1981 CHEVROLET MONTE CARLO towing

Downloaded from www.Manualslib.com manuals search engine Chevrolet's turbocharger incUles a "TlI'bo Control Center," which is an
electronic,
closed- loop, high energy spark control system that permits the use
of today's compression ratios with unleaded fuels. It works to control spark and
provide
good driveability. H automatically compensates for fuel octane,
atmospheric conditions,
load, and .other driving conditions, by continually monitoring engine detonation and adjusting the spark.
Are There Any Tricks To Driving A Turbocharged V-61
No, riot at all. Starting procedures are as covered on Page 2-8.
As with any normal engine, the turbocharged engine should not be run at
excessive
RPM immediately upon starting or shut down abruptly after running
at high
speeds.
Trailer
Towing: It should be noted that the Turbo V-6 engine uses advanced
electronic technology to provide a combination of performance and fuel
economy under most operating conditions, including driving in high-altitude
areas . Uke 'most V-6 engines, ~is su~abIe for pul~ng light-dutytrailers up to
450 kilograms (1,000 pounds) gross weight. However, the system was not
engineered for the rigors of towing
heavytraii for
specffic recommendations) .
Don't Attempt Do-tt-Yourself Fixes: The turbocharger has but a handful of
parts, but since it is precision-manufactured with some tolerances as fine as
1/1 ,000,000 of an inch, maintenance and repairs should be done by an
authorized Chevrolet dealer or other qualified service outlet which
regularly
does such servk:e.
Catch Trouble Before . It Becomes Major: The turbocharger is an integral part
of your engine and not ar\'add-on .device.1f you spot an oil leak or hear an
unusual sound coming from the turbocharger , take it
In for service immediately .
The trouble may be simple to correct, but if allowed to continue, may
necessitate a more costly repair.
Normaf Scheduled Maintenance -
with Two Exceptions: The recommended
maintenance for the turbocharged
V -6 engine is shown in the General Motors
Maintenance
Schedule found in the glove compartment of your Chevrolet. The
turbocharged engine requires basically the same maintenance as a regular V-6
with two ",xceptions :
Engine Oil Change -every 3,000 miles.
Oil Filter Change -every 3,000 miles .
2-33

Downloaded from www.Manualslib.com manuals search engine JACKING
CAUTION
To help avoid personal injury:
• Follow air jacking and stowage instructions.
• Use jack only for lifting this vehicle during wheel change.
• Never get . beneath the vehicle, start or run engine while vehicle is supported by jack.
• Always securely restol" sp!.re tire (orflattire) and all jac king equipment.
Wheel Nut Torque .
CAUTION: As soon as possible atter installing a wheel -AND at the intervals stated
In Section 'S of the Maintenanc," Schedule folder --have a technician tighten wheel nuts with a torque wrench to the specifications shown in "Specifications," Section 7 of this manual.
Wheel nuts should be tightened alternately and evenly to the correct torque.
Never use oil or grease on studs Of nuts.. Jrnproperty tightened wheel nuts could eventually aUow the whee! to come off while the veNeta Is moving, -po$$rbty causing
personal injury , damage and/or klss of c_ontrol. (Also see the "Replacement Fasteners" Caution In "Service and Maintenance ," Section 5 01 this m8nu81 regarding the danger of mixing metric and custom,sry fasteners. And, see the "Replacement Fasteners " Caution
under "Tires" in the same seclion regarding the importance of obtaining good metal-to­
metsl contact.)
Stowage ·of. Tire . and .!aC;.k,. . .
CAUTION: Always securely restow the spare tire assembfy (or nat tire), all jacking equipm ent, any tire inflator, and any covers or doors, using the means provided. This will help keep such things from being thrown about-and injuring people In the vehicta d.Ufing a sudden maneuver or an accident.
Before stowing
the tire, be sure:to clean the tire well 01 anything that would keep the tlr. from resting on the bOttom of the well. To stow the jack, place its lever in the "UP" position and. move the handle back and forth until the column is ·secure in the receiver (see Illustration). If these steps are not taken, the tire or lack may push against the trunk lid so thai the trunk lid cannot seal tightly. This _ may allOw carbon monoxide from the '. exhaust system -to get _inside tiMt c • . ttvougtl the trunk. (See "Engine -Exhaust Gas Caution (CaroonMonoxkle) " al the beginning of "Starting and Operating,'; Section 2 of this manual .)
Extended Vehicle Storage
If you plan to store your vehicle over an extended periOd of time, certain steps
should be taken to give it maximum protection.
It is recommended that you
write the Chevrolet Motor Division , General Motors Corporation, Consumer
Relations Dept., Warren , Michigan
48090, for detailed instructions on how to
prepare your vehicle for storage .
3-7

Downloaded from www.Manualslib.com manuals search engine Towing
Proper equipment .must be used to prevent damage to vehicles during any
towing. State (Provincial in Canada) and local laws which apply to vehicles in
tow must be
followed. Get detailed towing instructions from your dealer.
Your vehicle
may be towed on all four wheels, at speeds less than 35 mph (60
km/h), for distances up to 50 miles (80 kilometers), provided the driveline and
steering are normally operable. For such towing, the steering must be unlocked, transmission in neutral and the· parking brake released. Connect to
main structural parts of the vehicle. Do NOT attach to bumpers or brackets.
Remember also that power assist for brakes and steering will not be available when the engine is off.
If the vehicle is to be towed by a wrecker, use only equipment designed for this purpose, following the instructions of the wrecker manufacturer. A safety Chain
system must be used for all towing.
FREEING VEHICLE FROM SAND, MUD, SNOW OR
ICE
If your vehicle gets stuck in sand, mud, snow or ice, move the shift lever on automatic transmission models from "0" (Drive) to "R" (Reverse) in a repeat
pattern.
Apply a light pressure to the accelerator pedal while the transmission is in gear. Remove your foot from the accelerator while shifting. Do not race
the engine. For best traction, avoid spinning the wheels. Incorrect rocking of your vehicle while it is stuck may result in damage to vehicle components.
CAUTION: Do not spin the wheels faster than 35 mph (55 km/h). Personal injury and
damage (inCluding tire, transmission and/or rear axle failure) may result from excessive
wheel spinning.
If the vehicle remains stuck after several rocking attempts, seek other
assistance. Also see the Notice under '(Automatic Transmissions" in "Steering
Column-Controls," Section 2 of this manual.
3-9

Downloaded from www.Manualslib.com manuals search engine FUEL CAP
The fuel cap is.behind the. rear license plate.
NOTICE: tt you need: to repWce the fuel cap, use only a cap with these same features as specifie your dealer.
The fuel tank filler cap has a "screw-on ratcheting type" feature .
• _ To remove -rotate cap counterclockwise to clear the inside of the filler
neck. This will allow any residual pressure to escape .
_ To install -reverse this procedure and tighten cap securely until a
"ratcheting ". clicking sound is heard indicating cap is on properly.
CATALYTIC CONVERTER
.Ttle .cal;!ly:tic converter is an emission control device added to the exhaust system,' to reduce exhaust gas pollutants. The converter contains
a ceramic material coated with noble metal catalysts. To prevent contamination
of the catalysts , unleaded gasol;"" must be used . Unleaded gasoline also
reduces spark plug louling. exhaust system corrosion and engine oil
deterioration.
The catalytiC converter requires the use of unleaded gasoline. Using leaded gasoline wilt cause --the converter to lose its effectiveness as an
emission control device. Leaded gasoline will also damage the Computer
Command Control, system oxygen sensor, which could affect emission control,
fuel economy . and drivability.
~,~.,y..'~,","~ ... :..., To help 'prevent damage:
1. Keep your engine properly maintained . Engine malfunctions involving the electrical, carburetion or ignition systems may result in unusually high
catalytic con verter and exhaust . sy~tem temperatures which, under
extreme malfunctioning conditions·, may ignite interior floor:"'covering
materials above the converter. Do not keep driving your vehicle if you
detect engine misfire, noticeable loss of performance ,or other unusual operating conditions. Instead. have it serviced promptly.
A properly maintained
engine will help avoid malfunctions that could damage
the converter.
~ will also help provide good emission control and fuel economy.
See the Maintenance Schedule , folder for information on inspecling and
maintaining the engine. exhaust system. and other components. .
2. Do not drive through or Idle or park your vehicle over combustible
materials, such as grass or leaves_ They could touch the hot exhaust
system and ignite.
3. Do not push or tow this vehiCle to start it. This may result in unusually
high catalytic converter and exhaust system temperatures which under
extreme conditions may ignite interior floor -covering material above the
converter.
Pushing or towing to start can also damage · the catalytic
converter itself.
Disregarding these
instructions could damage the cataly:tic converter. the
vehicle, or nearby property.
5-2

Downloaded from www.Manualslib.com manuals search engine Choosing Oil Viscosity
Engine oil viscosity (thickness) has an effect on fuel economy. Lower viscosity engine oils can provide· better fuel economy; however, higher temperature
weather cOl1ditions. require· higher viscosity .engine. oils· for satisfactory
lubrication.
It is recommended that you select an oil not only of the proper quality and
viscosity, but also. a fuel-saving product.· These oils can be found in Chevrolet dealer serviGe departments, service stati()ns and other retail stores. They are
identified by words such as: "Energy Conserving," "Energy Saving," "Conserves Gasoline," "Gas Saving," "Gasoline Saving," "Friction
Reducing," "Improved Gasoline Mileage," "Improved Fuel Economy" or "Fuel
Saving."
The following chart lists the engine oil viscosities recommended for the
tE3lT1per~ture range you·. expecLbefore your next oil change. For temperatures
above -18'C '(O'F), SAE 10W-30 is the preferred viscosity grade. If cold­weather starting problems are encountered at temperatures below -18'C
(O'F), SAE 5W-30 viscosity oils m?-y be required.
Change Intervals
The oil and oil filter change intervals for your engine are based on the use of SF-quality oils and high-quality filters such as AC oil filters. Using oils other
than
SF-quality, or oil and/or filter change intervals longer than recommended, could reduce engine life.
Damage to engines due to improper maintenance or use of incorrect oil quality
'andl0r"'vi$9()~ity}s .~ot covered by the Chevrolet new car warranties.
Your engine WEIS filled with a high-quality engine oil when it was built. You do
not have to change this oil before the first recommended change
interval.
•
Severe Service-Change the oil and oil filter every 3,000 miles (4 800
kilometers) or three months (whichevefcbmes first) if one or more of the following "severe service" conditions is often encountered:
• Driving in dusty areas.
• Towing a trailer.
• Frequent idling or idling for long periods.
• Oriving 4 miles (6 kilometers) or less in freezing weather.
• Change the oil and oil filter as soon as possible after driving in a dust storm.
~ Norma! Service-If your engine is not a turbo-charged engine and your
normal driving does not include one of the above "severe service" conditions, change the oil every 7,500 miles (12 000 kilometers) or 12
months, whichever comes first. Change the oil
filter at the first oil change,
then every other
oil change, if mileage (7,500 miles or 12 000 kilometers)
determines when you change the oil. If time (12 months) determines when
you change the oil, change the filter with every oil change.
• If you have a turbocharged engine, it is VERY IMPORTANT to change the
oil and oil filter EVERY 3,000 miles (4 800 kilometers).
5-4

Downloaded from www.Manualslib.com manuals search engine If the tires are other than standard load range (or load range B for metric size
tires). the
load range will appear after the tire size stated on the Tire Placard.
Inflation Pressure
The Cold inflation pressures listed on the Tire Placard provide for the best
balance of fuel economy. tire life. riding comfort. and vehicle handling under
normal driving conditions.
These pressures
should be used for all vehicle loading conditions. except When towing a trailer. See. "Trailer Towing in "Belore Driving Your Monte
Carlo." Section 1 of this manuaL
Incorrect tire inflation pressures can. have adverse effects on tire. lije and
vehicle performance. Too low an air preS$urecaul>eS incre f~lure,. It can result in tire overloading, abnormal tire wear, adverse vehicle handling. and reduced fuel~nomy .. Too high an air pressure can result in
abnormal wear. harsh ride. an.d can increase the chance of damage from road
hazards.
LUGGAGE/CARGO LOAD CAPACITY
Maximum Luggage Compartment Load
Coupe 72 Kilograms (160 Pounds)
"'"~~\"'_"~"""_'","",' NOTICE: Total combined weight of luggage _compartment 16ad •. ·.luggage rack load (when equipped). trailer tongue load and passengers must not exceed the vehicle capacity
weight (shown on the Tire Placard located on the left front door).
· ·' .L' Check tire inflation pressures at least monthly (this includes the spare tire) and whenever your _ vehicle is serviced. When -possible, check tire inflation pressures when'the tires are "cold."
1. The "cold" ttr~inflation pressure is the tire pressure when a vehicle has
not been driven more than one mile. (1.6 kilometers) after Sitting for three
hours or more. This is the most accurate setting.
2. It is normal for tire pressures to increase 30 to 60 kilopascals (4 to 8
pounds per square inch) or more when the tires become hot from driving. If you must set inflation pressures when the tires are not "cold," add 30
kilopascals
(4 pounds per square inch) to the recommended cold pressures on the Tire Placard.
3. For sustained driving at speeds of 75 mph to 85 mph (120 km/h to
140 km/h), in countries where such speeds are allowed by law, cold
inflation
pressures must be increased 20 kPa (3 psi) above the cold
inflation pressures stated on the tire placard up to the maximum for
each load range as listed in the Chart below. Sustained speeds of 75 mph to 85 mph (120 km/h to 140km/h) ar!! not allow!!d when the 20
kPa (3 psi) adjustment Would require the pressures of either the front or
the rear tiles to be greater than the maximum pressure for each load
range listed on the chart below. For speeds faster than 85 mph (140 km/h) follow Caution at th!! beginning of this "tire" section.
5-12

Downloaded from www.Manualslib.com manuals search engine AJt Cleaner. Ail CoricIitionor FOlK Season .. Mainten ance .. AM" Pressu-e. Tires. AM" Vents. Alterna tOf tGEN) l.ghl AUniIlUffi Cafe .. AM or AM-FM Radios Antenna Antifreeze . Appearaoc e Care . Ash1rays & Lignler s. Assistance. Owl"lef Automat ic Door Locks. Automatic Transmission CorwElfter ClUlch Maintenanr;e
"""'-OpefaJ .... '1 TiPS.: AKIe. Re ar Standard . lifnited-SHp . Babies. AesCraint 01 .. BaIt Joints .. fun..., E mergency S ta ring F reedom. Gas Caution ..• GEN 191I... .•.• Test Indicator ...
. ........ 5-9
2-24
5-11
5-12
2-23 ....... 2·17 ... 2:27. 2-28 2·29 (Seo "Coolant") ,.,
2·22 6·' ,.,
2·10 5-5 .. 2 -9 2 ·'
5 ·'
5·' 1·10. ,-" . 5·1 0
3 ·' 5-10 3·' 2-17 5·10 Betore Dr iving Your Vehide... \. Bells: Sea!....,.. . (See I'Se at Belts") Blower, Healer & Air Cond.. 2-24. 2-25
Body Da mage . 4-4
.. """ ~,. Pedal Travel Trailer Towing .... Warning Ught .
2·14 2-\4 H2 2-17
Breakers . <;ircui t. • ..... 2-21. 7·3 Bteak ..... Period. New Vehicle ..• 2·2 Srioj'!( Headlights 2·7. 2·21 Brighl Metal Cleaning 4-4
Bulbs & Fuses.. 7·3. 7-4 Bumpers & HiIC:·~s. '·13 ~ 'Jack Operation ...... 3-4 B.w:ers._ . (See "'SOunds'" CoirpJler Con"mand Cont rOl System:~ 2·\8, 5·3 Cop Coolant A ecovery Tant.: .. ................. , .. 5-6 F uel.. 5-2 f>o¥Iier Steefing.. _____ -._ ....... ...... 0<. _____ -5-9 Radiator ... 5·8 Capacity, Cargo Weight. 5-11 Capacities. FlUid:. 7- Car Break-In Period . New.. 2-2 . car -Chemicals ... carbon Monoxide cautJorI .... ___ 4·' 2·' Care & Cleaning. Appearance . . .. 4·' Cargo Capacity . 5-11 Cargo on Root . Carrying,. '·2 Catalytic Converter . . ..................... ....... 5-2 ~ Command Control System .. -2·18. , ·3 Chains. Tire .. 5·15
7-6
Changing Wheets & Tires .. _ Cl-£O< ENGtl'E light .. Chectlbt, DrillSf . Child Seals & Restr ainls Chrome Protection .. ag.yette lighter ... CirCUIt Beakers QtiZOtlS Band Raoio . C!earIing .. Clock.I .. Cloth Trim Care .. ClutCh . Converter
Cold W&ather Starting ....
3 ·4 . 3·5 2 ·18. 5-3 ,., I -tO. 1·11 ... 2·22 2·21 , 7·3 2·29 . ..... 4·' 2-22 '·2 2·10 2·8 ~ip""lt Plocedu.-e . . ... 6 ·1
Condi lioner, Air (See "All" Cooditioner"~ Cons umer Relation s ... Converter ClUtch Con...eJo: Mirror Cooling System Afltilreeze (CooIanI) .. Overheating R ecovery Tank Service,. Thermoslal . COfl"lefing Lights . CorTosion Pmlection. Countries. Oper-ating in Fo.-eign .. Courtesy lights CruISe Control Cus!omer Service . 5·6
3·3
3 ·4 ,
5·6 '·7 '·8 2·7 . . 4-5 2· ' 2·30
2·12
6·' Damage, Sheet Metal . 4·4 Detogger,Re..-WiNJoW.. 2-25 DelrOSlor. Windshield . 2·24. 2·25 Delay Wipers 2·20 Descending a· Grade 2-9 Ditlererlliai (Rear Axle) limited·Slip __ 5·9 ,Malt)l~O 5 ·9
Trailllfing. 1·1 2
Dimensions 7· , Oimn'\e( Switch, Head~L 2·14 O ipshCks A.utomalic Tfansmission .. . 5-4 Engine Oil 5·3 Power Steering. 5-9 Directional Signals.. 2-7 Disc Brakes 2·15 Door loc::ks . __ ................ 1-2 Orivet' Checklist 1-1 Driving Down S teep Grades .... 2-9 in OU'sty Areas . 5 .... on Slippery Surlaces .................... 2·9 Economy ripS. Fuel .............................. 2-4 E lectric· Po_oo QpIion$ .. (See "Power"') Electrical System Banerv .. S-1 0 Bulbs .. . ....... ...... .... ........... 7,4 Circuit Breakers ....... , ........................ , 7-3 Fuses:. 7·3 GEN (Genefalor) lighI ..................... 2· 17 Jump S tarting 3- Spark Plugs 7-2 Voltmeter . 2·19 Emetgency. In Case oj Bralle WCIIllWlg li!1Il .. Eroglne Hot light .. • .. 2·17 . 2·17

Downloaded from www.Manualslib.com manuals search engine Freeing Vehicle When Stuck . Hazard Warnong FlaSher Jacking Jump Starti ng
Towing: Cru EtIlIssion Caution EmISSic:m Control
3·9 3·' 3·4, 3'5
C ata lytic Conve rter 5-2 ~te< Command ContrOl System 2·18. ; ·3 CHECK ENGINE ligh t Exha ust Ga s Caution
F uel Requ irements (Gas) E",,~
2·18. 5·3 ,., , .,
... " Break -In Code Coo~ng
(See Ma intenance Schedule) 2·2 , .; ;·6 El ,.,
.. , 2·9 ,.,
(See "Fuel") ' ·5 . .. 3·1 Ideflti hcation Jump Starting . C>r Overheating . Spec~fcations Starling . Cold WeaHJeI Star ting (Gasoline) Temperature Gage Tempera ture 19h1 Thermostat E OOIN E ligh!
{See ··Oir . . EllIjne··) 3·3 ,., ,.,
'·6 2·t9 2· 17 5·6 2·t8 El"9oo Oil. (See ·'Oi l. E'ngine.') E thylene Glycot Antifree ze
E)(hausl Gas Cau tion E~~. System , If'Ispection. Ederior Fnsh Care .
Fabric Care
Fan,
Healer & Air Cond FASTEN SEAT BELTS Light. . Fastener s. RepIacemeflI .. Fifter s
Air Cleal'lEl!' . , Finish Care. Firish Damage . Flammable C\e.aoets .. .. F lashers Hazard w arning . Turn Signal..
Flooded EngIne . Starling . Floor Controls .. F luid Capacities .. FM Radios .. Folding Seats ...
5·' ,.,
, .,
... . 4·4 ,., 2-24. 2·25 '·6 5 ·'
;., ,., ,., . . • -1
3·.1 ..... 2:7 . ....... , 2·9 ......... 2·13 ..... ..... 7·1
F Ofeign CounlrllltS . Operation in ... FOUl' Season Ioit ~ . Four·WayHazard FlasheI' ... Freedom Battery .. Freeirig Car When Stt.JCk.". , .... Cop . Economy Tips .. Gogo Gasohol .. a...... Octane RaIing ..
;., , ., . 2 ·15 . '. ..... 2-3 ....... .. . 2-3
7 ·7
Overse3$ OpefatiOtl _. Tanl( Capacity Fuse
Cha rt
Circuit Breakers ...
""'" Engrne Temperat lJ'e
Fuel.. Oil Prossure Tachometef (Engille $peed) Voltmetet' , .. Gasoline
GEN (Gener ator) Light
Glas s Clea ning
Gto"e 80)( Guard AQaIIlSl Theft Hazar d Warning Flasher Headlight s Circuil &eakel IJimmtIf Switc h
instrument Pa~ SWitch Light s ON Reminder .. Head Restraint s .. tEAT Light. Heated Rear Wmdow .
2·' ,.,
'·3 '·3
2-1 9 2-15 2·19 2·18
2· 19
(See "Fuer') 2-\7 ..,
2-16 ,.,
3'
.7-3 2,14 2--?1
2-21
'·5 2·17 2·25 Heat er/Air Condihoner2·23. 2-24 High ·Beam Head~ghl!i 2-2t _ 1·13 5·10 . (Inside Back Colter) 5·10. !Inside Sack Cover)
Hitches. Traile( . Hood Latches .. Hood Release . Horn .. HOT UghL Ideotihcation Nt.mbers 19r>ilion K9YS Lock . In Case of EIT1efgenc:y .nocator lights ... Infant Seats & Aestra.nt .. II1l1ati04'l Pressure. Tires. Inlets . Air.
2-t3 2·t7 7.·5
,.,
2·' ,., (See "UghIS") 1 ·10. r_ll 5·12 2·23 Inside Rearview Muror , '-3 Instrumetl t Pan&! & Controts .. 2·15 InleilOl Appe«i¥1Ce Care.. 4-1 Interior & inst rumen t Lights (See "Lights" ) Jacl:: Operation & Stowage.. 3- 4. 3 ·5 . 3-6 ~ S\aI1ing .. 3- 1 Keys...... '·1 Lane Ct\ange &. Turn Signals 2-7 Lap- Shoulcler Belts . (See "Seat Bells") L_
,_­Hood ...
,..
(Inside 8acto: Cover) Sealback. From. 1-4 Trunk . 2-22 lighter. Cigarette ... 2·22 ligh<' BRAKE .... ...................... .................. 2·1 7
Bright s On. !lui> c.... O£CI( ENGINE Choke Warning .. Comoring .................. . CouttKY·· ClimrneI-Swoi1ch. HNdigflt .. Electrical S)Stem (GEN) ..
2-21 ,..
2·18.,5·2 2-17 .. ....... 2-7 '·30 2-1. 2-11