENT PANEL CENTER)
IR1CONSOLE BOX WIRE AND A/C WIRE (BEHIND GLOVE BOX)IR2CONSOLE BOX WIRE AND A/C WIRE (BEHIND GLOVE BOX)
WhereEverybodyKnowsYourName

41
CODEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
BS1ENGINE ROOM MAIN WIRE AND FLOOR WIRE (LEFT KICK PANEL)
BT1FLOOR WIRE AND COWL WIRE (LEFT KICK PANEL)
BU1INSTRUMENT PANEL WIRE AND FLOOR WIRE (LEFT KICK PANEL)
BV1
BV2FLOOR NO. 3 WIRE AND CONSOLE BOX WIRE (UNDER THE INSTRUMENT PANEL CENTER)
BV3
FLOOR NO. 3 WIRE AND CONSOLE BOX WIRE (UNDER THE INSTRUMENT PANEL CENTER)
BW1ENGINE ROOM MAIN WIRE AND FLOOR NO. 3 WIRE (RIGHT KICK PANEL)
BX1FLOOR NO. 3 WIRE AND COWL WIRE (RIGHT KICK PANEL)
BY1INSTRUMENT PANEL WIRE AND FLOOR NO. 3 WIRE (RIGHT KICK PANEL)
BZ1ROOF WIRE AND MOON ROOF WIRE (FRONT SIDE OF ROOF LEFT)
Bc1FLOOR NO 3 WIRE AND FLOOR WIRE (UNDER THE LEFT SIDE OF REAR SEAT CUSHION)Bc2FLOOR NO. 3 WIRE AND FLOOR WIRE (UNDER THE LEFT SIDE OF REAR SEAT CUSHION)
Bd1FLOOR NO. 3 WIRE AND LUGGAGE NO. 2 WIRE (RIGHT SIDE OF LUGGAGE COMPARTMENT)
WhereEverybodyKnowsYourName

240
GROUND POINT
: RELAY BLOCKS
CODESEE PAGERELAY BLOCKS (RELAY BLOCK LOCATION)
219ENGINE COMPARTMENT LEFT
422LEFT KICK PANEL (J/B NO.1 LEFT)
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1D20FRONT DOOR LH WIRE
1E20INSTRUMENT PANEL WIRE
1F20ROOF WIRE
1G20COWL NO. 2 WIRE
1H
1J20COWL WIRE
1K
20COWL WIRE
3A
3D
3F22INSTRUMENT PANEL WIRE
3G
22INSTRUMENT PANEL WIRE
3H
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
IE136ENGINE ROOM MAIN WIRE AND COWL WIRE (R/B NO.4)
IE236ENGINE ROOM MAIN WIRE AND COWL WIRE (BEHIND GLOVE BOX)
IF236FRONT DOOR LH WIRE AND COWL WIRE (LEFT KICK PANEL)
IG136INSTRUMENT PANEL WIRE AND COWL WIRE (R/B NO.5)
IH136COWL NO. 2 WIRE AND COWL WIRE (BEHIND COMBINATION METER)
IJ136ENGINE WIRE AND COWL WIRE (RIGHT KICK PANEL)
IK136ENGINE WIRE AND INSTRUMENT PANEL WIRE (RIGHT KICK PANEL)IK236ENGINE WIRE AND INSTRUMENT PANEL WIRE (RIGHT KICK PANEL)
IN138ENGINE ROOM MAIN WIRE AND A/C WIRE (BEHIND GLOVE BOX)
IP138FRONT DOOR RH WIRE AND COWL WIRE (RIGHT KICK PANEL)
IQ138INSTRUMENT PANEL WIRE AND CONSOLE BOX WIRE (UNDER THE INSTRUMENT PANEL CENTER)IQ238INSTRUMENT PANEL WIRE AND CONSOLE BOX WIRE (UNDER THE INSTRUMENT PANEL CENTER)
BS140ENGINE ROOM MAIN WIRE AND FLOOR WIRE (LEFT KICK PANEL)
BT140FLOOR WIRE AND COWL WIRE (LEFT KICK PANEL)
BU140FLOOR WIRE AND INSTRUMENT PANEL WIRE (LEFT KICK PANEL)BU240FLOOR WIRE AND INSTRUMENT PANEL WIRE (LEFT KICK PANEL)
BV240FLOOR NO. 3 WIRE AND CONSOLE BOX WIRE (UNDER THE INSTRUMENT PANEL CENTER)
BX140FLOOR NO. 3 WIRE AND COWL WIRE (RIGHT KICK PANEL)
BY140INSTRUMENT PANEL WIRE AND FLOOR NO. 3 WIRE (RIGHT KICK PANEL)
BZ140ROOF WIRE AND MOON ROOF WIRE (FRONT SIDE OF ROOF LEFT)
Ba142FLOOR WIRE AND FRONT SEAT LH WIRE (UNDER THE FRONT LH SEAT)Ba242FLOOR WIRE AND FRONT SEAT LH WIRE (UNDER THE FRONT LH SEAT)
Bb142FLOOR NO. 3 WIRE AND FRONT SEAT RH WIRE (UNDER THE FRONT RH SEAT)
Bd142FLOOR NO. 3 WIRE AND LUGGAGE NO. 2 WIRE (RIGHT SIDE OF LUGGAGE COMPARTMENT)
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
EA34FRONT SIDE OF RIGHT FENDER
EB34FRONT SIDE OF LEFT FENDER
EC34REAR SIDE OF INTAKE MANIFOLD
ED34REAR SIDE OF CYLINDER HEAD RH
IF36LEFT KICK PANEL
IG36INSTRUMENT PANEL BRACE LH
IH36UNDER THE ASHTRAY LH
II36UNDER THE ASHTRAY RH
IJ36RIGHT KICK PANEL
BK40UNDER THE CENTER PILLAR LH
BL40UNDER THE CENTER PILLAR RH
BM40BACK PANEL CENTER
WhereEverybodyKnowsYourName