1990 VOLKSWAGEN TRANSPORTER oil change

Downloaded from www.Manualslib.com manuals search engine
VEHICLE
CARE
I

AIR CLEANER
A
dirty
filter
element reduces engine
out­
put and increases fuel consumption and

can
cause premature engine wear.
Normally, it is not required to service the
air cleaner more often than recommended in the Maintenance booklet. If the vehicle

is
driven on very dusty roads, the air

cleaner
must be serviced more frequently,

even
daily. We recommend
that
you have
the air cleaner serviced by your
Volks­

wagen dealer or a qualified workshop.
If
your
air
filter
must
be
changed more
frequently,
we
recommend
that
you have
your
Volkswagen dealer show
you the
procedure
before
you
attempt
doing
it

yourself.

The
paper
filter
element must never
be
cleaned
or
soaked
with
gasoline, clean­

ing
solvents or oil. POWER STEERING*
The
fluid
reservoir is located behind the
licence
plate lid.

The
power steering is filled
with
ATF Dexron®.

A
correct
fluid
level in the reservoir is im­
portant
for the proper functioning of
power steering.
With the engine running, the
fluid
level in the power steering system must be
checked
at regular intervals. The
fluid
level
should always be between the "max"
and "min" markings. If the level should go below the "min" marking, have the power
steering system inspected by your
Volks­

wagen dealer. It is not sufficient to
just
add hydraulic fluid.
WARNING

•
Be
sure
not to
confuse brake fluid

and
hydraulic fluid.
If
the wrong fluid
is
used,
the systems may fail.

•
If the
power steering system should

fail,
or if the
engine
is not
running
(for

example
while
being
towed),
you
will
still
be
able
to
steer
the
vehicle, how­
ever, more
effort
will
be required.
Note

Since
the hydraulic
fluid
also functions as

a
lubricant, serious damage to the pump
and to other components of the system
could result if there is insufficient hydraulic

fluid
in the system.

Always
heed WARNINGS on page
97. "where applicable


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE
CARE

COOLING
SYSTEM
The cooling system
is
sealed and gener­ ally requires little attention.
The cooling system has been filled at the factory with
a
permanent coolant which
does not need to be changed. The coolant

consists
of a
mixture
of
water
and the
manufacturer's coolant additive
G 11 —

antifreeze
on
glycol basis with anticorro-
sion additives (40% for USA
models;
50%
for Canadian models).
This
mixture
assures
the
necessary frost protection
and protects
the
entire cooling system
against corrosion and
scaling,
and raises
the boiling point of the coolant.
Do
not
reduce
the
concentration
of the

coolant
in the
summer
by
adding plain
water.
The coolant additive proportion
must
be at least
40%
but not more than

60%,
to
maintain the antifreeze protection
and the cooling efficiency. For year round driving, antifreeze is added
at the factory for temperatures down to:

-13°
F/-25°C(USA)

-40°
F/-40°
C
(Canada)

Only
use
quality phosphate-free
anti­

freeze containing ethylene glycol. Such antifreeze
is
available at
your
Volkswagen

dealer.

WARNING Antifreeze is poisonous. Always store antifreeze in its original container and

well
out of the reach of children. If you drain
the
coolant,
it must
be
caught
and

safely stored. Drained coolant should normally not be reused. Always des-

pose
of used coolant observing all en­
vironmental regulations.
Coolant losses
Coolant losses may indicate
a
leak in
the

cooling
system.
In
this
case,
the
cooling
system should
be
inspected immediately by
your
Volkswagen dealer.
It is not
suffi­

cient merely to add coolant.

In a
sealed system, losses can only occur
if
the
boiling point
of the
coolant
is ex­

ceeded as
a
result of overheating.
Overheating can occur
if:

•
the
flow
of air to the
radiator
is

obstructed
by
leaves, dust, insects
or by

additional
lights installed
in
front
of the
radiator grille;

•
the boiling point of the coolant has been
reduced
due to an
incorrect mixture
of

coolant and water;

•
the
radiator fan
is not
working
- see

"Radiator
fan",
or;

•
the vehicle is being driven up
a
long
hill
j

in
a
low gear with engine speed
very
high
and
at
very
high ambient temperature
-

see
"Radiator fan".

If
the cause for the overheating cannot
be

determined
and
corrected, contact
your

Volkswagen dealer immediately, other-
I
wise serious engine damage could result.

104
Always
heed
WARNING on page
97.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF-SERVICE

LIFTING
VEHICLE

The vehicle should
never
be lifted or
jacked
up from underneath the engine
oil
pan, the transmission housing, or the

front
or rear axle.
This
could lead to serious damage.
The same lifting points as illustrated for the hoist also apply when using a floor jack. To
avoid damage to the underbody or chassis

frame,
it is necessary to insert a rubber pad between the floor jack and the lift

points.

Lifting
with workshop hoist
and with floor jack

Make
sure there is sufficient clearance
between pads and vehicle before driving
vehicle on to hoist.
WARNING
When removing components such as engine block, transmission housing,

fuel
tank, wheels,
front
or rear axle, anchor vehicle to hoist or add corre­
sponding weights to maintain the cen­
ter of
gravity.
Otherwise the vehicle
might tilt or slip off the hoist, causing
serious damage or personal
injury.
•
To reduce the risk of serious perso­

nal
injury
and vehicle damage, lift
vehicle only at the special workshop hoist and floor jack lift points illustra­

ted.
Failure to lift vehicle at these points could cause the vehicle to tilt or
fall

from a lift when, for example,
heavy
components such as the engine block
or transmission are removed result­
ing
in a change in vehicle weight and

balance.

•
If you must lift
your
vehicle with a
floor jack to work underneath, be sure
the vehicle is safely supported on
stands
intended for this purpose.
Lifting
points

Front

At the
front
jacking point.
Rear

At rear cross member.
The vehicle must be lifted only at the lift
points illustrated.

Lifting
with vehicle jack Refer to the "Changing a wheel" on page

125.

140


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
TECHNICAL DATA

V-BELTS
CAPACITIES
for waterpump/alternator. 9.5 x 1100 LA
Fuel
tank 16.0 gal/60 liters
for A/C compressor . . . 12.5x1153 LA Syncro:
for power steering .... 9.5 x 1080 18.5 gal/70 liters Noteg
Reserve
(of
total
capacity) >. .. 2.5 gal/10 liters
The V-belts are among the most severely Coolin3
sVstem186
^t/17-5 ll,ers
stressed
parts of a vehicle. The belts there- Automatic
fore have very high quality requirements. transmission fluid (ATF) 3.2 qt/3.0 liters
When replacing a belt, it is not sufficient to Windshield washer container 4.3 qt/4.2 liters
use
just
any belt of the same
size.
For safe
operation, use only Original Volkswagen
Rear
window washer container 1.1 qt/1.0 liters

V-belts
specially designed for your Engine oil

vehicle.
The correct belts can be obtained
with
filter
change 4.8 qt/4.5 liters at your Volkswagen dealership.
without
filter
change 4.2 qt/4.0 liters

Do
not
fill
above "max" mark.
The oil level should be checked while topping up.
Difference between "min" and "max" marks
on the dipsticks is approx. 1 qt/1 liter


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
ALPHABETICAL INDEX
page
Introduction 2
Instrument illumination 46
Instrument panel 4 Instruments 40
Interior light 63,133
Jack and tools 123 Jack points 126
Keys 7
Kickdown 37
Lane changer 48
License plate lights 133 Lifting vehicle 140
Light switch 46 Light alloy wheels 92
Lights 46,130
Locks 7
Lubricants 98
Luggage compartment 28
Maintenance 95
Maintenance booklet 2
Manual Transmission 32 Manual Transmission Oil 102
Mirrors 13
Notes to owner 2 page
Octane rating 86
Oil change 100
Oil filter changing 101 Oil pressure warning light 43
OXS (Oxygen sensor) 144
Parking 31,145
Parking brake 31 Pedals 29
Power steering 103
Power windows 12
Radio 5, 135
Rear lid 11 Rear seat bench/bed combination 26
Rear view mirrors 13
Rear window defogger 47
Rear window wiper/washer 50
Refill Tank 105
Reverse 32
Roof rack 68
Safe driving hints 70
Safety belts 14
Safety belts warning light 18
Safety compliance sticker 151
Seats 20 Secondary heat exchanger 53
Selector lever 35 page
Service manuals 152 Side marker lights 132
Sliding door 10 Sliding roof 62
Sliding windows 12
Snow chains 119 Spare wheel 124
Spark plugs 146
Speedometer 40
Speed ranges 69
Starter switch 38 Starting procedures 39
Steering lock 38
Stopping engine 39
Sunroof 62 Sun visors 67
Switches 46
Swivel seats 22 Syncro Differential lock 33
Driving with the-all-wheel-drive . . 75
Snow chains 119
Technical Information 142 Towing 139
Tachometer 41
Tail lights 132
Technical data 146


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans